text
stringlengths 789
11.3k
| label
int64 0
1
| label_text
stringclasses 2
values |
|---|---|---|
* Exposure Controls/Personal Protection *
Respiratory Protection:IF TLV OF PRODUCT OR ANY COMPONENT EXCEEDED, USE
RESPIRATOR W/APPROPRIATE CARTRIDGES (NIOSH APPROVED). ENGINEERING
OR MANAGEMENT CONTROL SHOULD BE IMPLEMENTED TO REDUCE EXPOSURE.
Ventilation:LOCAL EXHAUST MUST BE SUFFICIENT TO KEEP AIRBORNE VAPOR
CONCENTRATION BELOW TLV.
Other Protective Equipment:CLEAN FLUSHING WATER SOURCE SUGGESTED.
IMPERVIOUS CLOTHING AS NEEDED.
Supplemental Safety and Health
NK
* Product Identification *
Preparer's Name:ONEY FLEMING
* Composition/Information on Ingredients *
Ingred Name:PETROLEUM (COAL OIL)
Other REC Limits:NONE RECOMMENDED
Other REC Limits:NONE RECOMMENDED
Ingred Name:NONHAZARDOUS INGREDIENTS
Other REC Limits:NONE RECOMMENDED
OSHA PEL:NOT EST.
ACGIH TLV:NOT EST.
Other REC Limits:NONE RECOMMENDED
OSHA PEL:NOT EST.
ACGIH TLV:NOT EST.
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES: IRRITATION, REDNESS, TEARING,
BLURRED VISION. SKIN: POSSIBLE IRRITATION, DEFATTING, DERMATITIS
W/PROLONGED/REPEATED EXPOSURE. INHALATION: NASAL/RESPIRATORY
IRRITATION, DIZZINESS, NAUSEA, HEADACH E. INGESTION: POSSIBLE
GASTROINTESTINALIRRITATION, NAUSEA, VOMITING.
Effects of Overexposure:IF TLV'S EXCEEDED, SKIN CONTACT PRODUCES
REDNESS. EYES: REDNESS/PAIN. INHALATION: LABORED BREATHING,
DULLNESS, DROWSINESS. INGESTION: ABDOMINAL PAIN, NAUSEA.
Medical Cond Aggravated by Exposure:RESPIRATORY DISEASES.
* First Aid Measures *
LIFTING EYELIDS. GET MEDICAL AID. SKIN: REMOVE CONTAMINATED
CLOTHING. WASH W/SOAP & WATER. INHALATION: GET FRESH AIR, GIVE
OXYGEN IF NECESSARY. GET MEDICAL AID. INGESTION: KEEP WARM,QUIET.
GET MEDICAL AID. DO NOT INDUCE VOMITING.
* Fire Fighting Measures *
Flash Point Method:TCC
Lower Limits:1.1
Upper Limits:6.0
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL, FOAM. WATER MAY
SPREAD FIRE, USE WATER SPRAY ONLY TO COOL CONTAINERS EXPOSED TO
FIRE.
Fire Fighting Procedures:SCBA (MSHA/NIOSH OR EQUIV.) & FULL PROTECTIVE
GEAR. PREVENT POSSIBLE PRESSURE BUILD-UP, AUTOIGNITION, EXPLOSION
TO EXTREME HEAT BY COOLING W/WATER SPRAY.
Unusual Fire/Explosion Hazard:VAPORS HEAVIER THAN AIR. MAY TRAVEL & BE
IGNITED BY PILET LIGHTS, OTHER FLAMES, SPARKS, HEATERS, SMOKING,
OTHER REMOTE IGNITION SOURCES.
* Accidental Release Measures *
Spill Release Procedures:VENTILATE AREA. COVER SPILL W/INERT ABSORBENT
MATERIAL & SHOVEL W/NON-SPARKING TOOLS INTO CONTAINER. REMOVE
CONTAINER TO SAFE AREA & SEAL.
Neutralizing Agent:NONE
*Handling and Storage *
Handling and Storage Precautions:STORE IN CLEAN, DRY AREA. KEEP AWAY
FROM SPARKS, FIRE, REMOTE IGNITION SOURCES.
Other Precautions:KEEP CONTAINER TIGHTLY CLOSED. KEEP AWAY FROM
CHILDREN. ALL EQUIPMENT SHOULD BE GROUNDED TO REDUCE STATIC
ELECTRICITY HAZARD. USE NONSPARKING TOOLS.
* Physical/Chemical Properties *
Melt/Freeze Pt:M.P/F.P Text:NA
Vapor Density:>AIR
pH:NA
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:NO
Appearance and Odor:BLUE LIQUID W/SLIGHT ODOR
Corrosion Rate:NA
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:DO NOT STORE NEAR HEATED SURFACES, OPEN
FLAMES, IGNITION SOURCES.
Hazardous Decomposition Products:THERMAL DECOMPOSITION MAY YIELD CARBON
DIOXIDE.
* Disposal Considerations *
Waste Disposal Methods:IN ACCORDANCE W/FEDERAL, STATE, LOCAL
REGULATIONS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:USE HYDROCARBON VAPOR CANISTER OR SUPPLIED AIR
RESPIRATOR IN CONFINED AREA.
ADEQUATE VENTILATION. MECHANICAL-EXPLOSION PROOF EQUIPMENT.
Other Protective Equipment:USE CHEMICAL RESISTANT APRONS OR CLOTHING.
Supplemental Safety and Health
NK
* Product Identification *
CAGE:OBRN9
CAGE:OBRN9
* Composition/Information on Ingredients *
Ingred Name:ODORLESS MINERAL SPIRITS
OSHA PEL:NONE ESTABLISHED
ACGIH TLV:NONE ESTABLISHED
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Health Hazards Acute and Chronic:OVEREXPOSURE-NAUSEA, HEADACHE,
DIZZINESS CAUSED BY OVER INHALATION. HIGH
IRRITATING TO THEEYES AND THE RESPIRATORY TRACT, ARE ANES THETIC,
AND MAY HAVE OTHER CENTRALNERVOUS SYSTEM EFFECTS.
Explanation of Carcinogenicity:NA
Effects of Overexposure:OVEREXPOSURE-NAUSEA, HEADACHE, DIZZINESS CAUSED
BY OVER INHALATION.
Medical Cond Aggravated by Exposure:NONE GENERALLY KNOWN.
* First Aid Measures *
SUBSIDES. IF IRRI- TATION PERSISTS CALL PHYSICIAN. SKIN CONTACT:
REMOVE CONTAMINATED CLOTHING AND WASH THOROUGHLY WITH SOAP AND
WATER. INH ALATION: IF OVERCOME BY VAPORS, REMOVETO FRESH AIR, CALL
A PHYSICIAN. INGESTION: DO NOT INDUCE VOMITING, CALL A
PHYSICIAN.
* Fire Fighting Measures *
Flash Point Method:SCC
Lower Limits:1
Upper Limits:6
Extinguishing Media:CARBON DIOXIDE, FOAM, WATER FOG, DRY CHEMICAL
Fire Fighting Procedures:USE AIR SUPPLIED BREATHING EQUIPMENT. COOL
ENCLOSED CONTAINERS WITH WATER SPRAY.AVOID BREATHING VAPORS OR
FUMES.
Unusual Fire/Explosion Hazard:IF LEAK OR SPILL HAS IGNITED, USE WATER
SPRAY TO DISPERSE THE VAPORS FROM FIRE FIGHTERS.
* Accidental Release Measures *
Spill Release Procedures:REMOVE ALL IGNITION SOURCES. KEEP FROM HEAT,
SPARK& OPEN FLAME. ADD ABSORBENT (SAND, EARTH, SAWDUST)TO SPILL.
VENTILATE AREA (OPEN WINDOWS, DOORS) IF LARGE SPILL KEEP FROM
ENTERING SEWERS AND WATER- COURSES BY DIKING. ADVISE AUTHORITIES
IF ENTERED.
Neutralizing Agent:NA
*Handling and Storage *
Handling and Storage Precautions:STORE AWAY FROM IGNITION SOURCES. KEEP
IN COOL, DRY, WELL VENTILATED AREAS. AVOID DIRECT SUNLIGHT AND
EXTREME TEMPERATURES, HOT OR COLD.
Other Precautions:AVOID EYE, SKIN CONTACT, INHALATION, INGESTION OF
MISTS, SPRAY OR VAPORS. AVOID BREATHING SANDING OR BLASTING
DUST.
* Physical/Chemical Properties *
pH:NA
Evaporation Rate & Reference:0.1 (BUTYL ACETATE=1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:SAND COLOR LIQUID WITH VERY LIGHT ODOR.
Corrosion Rate:NA
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
CAN REACT WITH OXIDIZING MATERIAL WHEN HEATED TO
DECOMPOSITION.
Stability Condition to Avoid:HIGH TEMPERATURE
Hazardous Decomposition Products:CARBON MONOXIDE
* Disposal Considerations *
Waste Disposal Methods:ASSURE CONFORMITY WITH APPLICABLE DISPOSAL
REGULA-TIONS. DISPOSE OF ABSORBED MATERIAL AT AN APPROVEDDISPOSAL
SITE OR FACILITY. DISPOSE IN CONFORMITY WITH STATE AND FEDERAL
REGULATIONS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:RESPIRATORY PROTECTION REQUIRED IF AIRBORNE
HIGH-EFFICIENCY PARTICULATE RESPIRATOR IS RECOMMENDED. ABOVE THIS
LEVEL;A NIOSH/MSHA APPROVED S CBA IS ADVISED.
Ventilation:USE GENERAL/LOCAL EXHAUST VENTILATION TO MEET TLV
REQUIREMENTS.
Other Protective Equipment:UNIFORM, APRON, EYEWASH & DELUGE SHOWER
Work Hygienic Practices:DO NOT GET IN EYES,ON SKN,ON CLTHNG.AVOID SPLAT
BY SLOW ADD TO SOLN.AVOID BRTH DUST.KEEP IN TGHT CLOS CNTNR.USE(SUP
DAT)
Supplemental Safety and Health
PH:N.FL PT MTD:N.WRK HYG PRAC:W/ADEQU VENT.WASH THOROU AFTER HAND.
PRODUCT CODES WHICH ARE BASED ON TYPE OF GRADE ARE AS
* Product Identification *
Product ID:SODIUM HYDROXIDE
* Composition/Information on Ingredients *
Ingred Name:SODIUM HYDROXIDE (SARA III)
Other REC Limits:N/K
OSHA PEL:2 MG/M3
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ROUTES OF ENTRY. EYES:YES ACCORDING TO
MFG; TLV & PEL IS 2 MG/M3. SEE SIGNS & SYMPTOMS OF OVEREXPOSURE
SECTION .
Explanation of Carcinogenicity:N/A
Effects of Overexposure:EXCESS INHAL OF DUST IS IRRI & MAY BE SEVER
DAMAG TO RESP PASSAGE &/LUNGS.CNTCT W/SKIN/EYES MAY CAUSE SEVERE
IRRI/BURNS.MAY CAUSE SEVERE BURN OF MOUTH & STOM. INGEST MAY CAUSE
NAUSEA & VOMITING.
Medical Cond Aggravated by Exposure:NONE IDENTIFIED
* First Aid Measures *
First Aid:CALL PHYS.EYES & SKIN:IMMED FLUSH EYES/SKIN W/LGE AMTS OF WTR
NOT INDUCE VOMIT; IF CONSCIOUS, GIVE LGE AMTS OF WTR. FOLLOW
W/DILUTED VI NEGAR, FRUIT JUICE/WHITE OF EGG,BEATEN W/WTR.
INHAL:RMV TO FRESH AIR.SUPPORT BREATHING (GIVE O*2/ARTIFICIAL
RESPIRATION).
* Fire Fighting Measures *
Extinguishing Media:USE EXTINGUISHING MEDIA APPROPRIATE FOR SURROUNDING
FIRE
Fire Fighting Procedures:FLOOD W/WTR; DO NOT SPLATTER/SPLASH THS MATL.
Unusual Fire/Explosion Hazard:CNTCT W/MOIST/WTR MAY GEN SUFFIC HEAT TO
IGN COMBUS MATL.REACTS W/MST METAL TO PRODUCE HYDROGEN GAS; WHCH
CAN FORM AN EXPLO MIXTURE W/AIR.
* Accidental Release Measures *
Spill Release Procedures:WEAR SCBA & FULL PROTECTIVE CLOTHING. WITH
CLEAN SHOVEL, CAREFULLY PLACE MATERIAL INTO CLEAN, DRY CONTAINER &
COVER. REMOVE FROM AREA. FLUSH SPILL AREA W/WTR.
Neutralizing Agent:J.T. BAKER NEUTRACIT-2 CAUSTIC NEUTRALIZER IS RECOMM
FOR SPLLS OF THS PRODUCT.
*Handling and Storage *
Handling and Storage Precautions:KEEP CONTAINER TIGHTLY CLOSED. STORE
IN CORROSION-PROOF AREA. STORE IN A DRY AREA. ISOLATE FROM
INCOMPATIBLE MATERIALS.
Other Precautions:N/K
* Physical/Chemical Properties *
HCC:C2
Solubility in Water:APPRECIABLE
Appearance and Odor:WHITE, ODORLESS SOLID.
Percent Volatiles by Volume:0
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
WTR;STRNG ACIDS;MST COMMON MTL;COMBUS MATL;ORGANIC
MATL;ZINC;ALUMINUM;MAGNESIUM;HALOGENATED HYDROCARBONS
Stability Condition to Avoid:MOISTURE
Hazardous Decomposition Products:N/K
* Disposal Considerations *
Waste Disposal Methods:DISPOSE IN ACCORDANCE WITH ALL APPLICABLE
FEDERAL, STATE, & LOCAL ENVIRONMENTAL REGULATIONS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:SELF-CONTAINED BREATHING APPARATUS FOR
CONCENTRATIONS ABOVE TLV LIMITS.
EXPLOSION PROOF VENTILATION EQUIPMENT. USE WITH ADEQUATE VENT.
Other Protective Equipment:EYE BATH AND SAFETY SHOWER. NEOPRENE APRON.
Supplemental Safety and Health
NO SMOKING, OPEN FLAMES OR LIGHT BULBS.
* Product Identification *
Product ID:ENAMEL, ALKYD SEMI-GLOSS
* Composition/Information on Ingredients *
Ingred Name:MINERAL SPIRITS (SOLVENTS)
Other REC Limits:NONE SPECIFIED
* Hazards Identification *
Health Hazards Acute and Chronic:SEVERE EYE IRRITATION, DRYING OF SKIN,
EXCESSIVE INHALATION CAUSES HEADACHE, DIZZINESS AND NAUSEA.
* First Aid Measures *
First Aid:EYE CONTACT: FLUSH WITH WATER. SKIN CONTACT: REMOVE PAINT
WITH MINERAL SPIRITS. THEN WASH WITH MILD SOAP AND WATER, AND APPLY
SKIN CREAM. INHALATION: REMOVE TO FRESH AIR AND CALL A PHYSICIAN.
APPLY AR TIFICIAL RESPIRATION IF NECESSARY.
* Fire Fighting Measures *
Flash Point Method:TCC
Lower Limits:1.1
Upper Limits:6.0
Extinguishing Media:FOAM CO2, DRY CHEMICALS, WATERSPRAY OR FOG.
Fire Fighting Procedures:USED AIR SUPPLIED RESCUE EQUIPMENT FOR
ENCLOSED AREAS. COOL EXPOSED CONTAINERS WITH WATER.
Unusual Fire/Explosion Hazard:KEEP AWAY FROM HEAT, SPARKS OR OPEN
FLAME.
* Accidental Release Measures *
Spill Release Procedures:KEEP PEOPLE AWAY. REMOVE ALL SOURCES OF
IGNITION AND PROVIDE VENTILATION. LARGE SPILLS MAY BE SCOOPED UP
WITH NON-SPARKING TOOLS. AVOID EXPOSURE TO SPARKS, FIRE OR HOT
METAL SURFACES. AVOID BREATHING VAPORS.
*Handling and Storage *
Handling and Storage Precautions:KEEP CONTAINERS CLOSED. USE WITH
ADEQUATE VENTILATION. GROUND CONTAINERS. LIMIT FREE FALL TO A FEW
INCHES TO PREVENT STATIC SPARKS.
Other Precautions:IMMERSE SPRAY BOOTH CLEANINGS (ACCUMULATION)
IMMEDIATELY IN WATER. AVOID PROLONGED OR REPEATED CONTACT WITH THE
SKIN.
* Physical/Chemical Properties *
Vapor Density:4.0
Solubility in Water:NEGLIGIBLE
Appearance and Odor:GRAY AND/OR WHITE VISCOUS LIQUID OF MINERAL SPIRITS
ODOR.(LIGHT)
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS WILL DISSOLVE OR SOFTEN SOME PLASTICS & RUBBER.
Stability Condition to Avoid:HEAT, SPARKS, OPEN FLAME AND FIRE.
Hazardous Decomposition Products:THERMAL DECOMPOSITION MAY YIELD CARBON
MONOXIDE, CO2, AND POSSIBLE ACROLEIN.
* Disposal Considerations *
Waste Disposal Methods:PLACE IN CLOSED CONTAINERS. RAGS & ABSORBENT
MATERIALS SHOULD BE IMMEDIATELY IMMERSED IN WATER. DISPOSE OF IN
ACCORDANCE WITH LOCAL, STATE AND FEDERAL REGULATIONS. NOTIFY FIRE
AND HEALTH AGENCIES.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Ventilation:NORMAL
Supplemental Safety and Health
* Product Identification *
Product ID:TOR GERMICIDAL DETERGENT
* Composition/Information on Ingredients *
Ingred Name:N-ALKYL DIMETHYL BENZYL AMMONIUM CHLORIDE
Fraction by Wt: 1.6%
Ingred Name:N-ALKYL DIMETHYL ETHYL BENZYL AMMONIUM CHLORIDE
Fraction by Wt: 1.6%
* Hazards Identification *
Effects of Overexposure:EYES/SKIN: MAY CAUSE IRRITATION. INGESTION: MAY
BE HARMFUL IF SWALLOWED.
* First Aid Measures *
First Aid:INHALATION: MOVE TO FRESH AIR. SKIN/EYES: FLUSH WITH WATER
INGESTION: DRINK WATER/MILK. AVOID ALCOHOL. CALL A PHYSICIAN
IMMEDIATELY
* Fire Fighting Measures *
Flash Point:NONE
Fire Fighting Procedures:NONE
Unusual Fire/Explosion Hazard:NONE
* Accidental Release Measures *
Spill Release Procedures:MOP UP. RINSE WITH WATER. FLUSH DOWN DRAIN.
*Handling and Storage *
SKIN OR ON CLOTHING.
Other Precautions:RINSE CONTAINER THOROUGHLY AND DISCARD IT. AVOID
CONTAMINATION OF FOOD. KEEP AWAY FROM CHILDREN.
* Physical/Chemical Properties *
Evaporation Rate & Reference:(WATER = 1): 1
Appearance and Odor:GREEN FREE FLOWING LIQUID, SASSAFRAS
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
ACIDS
Stability Condition to Avoid:NONE
Hazardous Decomposition Products:NONE
* Disposal Considerations *
Waste Disposal Methods:FLUSH DOWN DRAIN. LARGE AMOUNTS TO SANITARY
LANDFILL.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NONE
Ventilation:LOCAL EXHAUST
Supplemental Safety and Health
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:NON-HAZARDOUS FOR INGREDIENTS
* Hazards Identification *
Effects of Overexposure:AVOID EYE CONTACT; MAY CAUSE EYE IRRITATION.
* First Aid Measures *
First Aid:IN CASE OF CONTACT IMMEDIATELY FLUSH EYES W/PLENTY OF WATER
CLOTHING BEFORE REUSE. IF SWALLOWED, GIVE LARGE QUANTITIES OF WATER
OR F RUIT JUICE. CALL A PHYSICIAN IMMEDIATELY.
* Fire Fighting Measures *
Flash Point:NONE
Fire Fighting Procedures:NON FLAMMABLE
* Accidental Release Measures *
Spill Release Procedures:FLUSH WITH WATER TO SANITARY SEWER SYSTEM.
*Handling and Storage *
Handling and Storage Precautions:NOTHING SPECIAL
* Physical/Chemical Properties *
Evaporation Rate & Reference:(BU AC = 1) <1
Solubility in Water:COMPLETE
Appearance and Odor:BLUE, CITRUS ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
NONE
Hazardous Decomposition Products:NONE
* Disposal Considerations *
Waste Disposal Methods:FLUSH W/WATER TO SANITARY SEWER SYS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:IF >TLV, PROVIDE NIOSH APPROVED RESPIRATORS.
Ventilation:PROVIDE LOCAL EXHAUST VENTILATION TO KEEP BELOW TLV
Other Protective Equipment:AS REQUIRED
Supplemental Safety and Health
ALUMINUM.
* Product Identification *
Product ID:ITW DRILLS & END MILLS
* Composition/Information on Ingredients *
Ingred Name:COBALT (SEE SUPPLEMENTAL FOR INGREDIENTS)
Fraction by Wt: 0-8%
ACGIH TLV:0.1 MG/CUM
Ingred Name:CHROMIUM (SARA III)
Fraction by Wt: 4.2%
OSHA PEL:1 MG/M3
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:IRON ION (FE +2)
OSHA PEL:1 MG/M3 (FE)
Ingred Name:MANGANESE (SARA III)
OSHA PEL:(C) 5 MG/M3 DUST
Ingred Name:NICKEL
ACGIH TLV:1 MG/CUM
* Hazards Identification *
Effects of Overexposure:METALLIC TASTE; NAUSEA, TIGHTNESS OF CHEST;
FEVER; IRRIT OF EYES, NOSE, THROAT & SKIN, DEATH.
* First Aid Measures *
First Aid:INHALATION: REMOVE TO FRESH AIR, CONSULT PHYS. EYE: FLUSH
W/WATER. GET MEDICAL ATTENTION. SKIN: BRUSH OFF EXCESS DUST. WASH
AREA WELL W/SOAP & WATER. INGESTION: SEEK MEDICAL HELP IF LARGE
QUANTITES OF MATERIAL HAVE BEEN INGESTED.
* Fire Fighting Measures *
Flash Point:NONE
Fire Fighting Procedures:NONE
Unusual Fire/Explosion Hazard:NONE
*Handling and Storage *
Handling and Storage Precautions:USE GOOD HOUSEKEEPING PRACTICES TO
PREVENT ACCUMULATIONS OF DUSTS & TO KEEP AIRBORNE DUST CONCTRATIONS
AT A MINIMUM.
Other Precautions:THIS MATERIAL IS POTENTIALLY CONTAMINATED WITH
COATINGS SUCH AS OILS FOR PRESERVATIVES & OTHER CONTAMINANTS. IF
THE MATERIALS CONTAMINATED,
* Physical/Chemical Properties *
Spec Gravity:8.2
Solubility in Water:INSOLUBLE
Appearance and Odor:VARIOUS SHAPES, SOLID, METAL ODORLESS
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
REACTS WITH STRON ACIDS TO GENERATE HYDROGEN GAS
Hazardous Decomposition Products:METALLIC OXIDES
* Disposal Considerations *
Waste Disposal Methods:SOLIDS-SALE AS SCRAP FOR REUSE. DUST,
ETC.-FOLLOW FEDERAL, STATE AND LOCAL REGULATIONS REGARDING
DISPOSAL.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN .
Ventilation:LOCAL AND GENERAL VENTILATION NECESSARY TO KEEP AIR
CONCENTRATION BELOW LEVEL OF CONCERN .
Other Protective Equipment:FOR PROLONGED &/OR REPEATED SKIN EXPOSURE
APPROP IMPERVIOUS CLOTHING IS REQUIRED(BOOT,PANTS,COAT,FACE
PROTECTION,ETC).
Work Hygienic Practices:N/K
Supplemental Safety and Health
* Product Identification *
Product ID:FUEL OIL NO.4 AND NO.5
Preparer's Name:JAMES EHRMAN
* Composition/Information on Ingredients *
Ingred Name:HEATING OIL,PETROLEUM HYDROCARBON,FUEL OIL #4 & #5.
Other REC Limits:N/K
OSHA PEL:N/K
ACGIH TLV:N/K
* Hazards Identification *
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:DANGER-HARMFUL OR FATAL IF SWALLOWED.
POLYNUCLEAR AROMATIC HYDROCARBONS PRESENT IN THE OIL (MFR).
Effects of Overexposure:EYES:IRRITATION.SKIN:N/K .INGESTION:NO ACUTE
EFFECT.ASPIRATION HAZARD-DO NOT ALLOW LIQUID TO ENTER
LUNGS,CHEMICAL PNEUMONIA MAY RESULT.INHALATION:NO RECORDED EFFECTS
AT AMBIENT TEMPERATURES .
Medical Cond Aggravated by Exposure:N/K
* First Aid Measures *
MINUTES,LIFTING LIDS OCCASIONALLY.IF EYE IRRIT PERSISTS,GET MED
ATTN.SKIN:REMOVE CONTAM CLOTHING.WASH SKIN THOROUGHLY W/ SOAP &
WATER.INGEST: ASPIRATION HAZ.DO NOT INDUCE VOMIT.GET MED
ATTN.INHAL:REMOVE TO FRESH AIR.IF BREATHING STOPS IMMEDIATELY START
ARTIFICIAL RESPIRATION,MOUTH TO MOUTH WHILE HOLDING PERSON'S NOSE
CLOSED.GET MED ATTN.
* Fire Fighting Measures *
Flash Point Method:CC
Lower Limits:APPROX 7.5%
Upper Limits:APPROX 0.6%
Extinguishing Media:DRY CHEMICAL,FOAM,CO*2,WATER SPRAY.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .WATER SPRAY RECOMMENDED TO COOL FIRE EXPOSED
SURFACES & TO PROTECT PERSONNEL.
Unusual Fire/Explosion Hazard:LIMIT WATER ENTRY INTO BURNING OIL
STORAGE.ANTICIPATE BOIL-OVER FROM STORAGE TANK & KEEP PERSONNEL &
EQUIP AT SAFE DISTANCE.USE FOAM.HAZ DECOMP PROD-CO.
* Accidental Release Measures *
Spill Release Procedures:SMALL SPILLS-CLEAN BY USING OIL
ABSORBENT.LARGE SPILLS-FLUSH TO APPROVED OIL SEWER OR DIKE AREA &
PUMP TO SALVAGE TANK.CLEAN REMAINING RESIDUE USING DETERGENT & THEN
FLUSH WITH WATER.
Neutralizing Agent:N/K
*Handling and Storage *
Handling and Storage Precautions:CLASS IIIA COMBUSTIBLE LIQUID STORAGE
IS INDICATED BUT HEATED STORAGE IS COMMON & SUFFICIENT VAPORS MAY
BE PRESENT TO INITIATE FIRE OR EXPLOSION.
Other Precautions:WHEN MATERIAL IS HEATED,THERMAL BURNS MAY RESULT UPON
CONTACT.COMBUSTIBLE.KEEP FROM HEAT & OPEN FLAME.AVOID BREATHING
MIST OR VAPOR.AVOID SKIN CONTACT.DO NOT REUSE EMPTY CONTAINER FOR
OTHER PRODUCTS.
* Physical/Chemical Properties *
Melt/Freeze Pt:M.P/F.P Text:N/K
Decomp Temp:Decomp Text:N/K
Vapor Pres:SEE SUPP
Spec Gravity:<1 (WATER=1)
Solubility in Water:<0.1%
Appearance and Odor:DARK BROWN LIQUID.KEROSENE-LIKE ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS MAY IGNITE THIS MATERIAL.
Stability Condition to Avoid:HIGH HEAT,SPARKS,OPEN FLAME.
Hazardous Decomposition Products:CARBON MONOXIDE
Conditions to Avoid Polymerization:WILL NOT OCCUR.
* Disposal Considerations *
Waste Disposal Methods:DISPOSAL MUST BE IN ACCORDANCE WITH
FEDERAL,STATE AND LOCAL REGULATIONS .
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:IF EXPOSURES EXCEED ESTABLISHED LIMITS, A
NIOSH/MSHA APPROVED RESPIRATOR FOR ASBESTOS SHOULD BE USED.
CONSULT YOUR SAFETY OFFICE/IH PERSONNEL FOR GUIDANCE FOR THE TASK
AT HAND.
Ventilation:LOCAL EXHAUST IS RECOMMENDED IN SITUATIONS WHERE DUST IS
GENERATED BY ABRASIVE ACTIONS, ABRASION OR OTHER MEANS.
Other Protective Equipment:AS REQUIRED FOR TASK AT HAND, AND THE
GUIDANCE SET FORTH BY YOUR SAFETY OFFICE OR IH PERSONNEL
Work Hygienic Practices:DONOT INHALE DUST CREATED BY ABRADING ACTIONS.
USE FULL PROTECTION AGAINST AIRBORNE FIBERS. AVOID AIRBORNE DUST
CREATION
Supplemental Safety and Health
GENERIC "MSDS" CREATED FOR "NSN" IDENTIFIED BY "DISC" AS CONTAINING
ASBESTOS.WHEN A MANUFACTURER'S SPECIFIC "MSDS" IS PROVIDED FOR
MATERIAL PROCURED UNDER THIS NSN, THIS GENERIC "MSDS" WILL BE
REMOVED.
* Product Identification *
Preparer's Name:DOD HMIS/DGSC-SSH
* Composition/Information on Ingredients *
Ingred Name:ASBESTOS, CHRYSOTILE
OSHA PEL:0.2 FIBERS/CC
Ingred Name:ASBESTOS & RUBBER OVERALL COMPOSITION
Ingred Name:GENERIC "MSDS". SPECIFIC ASBESTOS TYPE NOT KNOWN. ONE
CITED IS ASSUMED. INFORMATION BASED ON SEGMENT "M" OF "DLSC TIR"
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:ACUTE: NO ACUTE EFFECTS ARE KNOWN;
CHRONIC: DUST FROM ABRASIVE ACTIONS(EG. CUTTING, MACHINING,
FILING, ETC.) MAYCONTAIN ASBESTOS FIBERS. CHRONIC OVEREXPOSURE
TO AIRBORNE FIBERS MAY LEAD TO ASBESTOSIS & MESOTHELIOMA.
SMOKINGCOMBINED W/FIBER INHALATION GREATLY INCREASES LUNG
CANCER RISK!
Explanation of Carcinogenicity:OVEREXPOSURE TO AIRBORNE CONCENTRATIONS
OF ASBESTOS MAY LEAD TO ASBESTOSIS AND MESOTHELIOMA.
Effects of Overexposure:INHAL: INHALATION OF AIRBORNE DUST CONTAINING
ASBESTOS FIBERS ON REPEATED EXPOSURE MAY CAUSE OR CAN LEAD TO
ASBESTOSIS/ MESOTHELIOMA; SKIN: N/K; EYE: POTENTIAL IRRITATION
FROM AIRBORNE DUST; INGEST: N/K.
Medical Cond Aggravated by Exposure:RESPIRATORY DEFICIENCIES DUE TO
REPEATED INHALATION OF AIRBORNE FIBERS.
* First Aid Measures *
First Aid:INHAL: REMOVE TO FRESH AIR. OBTAIN MEDICAL ADVICE; SKIN:
WASH EXPOSED AREA WITH SOAP & WATER; EYE: FLOOD W/ WATER. IF
IRRITATION OCCURS, GET MEDICAL ATTN; INGEST: CONSULT A
PHYSICIAN; OTHER: CHANGE CLOTHING AS REQUIRED TO AVOIDCARRYING
DUST PARTICLES INTO OTHER AREAS
* Fire Fighting Measures *
Flash Point:NONE
Extinguishing Media:MATERIAL IS NOT FLAMMABLE ; USE MEDIA APPROPRIATE
FOR SURROUNDING FIRE.
Fire Fighting Procedures:COMBUSTION PRODUCTS OF THIS MATERIAL MAY BE
TOXIC. USE A SELF-CONTAINED BREATHING APPARATUS WHEN FIGHTING FIRES
INVOLVING CHEMICAL PRODUCTS.
Unusual Fire/Explosion Hazard:NONE KNOWN
* Accidental Release Measures *
Spill Release Procedures:USE PROPER PERSONAL PROTECTION. VACUUM OR WET
CLEAN IF DUST IS INVOLVED. ANY VACUUM SYSTEM SHOULD BE EQUIPPED W/
AN OUTLET "HEPA" FILTER TO PREVENT REINTRODUCING ASBESTOS FIBERS TO
THE ATMOSPHERE.
*Handling and Storage *
Handling and Storage Precautions:HANDLE IN A MATTER TO MINIMIZE
FORMATION OR RETENTION OF AIRBORNE DUST. USE PROPER PERSONAL
PROTECTION FOR TASK AT HAND. CHECK W/YOUR SAFETY OFFICE!!!
Other Precautions:AS MANUFACTURED, LOCKED-IN ASBESTOS DOES NOT PRESENT
A HAZARD. ONLY WHEN THE ITEM IS SUBJECTED TO ABRASIVE ACTIONS &
DUST IS GENERATED, THEN ASBESTOS FIBERS MAY BE RELEASED & BECOME
AIRBORNE.
* Physical/Chemical Properties *
HCC:T6
Evaporation Rate & Reference:NONE
Solubility in Water:NOT SOLUBLE
Appearance and Odor:MANUFACTURED COMMODITY DESCRIBED BY LOGISTICS:
"ITEM-NAME"
Percent Volatiles by Volume:NONE
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
NONE KNOWN
Stability Condition to Avoid:NONE KNOWN
* Disposal Considerations *
Waste Disposal Methods:DUST SHOULD BE HANDLED AS A HAZARDOUS AIR
LANDFILLS APPROVED FOR ASBESTOS DISPOSAL. NOTE IF ITEM UNDER
CONSIDERATION FOR DISPOSAL IS "FRIABLE OR NON-FRIABLE".
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NONE REQUIRED UNDER NORMAL PRODUCT USAGE.
Ventilation:NONE REQUIRED UNDER NORMAL PRODUCT USAGE.
Other Protective Equipment:NONE REQUIRED UNDER NORMAL PRODUCT USAGE.
Work Hygienic Practices:GOOD PERSONAL HYGIENE SHOULD BE PRACTICED.
Supplemental Safety and Health
* Product Identification *
Preparer's Name:DALI M AREN
* Composition/Information on Ingredients *
Ingred Name:NON-HAZARDOUS FOR INGREDIENTS
* Hazards Identification *
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Explanation of Carcinogenicity:NONE
* First Aid Measures *
First Aid:OBTAIN MEDICAL ATTENTION IN ALL CASES.
* Fire Fighting Measures *
Extinguishing Media:IF PRODUCT BECOMES INVOLVED IN A FIRE SITUATION ANY
EXTINGUISHING MEDIA USED DURING FIRE FIGHTING WILL BE COMPATIBLE.
* Accidental Release Measures *
Spill Release Procedures:MAY BE SWEPT UP & DISPOSED OF W/NORMAL LAB
TRASH.
* Physical/Chemical Properties *
Solubility in Water:INSOLUBLE
Appearance and Odor:PAPER DISCS OF VARIABLE COLOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
* Disposal Considerations *
Waste Disposal Methods:MAY BE DISPOSED OF W/NORMAL LAB TRASH.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:USE NIOSH/MSHA APPROVED OR EQUIVALENT
CHEMICAL/MECHANICAL FILTERS DESIGNED TO REMOVE COMBINATION OF
PARTICULATES & ORGANIC VAP IN OPEN & RESTRICTED VENT AREAS. USE
NIOSH/MSHA APPRVD AIRLINE TYPE RESPS /HOODS IN CONFINED AREAS.
Ventilation:SUFFICIENT VENT, IN PATTERN & VOL, SHOULD BE PROVIDED TO
KEEP AIR CONTAM CONC BELOW APPLIC EXPOS LIMS. HEAVY (ING 9)
Other Protective Equipment:EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET
Work Hygienic Practices:WASH HANDS BEFORE EATING, SMOKING/USING WASH
ROOM. DO NOT SMOKE IN ANY CHEM HNDLG/STOR AREA. FOOD/BEVERAGES (ING
Supplemental Safety and Health
EXPLO HAZ:SUCH CNTNRS TO FLAME; THEY MAY EXPLODE & CAUSE INJURY/DEATH.
MFR'S SFTY PRECS HAVE BEEN READ & UNDERSTOOD. DO NOT WELD/FLAME
-CUT EMPTY DRUM. AVOID BRTHG SANDING DUSTS. NOTE:THESE PRODS MAY
ALSO CONTAIN TITANIUM DIOXIDE, BENTONITE CLAYS/ (ING 6)
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:KEROSENE (PETROLEUM), HYDROTREATED; (MINERAL SPIRITS
(STODDARD SOLVENT))
Ingred Name:TITANIUM OXIDE; (TITANIUM DIOXIDE)
Ingred Name:SILICA, CRYSTALLINE - QUARTZ; (SILICA)
Fraction by Wt: >0.1%
OSHA PEL:N/K
ACGIH TLV:0.1 MG/M3 RDUST
Ingred Name:CALCIUM CARBONATE
Ingred Name:ALKYD RESIN; (ALKYD RESIN SOLIDS)
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:SUPDAT:OTHER PIGMENTS CLASSIFIED AS "NUISANCE DUSTS".
NORMAL APPLICATION PROCS POSE NO HAZ SINCE SILICAS IS WET &(ING 7)
Ingred Name:ING 6:ENCAPSULATED, BUT GRINDING/SANDING DRIED FILMS MAY
YIELD RESPIRABLE SILICA DUSTS. CONTROL EXPOS TO (ING 8)
Ingred Name:ING 7:<0.1 MG/M2 USING NIOSH/MSHA APPROVED DUST FILTER
RESPIRATORS.
Ingred Name:VENT:SOLV VAPS SHOULD BE REMOVED FROM LOWER LEVELS OF WORK
Ingred Name:ING 9:SHOULD BE ELIMINATED IF FLAMM/AIR MIXTS WILL BE
Ingred Name:EYE PROT:& FULL LENGTH FACESHIELD .
Ingred Name:OTHER PROT EQUIP:CLTHG CONTAM IS LIKELY. USE PROT CREAM IF
SKIN CONT IS LIKELY. USE APRON/OTHER APPROP EQUIP.
Ingred Name:HYGIENE PRACT:SHOULD NOT BE CONSUMED ANYWHERE THIS PRODUCT
IS HANDLED OR STORED.
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ACUTE:ANESTH. IRRIT. MAY CAUSE HDCH &
NAUS. IRRIT OF RESP TRACT/CNS DEPRESS CHARACT BY FOLLOWING
PROGRESSIVE STEPS:HDCH, DIZZ, STAG GAIT, CONFUSN, UNCON/COMA.
NOTE:INTENTIONAL MISUSE BY DELIB CONC & I NHAL FUMES MAY BE
HARMFUL/FATAL. CHRONIC:MAY CAUSE RESP SENSIT, LIVER/KIDNEY DMG. MAY
CAUSE SKIN (EFTS OF OVEREXP)
Explanation of Carcinogenicity:SILICA, CRYSTALLINE-QUARTZ:IARC
CARCINS, (SUPDAT)
Effects of Overexposure:HLTH HAZ:SENSITIZATION. PERMANENT CENTRAL
NERVOUS SYSTEM CHANGES CAN OCCUR BECAUSE OF SOLVENT EXPOSURE.
Medical Cond Aggravated by Exposure:RESPIRATORY ALLERGIES. CHRONIC
DISEASES OF THE SKIN, NOSE, THROAT & LUNGS, CENTRAL NERVOUS SYSTEM,
LIVER, KIDNEY, BLOOD, EYES.
* First Aid Measures *
First Aid:INHAL:MOVE PERS TO FRESH AIR. RESTORE BRTHG. TREAT
SYMPTOMATICALLY. CONSULT MD. EYES:FLUSH IMMED W/LG AMTS OF WATER
AFFECTED AREAS W/SOAP & WATER. REMOVE CONTAM CLTHG. CONSULT MD IF
IRRIT PERSISTS. INGEST:CALL MD IMMED. NEVER GIVE ANYTHING BY MOUTH
TO UNCON PERS. TREAT SYMPTOMATICALLY.
* Fire Fighting Measures *
Flash Point Method:SCC
Lower Limits:1.1%
Upper Limits:5.9%
Extinguishing Media:FOAM, DRY CHEMICAL OR CARBON DIOXIDE.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT . COOL EXPOSED CONTAINERS W/WATER SPRAY. MINIMIZE
BREATHING VAPOR OR FUMES.
Unusual Fire/Explosion Hazard:DO NOT MIX/STORE W/STRONG OXIDANTS SUCH
AS LIQ CHLORINE/CONC OXYGEN. "EMPTY" PROD CNTNRS RETAIN PROD
RESIDUE. DO NOT PRESSURIZE, CUT, HEAT, WELD/EXPOSE (SUPDAT)
* Accidental Release Measures *
Spill Release Procedures:REMOVE ALL SOURCES OF IGNIT (FLAME, HOT SURFS
& ELEC, STATIC/FRICTIONAL SPKS). AVOID BRTHG VAPS. USE NIOSH/MSHA
APPRVD SELF-CNTND BRTHG EQUIP. VENTILATE AREA. CONTAIN & REMOVE
W/INERT ABSORB MATL & NO N-SPARKING TOOLS. AVOID CONTACT.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:DO NOT STORE/USE NEAR HEAT/OPEN FLAME.
DO NOT GET IN EYES. AVOID SKIN CONTACT.
Other Precautions:KEEP CLOSURE TIGHT & CNTNR UPRIGHT TO PVNT LEAKAGE.
DRUMS OF THIS MATL SHOULD BE GROUNDED & BONDED WHEN POURING. DO NOT
WELD/FLAME-CUT EMPTY DRUM. CAN CAUSE ALLERGIC RESP/SKIN RXN. PVNT
PRLNG/RPTD BRT HG OF VAP/SPRAY MIST. DO NOT (SUPDAT)
* Physical/Chemical Properties *
Vapor Density:HVR/AIR
Spec Gravity:VARIES W/PROD
Solubility in Water:NIL
Appearance and Odor:VISCOUS LIQUID SLIGHT PETROLEUM ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
AMINES, ACIDS, HYDROXYL OR OTHER ACTIVE HYDROGEN COMPOUNDS.
Stability Condition to Avoid:HIGH TEMPERATURES.
Hazardous Decomposition Products:NONE SPECIFIED BY MANUFACTURER.
* Disposal Considerations *
REFER TO HAZARD INFO IN OTHER SECTIONS OF MSDS. USE LICENSED
HAZARDOUS WASTE DISPOSAL CO NCERN.
| 1 | eyes_protection_mandatory |
Control Measures
*
*
Contractor Summary
*
*
Ingredients
*
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
------------------------------
OSHA PEL: 0.1 MG/M3 RDUST(MFR)
ACGIH TLV: 0.1 MG/M3 RDUST
------------------------------
DISTILLATES)
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
------------------------------
OSHA PEL: 5 MG/M3 (MFR)
------------------------------
HYDROTREATED MIDDLE DISTILLATE)
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
------------------------------
% Wt: 1-5
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
------------------------------
% Wt: 1-5
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
-----------------------------
% Wt: 1-5
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
------------------------------
% Wt: 0.1-1
------------------------------
-----------------------------
INCL PARTICLES SO SM THAT THEY CANNOT BE SEEN.
-----------------------------
PLACE IN A U.S. DOT-APPROVED CONTAINER & SEAL.
-----------------------------
-----------------------------
-----------------------------
*
Health Hazards Data
*
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: YES
Carcinogenicity Inds - NTP: YES
IARC: YES
OSHA: NO
Effects of Exposure: EYE CONT:MOD IRRIT:SIGNS/SYMPS CAN INCLUDE REDNESS, SWELL,
PAIN, TEARING & HAZY VISION. SKIN:MILD IRRIT (AFTER PRLNG/RPTD
CONT):SIGNS/SYMPS CAN INCL REDNESS, SWELL & ITCH. INHAL:IRRIT (UPPER
RESP)SIGN S/SYMPS CAN INCL SORENESS OF NOSE & THROAT, COUGH &
SNEEZING. WHILE FOLLOWING EFTS ARE ASSOC W/ONE/MORE(EFTS OF OVEREXP)
Explanation Of Carcinogenicity: SILICA, CRYSTALLINE-TRIPOLI:IARC MONOGRAPHS,
Signs And Symptions Of Overexposure: HLTH HAZ:OF INDIVIDUAL INGS IN THIS PROD
& ARE REQD TO BE INCL ON MSDS BY U.S. OSHA HAZ COMMUNICATION STD, THEY
ARE NOT EXPECTED EFTS DURING FORESEEABLE USE OF THIS PROD. SILICOSIS:
SIGNS/SYMPS:CAN IN CL SHORTNESS OF BREATH & PERSISTENT COUGH. INGEST:MAY
CAUSE:GI EFTS: SIGNS/SYMPS CAN INCL COUGH, DFCLTY BRTHG, (SUPDAT)
Medical Cond Aggravated By Exposure: NONE SPECIFIED BY MANUFACTURER.
MINUTES. GET IMMEDIATE MEDICAL ATTENTION. SKIN:FLUSH W/LARGE AMOUNTS OF
WATER. IF IRRITATION PERSISTS, GET MEDICAL ATTENTION. INHAL:REMOV E PERSON TO
FRESH AIR. IF SIGNS/SYMPTOMS CONTINUE, CALL MD. INGEST:CALL MD IMMEDIATELY.
ONLY INDUCE VOMITING AT INSTRUCTION OF MD. NEVER GIVE ANYTHING BY MOUTH TO AN
UNCONSCIOUS PERSON.
*
Handling and Disposal
*
Spill Release Procedures: REFER TO OTHER SECTIONS OF THIS MSDS FOR INFO
REGARDING PHYSICAL & HLTH HAZS, NIOSH/MSHA APPRVD RESP PROT, VENT &
ASSISTANCE. E XTING ALL IGNIT SOURCES. COVER W/ABSORB
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: INCIN IN INDUS/COMMERCIAL FACILITY IN PRESENCE OF
COMBUST MATL. ABSORBED WASTE PROD MAY ALSO BE INCIN IN INDUS/COMMERCIAL
FACILITY IN PRESENCE OF COMBUST MATL. SINCE REGS VARY, CONSULT APPLIC FED,
STA TE & LOC REGS/AUTHS BEFORE DISPOSAL.
Handling And Storage Precautions: AVOID EYE CONT. AVOID PRLNG/RPTD SKIN CONT.
USE IN WELL-VENTILATED AREA. AVOID BRTHG OF VAPS. DO NOT INGEST. STORE AT
Other Precautions: AVOID BRTHG OF DUST CREATED BY CUTTING, SANDING/GRINDING.
KEEP CNTNR CLSD WHEN NOT IN USE. KEEP OUT OF REACH OF CHILDREN. KEEP CNTNR
TIGHTLY CLSD. KEEP AWAY FROM HEAT, SPKS, OPEN FLAME & OTHER SOURCES OF
IGNIT. COMBUSTIBLE LIQUID & VAPOR.
*
Fire and Explosion Hazard Information
*
Flash Point Method: PMCC
Extinguishing Media: WATER SPRAY, CARBON DIOXIDE, DRY CHEMICAL, FOAM.
Fire Fighting Procedures: USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT (FP N).
Unusual Fire/Explosion Hazard: NONE KNOWN.
*
*
Respiratory Protection: CONTINUOUS SPURRING OF DRY BUFF PADS MAY PRDCE DUST
CNDTNS IN EXCESS OF OSHA PEL OR TLV FOR CRYSTALLINE SILICA. WHEN
CLEANING/SPURRING DRY BUFF PAD USED W/THIS PROD, USE APPROP LOC EXHST TO
CONTROL DU ST/USE APPROP NIOSH/MSHA APPRVD
Ventilation: PROVIDE SUFFICIENT VENT TO MAINTAIN EMISSIONS BELOW REC EXPOS
LIMS. IF EXHST VENT IS NOT ADEQ, USE APPROP NIOSH/
Other Protective Equipment: EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET ANSI
DESIGN CRITERIA (FP N).
Work Hygienic Practices: NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health: MFR'S TRADE NAME/PART NO:& WAX,
ORG:LUNGS. EFTS OF OVEREXP:WHEEZING, COUGH UP BLOOD & PNEUM, WHICH CAN BE
FATAL. SILICA TRI POLI IS POTNTL CANCER HAZ CAUSING LUNG & INJECTION SITE
CANCER BY INHAL, INTRAPLEUAL & INTRAPERITONEAL RTES OF
*
Physical/Chemical Properties
*
Vapor Density: >1
PH: SUPDAT
Evaporation Rate & Reference: >1 (WATER=1)
Solubility in Water: MODERATE
Appearance and Odor: TAN TO BEIGE COLOR PASTE; MILD SOLVENT ODOR.
*
Reactivity Data
*
Stability Indicator: YES
Stability Condition To Avoid: NONE SPECIFIED BY MANUFACTURER.
Materials To Avoid: STRONG OXIDIZING AGENTS.
Hazardous Decomposition Products: CARBON MONOXIDE & CARBON DIOXIDE, TOXIC
VAPORS, GASES OR PARTICULATES.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT
*
Toxicological Information
*
*
Ecological Information
*
*
*
*
Regulatory Information
*
*
Other Information
*
*
HAZCOM Label
*
Company Name: MINNESOTA MINING AND MFG CO ENGINEERING DOCUMENT SYSTEMS DIV
Street: 3M CTR
Label Required IND: Y
Status Code: C
Origination Code: G
Chronic Hazard IND: Y
Skin Protection IND: YES
Signal Word: WARNING
Respiratory Protection IND: YES
Health Hazard: Slight
Contact Hazard: Slight
Fire Hazard: Moderate
Reactivity Hazard: None
Hazard And Precautions: COMBUSTIBLE. ACUTE:EYE CONTACT:MODERATE
IRRITATION:SIGNS OR SYMPTOMS CAN INCLUDE REDNESS, SWELLING, PAIN, TEARING
& HAZY VISION. SKIN:MILD IRRITATION (AFTER PROLONGED OR REPEATED
CONTACT):SIGNS OR SYM PTOMS CAN INCLUDE REDNESS, SWELLING & ITCHING.
INHALATION:IRRITATION (UPPER RESPIRATORY) SIGNS OR SYMPTOMS CAN INCLUDE
SORENESS OF NOSE & THROAT, COUGHING & SNEEZING. CHRONIC:CANCER
HAZARD. CONTAINS S ILICA, CRYSTALLINE-TRIPOLI, WHICH IS LISTED AS AN ANIMAL
LUNG CARCINOGEN (FP N).
*
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:WEAR A PROPERLY FITTED NIOSH-APPROVED DUST
RESPIRATOR FOR DUSTY CONDITIONS.
Ventilation:USE ADEQUATE MECHANICAL VENTILATION.
Other Protective Equipment:LONG SLEEVED CLOTHING
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING AND BEFORE
EATING, DRINKING OR SMOKING. LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE.
Supplemental Safety and Health
SILICA GEL IS A SYNTHETIC AMORPHOUS SILICA NOT TO BE CONFUSED WITH
CRYSTALLINE SILICA. COBALT CHLORIDE IS GENERALLY RECOGNIZED AS SAFE
AS A TRACE MINERAL ADDED TO ANIMAL FEEDS BY FDA. HOWEVER, THIS IS
NOT A FOOD-GRADE PRODUCT. THIS PRODUCTIS NOT KNOWN TO HAVE ANY
ADVERSE EFFECT ON THE AQUATIC ENVIRONMENT.
* Product Identification *
Product ID:BLUE INDICATING GEL
* Composition/Information on Ingredients *
Ingred Name:SILICA GEL
Other REC Limits:NONE SPECIFIED
Ingred Name:COBALT CHLORIDE
Other REC Limits:NONE SPECIFIED
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EPIDEMIOLOGICAL STUDIES INDICATE
SILICA GEL HAS A LOW POTENTIAL FOR ADVERSE HEALTH EFFECTS. IT IS
CONSIDERED TO BE A NUISANCE DUST. WHEN ACTIVATED, SILICA GEL ACTS
AS A DESICCANT & CAN CAUSE A DRYING IRRITATION OF THE MUCOUS
MEMBRANES & SKIN. COBALT CHLORIDE CAN CAUSE DERMATITIS & IRRITATION
OF THE RESPIRATORY TRACT.
Explanation of Carcinogenicity:THIS COMPOUND CONTAINS NO INGREDIENTS AT
CONCENTRATIONS OF 0.1% OR GREATER THAT ARE CARCINOGENS OR SUSPECT
CARCINOGENS.
Effects of Overexposure:EYE, SKIN & RESPIRATORY TRACT IRRITATION.
Medical Cond Aggravated by Exposure:THERE IS NO KNOWN MEDICAL
CONDITIONS ABNORMALLY AGGRAVATED BY EXPOSURE THIS PRODUCT.
* First Aid Measures *
EYELIDS OPEN. IF IRRITATION OCCURS AND PERSISTS, GET MEDICAL
ATTENTION. SKIN: WASH WITH SOAP AND WATER. INHALATION: REMOVE TO
FRESH AIR. ING ESTION: MATERIAL WILL PASS THROUGH THE BODY
NORMALLY.
* Fire Fighting Measures *
Flash Point:NONE
Autoignition Temp:Autoignition Temp Text:NONE
Lower Limits:NONE
Upper Limits:NONE
* Accidental Release Measures *
Spill Release Procedures:SWEEP OR VACUUM UP
Neutralizing Agent:NONE
*Handling and Storage *
Handling and Storage Precautions:KEEP TIGHTLY SEALED TO PROTECT
QUALITY. STORE IN COOL, DRY PLACE.
Other Precautions:AVOID PROLONGED BREATHING OF DUST OR SKIN CONTACT
WITH DUST. THE DRYING ACTION OF THIS MATERIAL CAN CAUSE IRRITATION
OF THE MUCOUS MEMBRANES OF THE NOSE AND THROAT AND IRRITATION OF
THE SKIN. WEAR PRO TECTIVE EQUIPMENT FOR MANUAL HANDLING.
* Physical/Chemical Properties *
HCC:N1
Spec Gravity:2.1
Solubility in Water:SILICA GEL: NEG.
Appearance and Odor:CLEAR BLUE GRANULES
Percent Volatiles by Volume:0
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
REACTS WITH HYDROGEN FLUORIDE.
Hazardous Decomposition Products:NONE SPECIFIED BY MANUFACTURER.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE IN AN APPROVED LANDFILL ACCORDING TO
FEDERAL, STATE AND LOCAL REGULATIONS. COVER PROMPTLY TO AVIOD
BLOWING OF DUST.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:USE NIOSH/MSHA APPROVED ORGANIC VAPOR RESPIRATOR
IF VENTILATION IS INADEQUATE.
Ventilation:GENERAL MECHANICAL VENTILATION RECOMMENDED FOR ENCLOSED
AREAS.
Other Protective Equipment:EYE WASH STATION AND SINK. EYE WASH FOUNTAIN
& DELUGE SHOWER MEETING ANSI DESIGN CRITERIA .
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
* Product Identification *
CAGE:0U4X9
CAGE:0U4X9
* Composition/Information on Ingredients *
Ingred Name:PHENOL, 4,4'-(3H-2,1-BENZOXATHIOL-3-YLIDENE)
BIS(2,6-DIBROMO-3-METHYL-,S,S-DIOXIDE; (BROMOCRESOL GREEN)
OSHA PEL:N/K
ACGIH TLV:N/K
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES:IRRITATION AND POSSIBLE EYE
DAMAGE. SKIN:MAY CAUSE SKIN IRRITATION WITH PROLONGED CONTACT.
INGEST:HEADACHES, NAUSEA, VOMITING, DIARRHEA, CRAMPS.
INHAL:RESPIRATORY TRACT IRRITATION, HEADACHES AND VOMITING.
PROLONGED EXPOSURE CAN CAUSE CENTRAL NERVOUS SYSTEM DEPRESSION.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:IMPAIRED RESPIRATORY FUNCTION.
PRE-EXISTING EYE AND SKIN PROBLEMS.
* First Aid Measures *
MINUTES . SKIN:FLUSH WITH COPIOUS AMOUNTS OF WATER. CALL MD
IMMEDIATELY . INGEST:CALL MD IMMEDIATELY . INHAL:REMOVE TO FRESH
AIR. SUPPORT BREATHING (GIVE O*2/ARTIFICIAL RESPIRATION) .
* Fire Fighting Measures *
Lower Limits:2.0%
Extinguishing Media:ALCOHOL FOAM, CARBON DIOXIDE, DRY CHEMICAL
Fire Fighting Procedures:NIOSH/MSHA APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:VAPORS MAY FLOW ALONG SURFACE TO IGNITION
SOURCES AND FLASH BACK. CLOSED CONTAINERS EXPOSED TO HEAT MAY
EXPLODE.
* Accidental Release Measures *
Spill Release Procedures:REMOVE ALL IGNITION SOURCES. VENTILATE
ENCLOSED AREAS. COLLECT FREE LIQUID. SOAK UP REMAINING SPILLAGE
WITH SAND AND OTHER ABSORBENT. PLACE INTO CHEMICAL WASTE CONTAINER
FOR DISPOSAL.
Neutralizing Agent:
*Handling and Storage *
Handling and Storage Precautions:STORE IN A COOL PROTECTED LOCATION.
KEEP CONTAINER CLOSED WHEN NOT IN USE.
Other Precautions:CLEAN UP SPILLS IMMEDIATELY. DO NOT REUSE EMTPY
CONTAINER.
* Physical/Chemical Properties *
Evaporation Rate & Reference:>1 (WATER=1)
Solubility in Water:COMPLETE
Appearance and Odor:REDDISH-ORANGE LIQUID; ALCOHOL ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS.
Stability Condition to Avoid:
Hazardous Decomposition Products:NOT KNOWN
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE AND
FEDERAL REGULATIONS . DISPOSE OF AT APPROVED CHEMICAL WASTE
REPROCESSING FACILITY.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NONE NORMALLY REQUIRED WITH GOOD VENTILATION.
NIOSH/MSHA-APPROVED RESPIRATOR WITH ORGANIC VAPOR CARTRIDGE IF TLV
IS EXCEEDED.
Ventilation:MECHANICAL (GENERAL) AND/OR LOCAL EXHAUST TO MAINTAIN
EXPOSURE BELOW TLV.
Other Protective Equipment:AS NECESSARY TO PREVENT PROLONGED CONTACT.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.LAUNDER
CONTAMINATED CLOTHING BEFORE REUSE.
Supplemental Safety and Health
NONE.
* Product Identification *
Preparer's Name:R. MILES,TECH. DIRECTOR
* Composition/Information on Ingredients *
Ingred Name:STODDARD SOLVENT
Ingred Name:MINERAL OIL (PETROLEUM BASE OIL)
OSHA PEL:5 MG/M3 (OIL MIST)
ACGIH TLV:5 MG/M3 (OIL MIST)
Ingred Name:CORROSION INHIBITOR (PROPIETARY MIXTURE)
Other REC Limits:5 MG/M3 (TWA)
Ingred Name:WETTING AGENT (TYPE NOT SPECIFIED-PROPIETARY)
Fraction by Wt: <5%
Ingred Name:FRAGRANCE (PROPIETARY MIXTURE)
Fraction by Wt: <5%
Ingred Name:LPG (LIQUEFIED PETROLEUM GAS)
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:THIS PRODUCT IS AN INHALATION HAZARD.
EYE OR SKIN CONTACT MAY CAUSE IRRITATION.
Effects of Overexposure:EYES:IRRITATION,TEARING,REDNESS.
SKIN:IRRITATION,DRYING.
INHALATION:ANESTHESIA,HEADACHE,DIZZINESS,NAUSEA,UPPER RESPIRATORY
IRRITATION. INGESTION:IRRITATION,NAUSEA,VOMITING,DIARRHEA.
ASPIRTATION INTO L UNGS:CHEMICAL PNEUMONITIS.
Medical Cond Aggravated by Exposure:INDIVIDUALS WITH A HISTORY OF
RESPIRATORY CONDITIONS MAY BE AT INCREASED RISK.
* First Aid Measures *
PERSISTS SEE DOCTOR. SKIN:WASH WITH SOAP AND WATER.IF IRRITATION
PERSISTS.SEE DOCTOR. INHALATION:REMOVE TO FRESH AIR.GIVE OXYGEN/CPR
IF NEE DED,SEE DOCTOR. INGESTION:DO NOT INDUCEVOMIT.SEEK MEDICAL
ATTENTION.
* Fire Fighting Measures *
Lower Limits:1.8
Upper Limits:9.5
Extinguishing Media:USE CARBON DIOXIDE, FOAM, DRY CHEMICAL, OR WATER
FOG.
Fire Fighting Procedures:FIRE FIGHTERS SHOULD USE NIOSH APPROVED SCBA &
FULL PROTECTIVE EQUIPMENT WHEN FIGHTING CHEMICAL FIRE. USE WATER
SPRAY TO COOL NEARBY CONTAINERS EXPOSED TO FIRE.
Unusual Fire/Explosion Hazard:CONSIDERED EXTREMELY FLAMMABLE. CANS MAY
EXPLODE IN HEAT OF FIRE.
* Accidental Release Measures *
Spill Release Procedures:SPILL IS UNLIKELY FROM AEROSOL CANS. LEAKING
CANS SHOULD BE PLACED IN PLASTIC BAG OR OPEN PAIL UNTIL PRESSURE
HAS DISSIPATED. KEEP AREA WELL VENTILATED.
*Handling and Storage *
Handling and Storage Precautions:STORE IN COOL,DRY,WELL VENTILATED,LOW
FIRE RISK AREA.PROTECT CONTAINER FROM PHYSICAL DAMAGE.DO NOT STORE
Other Precautions:KEEP AT ROOM TEMPERATURE AS EXPOSURE TO SUNLIGHT MAY
CAUSE BURSTING. KEEP AWAY FROM IGNITION SOURCES AND INCOMPATIBLE
MATERIALS.AVOID EXCESSIVE INHALATION OF SPRAY PARTICLES. DO NOT
PUNCTURE OR INCINE RATE. DO NOT TAKE INTERNALLY.
* Physical/Chemical Properties *
HCC:V3
Vapor Density:>1
Solubility in Water:INSOLUBLE
Appearance and Odor:LIGHT AMBER. CHARACTERISTIC ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING MATERIALS.
Stability Condition to Avoid:HIGH TEMPERATURES, SPARKS, AND OPEN FLAMES
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE,
INCOMPLETELY BURNED CARBON PRODUCTS.
* Disposal Considerations *
Waste Disposal Methods:CONTACT YOUR LOCAL ENVIRONMENTAL OFFICER.DO NOT
PUNCTURE OR INCINERATE CONTAINER.GIVE TO DISPOSAL SERVICE.DISPOSE
OF IN ACCORDANCE WITH FEDERAL,STATE AND LOCAL ENVIRONMENTAL
REGULATIONS.FULL OR PARTIA LLY FILLED CONTAINERS ARE CONSIDERED
HAZARDOUS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Ventilation:GEN VENT TO MAINTAIN VAPORS BELOW TLV. WHEN SPRAYING,
* Product Identification *
Kit Part:Y
Preparer's Name:WES MAURICE
* Composition/Information on Ingredients *
Ingred Name:MONOCHLOROBENZENE
Other REC Limits:NONE SPECIFIED
Ingred Name:DIPHENYMETHANEDIISOCYANATE (MDI)
Other REC Limits:NONE SPECIFIED
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES: IRRIT, WATERING OF EYES &
POSSIBLE REVERSIBLE CORNEAL DAMAGE. SKIN: LOCAL SWELLING, SORENESS,
ITCHING. IN SENSITIZED INDIVIDUALS, WILL CAUSE AN ALLERGIC SKIN
RASH. INHAL: DUE TO LOW VOLATILITY, SIGNIFICANT EXPOSURE TO
ISOCYANATE VAPORS IS NOT EXPECTED UNLESS OVERHEATED. EXCESSIVE
INHALATION CAN PRODUCE IRRIT **
Effects of Overexposure:**OF THE NOSE/THROAT/RESPIRATORY TRACT.
EXCESSIVE & EXTENSIVE EXPOSURE CAN PRODUCE REVERSIBLE SYMPTOMS OF
BRONCHITIS. SENSITIZED INDIVIDUALS WILL DEVELOP ASTHMA-LIKE
SYMPTOMS AT LOW EXPOSURE. INGEST: MAY RESULT IN IRRITATION & SOME
CORROSIVE ACTION IN THE MOUTH, STOMACH TISSUE, DIGESTIVE TRACT &
KIDNEY & LIVER DAMAGE.
* Fire Fighting Measures *
Flash Point Method:PMCC
Lower Limits:1.8
Upper Limits:9.6
Extinguishing Media:FOAM, CO2, DRY CHEMICAL, WATER SPRAY.
Fire Fighting Procedures:USE AIR SUPPLIED RESPIRATOR. USE WATER TO COOL
HEAT EXPOSED CONTAINERS.
Unusual Fire/Explosion Hazard:HIGH TEMPERATURES MAY CAUSE PRESSURE
BUILDUP IN CLOSED CONTAINERS.
* Accidental Release Measures *
Spill Release Procedures:REMOVE ALL IGNITION SOURCES. WEAR AIR-SUPPLIED
RESPIRATOR FOR MAJOR UNVENTILATED SPILL. COVER W/ABSORB MAT'L, ADD
HRS.
*Handling and Storage *
Handling and Storage Precautions:AVOID MOISTURE CONTAMINATION WHICH
WILL CAUSE CO2 PRESSURE. DO NOT RESEAL CONTAINER IF MOISTURE
CONTAMINATION IS SUSPECTED.
APPLYING IN CONFINED AREAS OR IN OTHER CIRCUMSTANCES LIKELY TO***
Supplemental Safety and Health
N/K***PRODUCE A AIRBORNE LEVELS OF SOLVENT OR ISOCYANATE
IN EXCESS OF TLV, USE AN AIR-SUPPLIED RESPIRTAOR.
* Physical/Chemical Properties *
HCC:F4
Solubility in Water:NEGLIGIBLE
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
WATER, ALCOHOLS, STRONG BASES, AMINES.
Hazardous Decomposition Products:OXIDES OF CARBON AND NITROGEN;
POSSIBLE REVERSIBLE CORNEAL DAMAGE.
* Disposal Considerations *
FEDERAL AND STATE REGULATIONS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NIOSH APPROVED RESPIRATOR W/AN ORGANIC VAPOR &
DUST CARTRIDGE, AIR SUPPLIED MASK/HOOD
Ventilation:LOCAL EXHAUST; MECHANICAL EXHAUST: MUST BE EXPLOSION PROOF
Other Protective Equipment:CAP & IMPERMEABLE APRON
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE.
Supplemental Safety and Health
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:SILICA DIOXIDE, CRYSTALLINE QUARTZ, SAND (SUSPECTED HUMAN
ACGIH TLV:0.1 MG/CUM RESP DUST
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:INHALATION: UPPER/LOWER RESPIRATORY
TRACT IRRITATION. EYES: IRRITATION. SKIN: MINOR IRRITATION.
INGESTION: GI IRRITATION.
Explanation of Carcinogenicity:SEE INGREDIENTS
Effects of Overexposure:NAUSEA, HEADACHES, DIZZINESS, REDNESS, TEARING,
VOMITING, DIRRHEA.
* First Aid Measures *
First Aid:INHALATION: REMOVE TO FRESH AIR. GIVE CPR IF NECESSARY.
EYES/SKIN: WASH THOROUGHLY W/CLEAN WATER. INGESTION: IF CONSCIOUS,
GIVE 2 GLASSES OF WATER TO DRINK. OBTAIN MEDICAL ATTENTION IN ALL
CASES.
* Fire Fighting Measures *
Extinguishing Media:FOAM, CO2, CHEMICAL, WATER FOG
Fire Fighting Procedures:WEAR APPROPRIATE FIRE FIGHTING PROTECTION,
SCBA IN CONFINED AREA.
Unusual Fire/Explosion Hazard:UNOPENED CONTAINERS MAY BURST OPEN &
SPATTER. KEEP CONTAINERS COOL W/WATER SPRAY/REMOVE FROM AREA.
* Accidental Release Measures *
Spill Release Procedures:KEEP MATERIAL OUT OF OPEN BODIES OF WATER.
DIKE & ABSORB W/INERT MATERIAL & PUT INTO CONTAINERS FOR
RECOVERY/DISPOSAL.
*Handling and Storage *
Handling and Storage Precautions:KEEP CONTAINERS CLOSED WHEN NOT IN
USE. ROTATE STOCK, USE OLD MATERIALS FIRST. DON'T TAKE INTERNALLY.
AVOID PROLONGED CONTACT/INHALATION.
Other Precautions:KEEP OUT OF REACH OF CHILDREN.
* Physical/Chemical Properties *
Vapor Density:>1
Evaporation Rate & Reference:SLOWER THAN BU AC
Solubility in Water:MISCIBLE
Appearance and Odor:OPAQUE LIQUID, W/MILD ODOR
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
MATERIALS THAT REACT W/WATER. STRONG ACIDS, ALKALI
Hazardous Decomposition Products:STRONG ACRID FUMES
* Disposal Considerations *
Waste Disposal Methods:INCINERATE/LANDFILL ACCORDING TO FEDERAL, STATE
& LOCAL REGULATIONS. DON'T DUMP INTO LAKES, STREAMS/OTHER WATER
SUPPLY.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NONE NORMALLY REQUIRED. FOLLOW SPECIFICATIONS IN
Ventilation:LOCAL EXHAUST TO REMOVE SMOKE FROM BREATHING AREA.
MECHANICAL (GENERAL) IS NORMALLY ADEQUATE.
Other Protective Equipment:EYE WASH STATION, EMERGENCY SHOWER. PERSONAL
CLOTHING AND SHOES SHOULD BE PROTECTED FROM CONTAMINATION.
Work Hygienic Practices:DO NOT EAT, DRINK OR SMOKE IN WORK AREA. WASH
AFTER HANDLING AND BEFORE EATING, DRINKING, OR SMOKING.
Supplemental Safety and Health
* Product Identification *
Preparer's Name:ROBERT L. GILBERT
* Composition/Information on Ingredients *
Ingred Name:LEAD (SARA III)
Other REC Limits:NONE RECOMMENDED
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:TIN
Other REC Limits:NONE RECOMMENDED
OSHA PEL:2 MG/M3
Ingred Name:ROSIN (MAY DECOMPOSE DURING SOLDERING TO
FORMALDEHYDE/TURPENTINE)
Fraction by Wt: 1 - 3%
Other REC Limits:NONE RECOMMENDED
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: WEAKNESS,VOMITING,LOSS OF
APPETITE, CONVULSIONS,STUPOR, POSSIBLY COMA. DUST,VAPOR OR FUMES
MAY BE IRRITATING TO SKIN,EYES, RESPIRATORY SYSTEM. CHRONIC:
WEAKNESS, INSOMNIA, HYPERTENSION, SLIGHT IRRITATION OF EYES,
HEADACHE, POSSIBLE PARALYSIS. LEAD MAY DAMAGE BLOOD-FORMING,
NERVOUS, URINARY, REPRODUCTIVE SYSTEMS.
Explanation of Carcinogenicity:FORMALDEHYDE FORMED DURING THE
DECOMPOSITION OF ROSIN FLUX IS LISTED AS A SUSPECTED CARCINOGEN BY
ACGIH.
Effects of Overexposure:WEAKNESS, VOMITING, LOSS OF APPETITE,
CONVULSIONS, STUPOR, COMA, SKIN IRRITATION, EYE IRRITATION,
RESPIRATORY SYSTEM IRRITATION, INSOMIA, HYPERTENSION, HEADACHE,
PARALYSIS, AND DAMAGE OF BLOOD-FORMING , NERVOUS, URINARY, AND
REPRODUCTIVE SYSTEMS.
Medical Cond Aggravated by Exposure:LEAD AND ITS INORGANIC COMPOUNDS
ARE NEUROTOXINS WHICH MAY PRODUCE NEUROPATY. ROSIN IS AN ALLERGEN.
* First Aid Measures *
First Aid:EYES: FLUSH WITH LARGE AMOUNTS OF WATER. GET MEDICAL
ATTENTION IF SYMPTOMS PERSIST. SKIN: WASH WITH SOAP AND WATER.
INHALATION: MOVE TO FRESH AIR. GET MEDICAL ATTENTION IF
EXPERIENCING EFFECTS OF OVER EXPOSURE. INGESTION: GET IMMEDIATE
MEDICAL ATTENTION.
* Fire Fighting Measures *
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL, FOAM.
Fire Fighting Procedures:WEAR FULL PROTECTIVE CLOTHING AND
NIOSH-APPROVED FULL FACE PIECE, SELF-CONTAINED BREATHING APPARATUS
OPERATED IN THE POSITIVE-PRESSURE MODE.
Unusual Fire/Explosion Hazard:DO NOT USE WATER ON FIRES WHERE MOLTEN
METAL IS PRESENT. HIGH TEMPERATURES MAY PRODUCE HEAVY METAL FUMES,
DUSTS AND OR VAPORS.
* Accidental Release Measures *
Spill Release Procedures:PARTICULATE MATTER SHOULD BE STORED IN DRY
CONTAINERS FOR LATER DISPOSAL. DUST MATERIAL SHOULD BE VACUUMED OR
WET SWEPT. DO NOT USE COMPRESSED AIR OR DRY SWEEPING AS A MEANS OF
CLEANING.
Neutralizing Agent:NOT APPLICABLE.
*Handling and Storage *
Handling and Storage Precautions:WASH HANDS WITH SOAP AND WATER AFTER
HANDLING SOLDER. STORE IN DRY AREA AWAY FROM STRONG OXIDIZERS.
AVOID BREATHING SMOKE DURING SOLDERING.
Other Precautions:NONE KNOWN.
* Physical/Chemical Properties *
HCC:N1
Solubility in Water:INSOLUBLE
Appearance and Odor:GRAY METAL WITH NEUTRAL ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:NONE KNOWN.
Hazardous Decomposition Products:HIGH TEMPERATURES MAY PRODUCE HEAVY
METAL FUMES, DUST AND/OR VAPORS.
Conditions to Avoid Polymerization:WILL NOT OCCUR.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF HAZARDOUS WASTES IN ACCORDANCE WITH
LOCAL, STATE AND FEDERAL REGULATIONS. CONSULT A LICENSED HAZARDOUS
WASTE COMPANY.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NONE NEEDED W/WORKING MIXTURES & NORMAL ROOM
VENTILATION.
Ventilation:ROOM VENTILATION IS SUFFICIENT. AVOID USE OF PRODUCT IN
UNVENTILATED AREAS.
Other Protective Equipment:CHEMICAL APRONS ARE RECOMMENDED.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
DISP METH:MAY REQUIRE PRETREATMENT.
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:SODIUM HYDROXIDE (SARA III)
Fraction by Wt: 0-1%
OSHA PEL:2 MG/M3
Ingred Name:SODIUM SULFITE (2:1)
Ingred Name:HYDROQUINONE (SARA III)
Fraction by Wt: 1-5%
OSHA PEL:2 MG/M3
ACGIH TLV:2 MG/M3
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:4-METHYL-1-PHENYL-3-PYRAZOLIDONE
Fraction by Wt: 0-1%
Ingred Name:ETHANOL, 2-(METHYLAMINO)-; (METHYLETHANOLAMINE)
Fraction by Wt: 1-5%
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: EYE:MAY CAUSE IRRIT. SKIN:MAY
CAUSE IRRIT; MAY CAUSE ALLERGIC SKIN RXN. INHAL:NORM NO PROB, BUT
INHAL OF MIST COULD CAUSE RESP IRRIT. INGEST:MAY CAUSE IRRIT OF MUC
MEMB/DIGESTIVE TRACT. CHRONIC :HYDROQUINONE:RPTD CONT CAN CAUSE
SKIN SENSIT & ALLERGIC DERM. CHRONIC OVEREXPOS CAN CAUSE ANEMIA &
(EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ:DISCOLORATION & CORNEAL OPACITY OF
EYES. METHYL PHENIDONE:CONTACT W/SKIN MAY CAUSE SLIGHT IRRITATION.
LAB TESTS INDICATE MATERIAL IS A SKIN SENSITIZER. ALL OTHER
INGREDS:A COMPUTERIZED LITERA TURE SEARCH OF NATIONAL DATABASES DID
NOT YIELD ANY CHRONIC EFFECTS ASSOCIATED W/THESE MATERIALS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
* First Aid Measures *
First Aid:EYE:IMMEDIATELY FLUSH W/PLENTY OF RUNNING WATER FOR AT LEAST
OF CONTINU ED IRRITATION, CONSULT MD. INHAL:FOR OVEREXPOSURE,
REMOVE TO FRESH AIR. INGEST:OBTAIN IMMEDIATE MEDICAL ATTENTION.
* Fire Fighting Measures *
Flash Point:NONCOMBUSTIBLE
Extinguishing Media:ANY APPLICABLE TO PRIMARY CAUSE OF FIRE.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT . EVACUATE PERSONNEL TO A SAFE AREA. KEEP
PERSONNEL REMOVED & UPWIND OF FIRE.
Unusual Fire/Explosion Hazard:WHEN HEATED TO DECOMPOSITION, EMISSION OF
TOXIC FUMES OF SO*2 IS POSSIBLE.
* Accidental Release Measures *
Spill Release Procedures:REVIEW FIRE/EXPLOS & PROT SECTION BEFORE
PROCEEDING W/CLEAN UP. USE APPROP PERSONAL PROT EQUIP DURING CLEAN
UP. DIKE SPILL. PVNT LIQ FROM ENTERING SEWERS, WATERWAYS OR LOW
AREAS. SOAK UP W/SAND, OIL D RY OR OTHER ABSORB MATL. SPILL MAY BE
(SUPP DATA)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:STORE IN WELL VENTD AREA. DO NOT STORE
W/INCOMPAT MATLS. DO NOT STORE OR CONSUME FOOD, DRINK OR TOBACCO IN
AREA WHERE THEY MAY BECOME CONTAMD W/MATL.
Other Precautions:KEEP CONTAINER TIGHTLY CLOSED.
* Physical/Chemical Properties *
HCC:N1
Vapor Pres:SAME/H*2O
Vapor Density:SAME/H*2O
Evaporation Rate & Reference:SAME AS WATER
Appearance and Odor:CLEAR & LIGHT YELLOW; SLIGHTLY FISHY ODOR.
Percent Volatiles by Volume:SUPDAT
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS & OXIDIZERS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:OXIDES OF SULFUR & NITROGEN, CO*2 &
CARBON MONOXIDE.
* Disposal Considerations *
Waste Disposal Methods:RECOVER NONUSABLE FREE LIQ &/OR CONTAMD WATER &
DISP OF IN AN APPRVD/PERMITTED TREATMENT SYS. REMOVE NONUSABLE
SOLID MATL &/OR CONTAMD SOIL, FOR DISP IN AN APPRVD/PERMITTED
LANDFILL. DISCHARGE TO SEWE R REQS APPROVAL OF PERMITTING AUTH &
(SUPP DATA)
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NIOSH APPROVED RESPIRATOR.
Ventilation:GOOD LOCAL EXHAUST:YES. MECHANICAL (GENERAL):YES, FOLLOW
OSHA STANDARD.
Other Protective Equipment:ANSI APPROVED EMERGENCY EYE WASH AND DELUGE
SHOWER . AS NEEDED.
Work Hygienic Practices:PRACTICE GOOD HOUSEKEEPING.
Supplemental Safety and Health
* Product Identification *
Kit Part:Y
* Composition/Information on Ingredients *
Ingred Name:SILICA, CRYSTALLINE - QUARTZ; (SILICON DIOXIDE)
OSHA PEL:SEE TABLE Z-3
ACGIH TLV:0.1 MG/M3 RDUST
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ACUTE:EYE IRRITATION. POSSIBLE SKIN
IRRITATION. CHRONIC:FREE SILICA DUST MAY CAUSE DELAYED LUNG INJURY.
Explanation of Carcinogenicity:SILICA, CRYSTALLINE-QUARTZ:IARC
ON CARCINS: (SUPDAT)
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NOT KNOWN.
* First Aid Measures *
First Aid:INHALATION:MOVE SUBJECT TO FRESH AIR. EYES:FLUSH WITH WATER
INGESTION:CALL PHYSICIAN.
* Fire Fighting Measures *
Extinguishing Media:MEDIA SUITABLE FOR SURROUNDING FIRE . NO FIRE
HAZARD.
Fire Fighting Procedures:WEAR NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT . NOT APPLICABLE.
Unusual Fire/Explosion Hazard:NOT APPLICABLE.
* Accidental Release Measures *
Spill Release Procedures:SWEEP OR VACUUM USING GOOD VENTILATION SO TLV
IS NOT EXCEEDED.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:USE DUSTLESS SYSTEMS FOR HANDLING,
STORAGE AND CLEANUP SO TLV OF SIO*2 IS NOT EXCEEDED.
Other Precautions:PRACTICE GOOD HOUSEKEEPING AND POST WORK AREAS WHERE
PRODUCT IS USED.
* Physical/Chemical Properties *
Solubility in Water:NEGLIGIBLE
Appearance and Odor:GRANULAR SAND, CRUSHED OR GROUND LIKE FLOUR; NO
ODOR OR TASTE.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
DISSOLVED BY HYDROFLUORIC ACID WHICH CAN RESULT IN SILICON
TETRAFLUORIDE (SIF*4) WHICH IS CORROSIVE GAS.
Stability Condition to Avoid:NOT APPLICABLE.
Hazardous Decomposition Products:NOT APPLICABLE.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE IN SANITARY LANDIFLL IN ACCORDANCE WITH
STATE, LOCAL, AND FEDERAL REGULATIONS ON SOLID WASTES.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NONE NEEDED. USE NIOSH/MSHA APPROVED RESPIRATOR
APPROPRIATE FOR EXPOSURE OF CONCERN .
Ventilation:NO SPECIAL CONTROLS NECESSARY.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
EXPLO HAZ: FOUND IN AN OFFICE SETTING.
* Product Identification *
Preparer's Name:RC
* Composition/Information on Ingredients *
Ingred Name:POLY(OXYETHYLENEOXYTEREPHTHALOYL); (POLYESTER FILM
(POLYETHYLENE TEREPHTHALATE))
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:PARAFFIN WAX
OSHA PEL:2 MG/M3 (FUME)
ACGIH TLV:2 MG/M3 (FUME)
Ingred Name:COLORANT; (COLORING MATERIAL)
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:RESIN
OSHA PEL:N/K
ACGIH TLV:N/K
* Hazards Identification *
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES/SKIN: NON-IRRITATING.
INHALATION/INGESTION: NOT CONSIDERED ROUTES OF EXPOSURE.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
* First Aid Measures *
First Aid:INGEST: CALL MD IMMEDIATELY . INHAL: REMOVE TO FRESH AIR.
SUPPORT BREATHING (GIVE OXYGEN/ARTIFICIAL RESPIRATION) . EYES:
ASSISTANCE FROM MD . SKIN: FLUSHW/COPIOUS AMOUNTS OF WATER. CALL
MD . THIS MATERIAL IS A COATED FILM. NO MEDICAL EMERGENCY IS
FORESEEN WHEN PRODUCT IS USED AS INTENDED.
* Fire Fighting Measures *
Extinguishing Media:MEDIA SUITABLE FOR SURROUNDING FIRE .
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:THE FILM WILL BURN WHEN IN CNTCT W/FIRE.
PRODS OF COMBUST INCL CARBON DIOXIDE, CARBON MONOXIDE & WATER WHICH
ARE SIMILAR TO COMBUST OF OTHER PRODS (SUPDAT)
* Accidental Release Measures *
Spill Release Procedures:THIS SECTION IS NOT APPLICABLE TO THIS PRODUCT
WHICH IS A DRY FILM.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:NO SPECIAL HANDLING PRECAUTIONS
NECESSARY. STORE AWAY FROM EXCESSIVE HEAT.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
* Physical/Chemical Properties *
Solubility in Water:NOT SOLUBLE
Appearance and Odor:COATED, FLEXIBLE FILM; NO ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
NONE EXPECTED.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:NONE SPECIFIED BY MANUFACTURER.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE IN ACCORDANCE WITH ALL FEDERAL, STATE
AND LOCAL REGULATIONS. THIS FILM IS NOT CONSIDERED A HAZARDOUS
| 1 | eyes_protection_mandatory |
Control Measures
*
Proprietary Ind: Y
*
Contractor Summary
*
*
Item Description Information
*
Item Manager: S9G
Item Name: GREASE,MOLYBDENUM DISULFIDE
Unit of Issue: CN
UI Container Qty: G
Type of Container: CAN
*
Ingredients
*
-----------------------------
*
Health Hazards Data
*
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: YES
Effects of Exposure: EYE-MAY BE IRRITATING TO THE EYES. SKIN-MAY CAUSE SKIN
DISORDERS SUCH AS DERMATITIS, FOLLICULITIES OR OIL ACNE. RELEASE DURING HIGH
PRESSURE USGAE MAY RESULT IN INJECTION OF OIL INTO THE SKIN CAUSING LOCAL
NECROSIS. INHALATION-NO EXPECTED TO BE A RELEVANT ROUTE OF EXPOSURE. HOWEVER,
VAPOR IS IRRITATING TO THE NOSE, THROAT & UPPER RESPIRATORY TRACT MAY BE
PRODUCED. INGESTION-NO SPECIFIC INFORMATION IDENTIFIED.
Signs And Symptions Of Overexposure: IRRITATION. LOCAL NECROSIS IS EVIDENCED BY
DELAYED ONSET OF PAIN AND TISSUE DAMAGE A FEW HOURS FOLLOWING INJECTION. SKIN
SENSITIZATION (ALLERGY) MAY BE EVIDENCED BY RASHES, ESPECIALLY HIVES.
Medical Cond Aggravated By Exposure: PREEXISTING EYE, SKIN AND RESPIRATORY
DISORDERS MAY BE AGGRAVATED BY EXPOSURE TO THIS PRODUCT.
OPEN. GET MEDICAL ATTENTION. SKIN-REMOVE CONTAMINATED CLOTHING/SHOES &
WIPE EXCESS FROM SKIN. FLUSH SKIN WITH WATER. FOLLOW BY WASHING W ITH SOAP
& WATER. IF IRRITATION OCCURS,GET MEDICAL ATTENTION. DO NOT REUSE
CLOTHING UNTIL CLEANED. IF MATERIAL IS INJECTED UNDER THE SKIN, GET MEDICAL
ATTENTION. INHALATION-REMOVE VICTIM TO FRESH AIR & PROVIDE OXYGEN IF
BREATHING IS DIFFICULT. GET MEDICAL ATTENTION. INGESTION-DO NOT INDUCE
VOMITING. INGENERAL NO TREATMENT IS NEEDED UNLESS LARGE QUANTITIES ARE
INGESTED. GET MEDICAL ADVICE.
*
Handling and Disposal
*
Spill Release Procedures: MAY BURN ALTHOUGH NOT READILY IGNITABLE. USE CAUTIOUS
JUDGEMENT WHEN CLEANING UP LARGE SPILLS.***SMALL SPILLS***TAKE UP WITH AN
ABSORBENT MATERIAL & DISPOSE OF PROPERLY.***LARGE SPILLS***WEAR RESPIRAT
ORS & PROTECTIVE CLOTHING AS APPROPIATE.SHUT OFF SOURCE OF LEAK IF SAFE
TO DO SO. DIKE & CONTAIN. RECOVER WITH VACUUM OR PUMP TO STORAGE/SALVAGE
VESSELS. SOAK UP RESIDUE WITH ABSORBENT MATERIAL.
Waste Disposal Methods: PLACE IN AN APPROPIATE DISPOSAL FACILITY IN COMPLIANCE
WITH LOCAL REGULATIONS.
Handling And Storage Precautions: STORE IN A COOL, DRY PLACE WITH ADEQUATE
VENTILATION. KEEP AWAY FROM OPEN FLAMES AND HIGH TEMPERATURES. WASH WITH SOAP
& WATER BEFORE EATING, DRINKING, APPLYING COSMETICS, OR USING TOILET
FACILITIES. LAUNDER CONTAMINATED CLOTHING BEFORE RESUE.
Other Precautions: NOTE TO PHYSICIAN: IN GENERAL, EMESIS INDUCTION IS NECESSARY
IN HIGH VISCOSITY, LOW VOLATILITY PRODUCTS, I.E., MOST OILS AND GREASES.
*
Fire and Explosion Hazard Information
*
Flash Point Text: N/AV
Lower Limits: N/AV
Upper Limits: N/AV
Extinguishing Media: USE WATER FOG, FOAM, DRY CHEMICAL OR CO2. DO NOT USE A
DIRECT STREAM OF WATER. PRODUCT WILL FLOAT AND CAN BE REIGNITED ON SURFACE OF
WATER.
Fire Fighting Procedures: MATERIAL WILL NOT BURN UNLESS PREHEATED. DO NOT ENTER
CONFINED FIRE SPACE WITHOUT FULL BUNKER GEAR(HELMET WITH FACE SHIELD, BUNKER
APPROVED SELF-CONTAINED BREATHING APPARATUS. COOL FIRE EXPOSED CONTAINERS
WITH WATER.
Unusual Fire/Explosion Hazard: SULFUR OXIDES AND HYDROGEN SULFIDE, BOTH OF
WHICH ARE TOXIC. MAY BE RELEASE UPON COMBUSTION.
*
*
Respiratory Protection: USE A NIOSH-APPROVED RESPIRATOR AS REQUIRED TO PREVENT
ATMOSPHERE-SUPPLYING RESPIRATOR OR AN AIR-PURIFYING RESPIRATOR FOR ORGANIC
VAPORS.
Other Protective Equipment: PROTECTIVE CLOTHING
*
Physical/Chemical Properties
*
HCC: N1
B.P. Text: N/AV
M.P/F.P Text: N/AV
Vapor Pres: N/AV
Vapor Density: N/AV
Spec Gravity: N/AV
Evaporation Rate & Reference: N/AV
Solubility in Water: N/AV
Appearance and Odor: SMOOTH BUTTERY BLACK GREASE, HYDROCARBON ODOR.
*
Reactivity Data
*
Stability Indicator: YES
Materials To Avoid: AVOID HEAT, FLAME AND CONTACT WITH STRONG OXIDIZING
AGENTS..
Hazardous Decomposition Products: CARBON MONOXIDE, MOLYBDENUM DISULFIDE, OXIDES
OF ANTIMONY, SULFUR, NITROGEN AND OTHER UNIDENTIFIED ORGANIC COMPOUNDS MAY BE
FORMED UPON COMBUSTION.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: WILL NOT OCCUR.
*
Toxicological Information
*
*
Ecological Information
*
*
*
Transport Information: NOT HAZARDOUS BY D.O.T. REGULATIONS.
*
Regulatory Information
*
CONTAINS AN ANTIMONY COMPOUND.
Federal Regulatory Information: UNDER EPA-CWA: THIS PRODUCT IS CONSIDERED AN
COMP ONENTS OF THIS PRODUCT ARE LISTED ON THEEPA/TSCA INVENTORY OF CHEMICAL
SUBSTANCES.
*
Other Information
*
*
Transportation Information
*
Multiple KIT Number: 0
Unit Of Issue: CN
Container QTY: G
Type Of Container: CAN
*
Detail DOT Information
*
DOT PSN Code: ZZZ
DOT Proper Shipping Name: NOT REGULATED BY THIS MODE OF TRANSPORTATION
*
Detail IMO Information
*
IMO PSN Code: ZZZ
IMO Proper Shipping Name: NOT REGULATED FOR THIS MODE OF TRANSPORTATION
*
Detail IATA Information
*
IATA PSN Code: ZZZ
IATA Proper Shipping Name: NOT REGULATED BY THIS MODE OF TRANSPORTATION
*
Detail AFI Information
*
AFI PSN Code: ZZZ
AFI Proper Shipping Name: NOT REGULATED BY THIS MODE OF TRANSPORTATION
*
HAZCOM Label
*
Company Name: ROYAL LUBRICANTS COMPANY INC.
Label Required IND: Y
Status Code: C
Origination Code: F
Skin Protection IND: YES
Signal Word: CAUTION
Respiratory Protection IND: YES
Health Hazard: Slight
Contact Hazard: Slight
Fire Hazard: None
Reactivity Hazard: None
Hazard And Precautions: TARGET ORGANS: N/P. EYE-MAY BE IRRITATING TO THE EYES.
SKIN-MAY CAUSE SKIN DISORDERS SUCH AS DERMATITIS, FOLLICULITIES OR OIL ACNE.
RELEASE DURING HIGH PRESSURE USGAE MAY RESULT IN INJECTION OF OIL I NTO THE
SKIN CAUSING LOCAL NECROSIS. INHALATION-NO EXPECTED TO BE A RELEVANT ROUTE OF
EXPOSURE. HOWEVER, VAPOR IS IRRITATING TO THE NOSE, THROAT & UPPER
RESPIRATORY TRACT MAY BE PRODUCED. INGESTION-NO SPECIFIC INFORMATION
IDENTIFIED.
*
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NONE REQUIRED WHERE ADEQUATE VENTILATION
CONDITIONS EXIST. IF AIRBORNE CONCENTRATION IS HIGH, USE NIOSH/MSHA
APPROVED APPROPRIATE RESPIRATOR OR DUST MASK.
Ventilation:USE ADEQUATE GENERAL OR LOCAL EXHAUST VENTILATION TO KEEP
FUME OR DUST LEVELS AS LOW AS POSSIBLE.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:HEXAMETHYLENETETRAMINE
* Hazards Identification *
Routes of Entry: Inhalation:NOSkin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHAL/SKIN ABSORP/INGEST/CHRONIC: NONE
IDENTIFIED. SKIN: IRRITATION, PROLONGED CONTACT MAY CAUSE SKIN
SENSITIZATION. EYE: IRRITATION.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE IDENTIFIED.
* First Aid Measures *
First Aid:INGEST: IF PERSON IS CONSCIOUS, IMMEDIATELY GIVE LARGE
AMOUNTS OF WATER. GET MEDICAL ATTENTION. INHAL: IF PERSON BREATHES
IN LARGE AMOUNTS, MOVE THE EXPOSED PERSON TO FRESH AIR. SKIN: IN
CASE OF CONTA CT, IMMEDIATELY WASH SKIN WITH PLENTY OF SOAP AND
* Fire Fighting Measures *
Extinguishing Media:USE EXTINGUISHING MEDIA APPROPRIATE FOR SURROUNDING
FIRE.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPRVD POSITIVE PRESS SCBA &
FULL PROT EQUIP . MOVE CNTNRS FROM FIRE AREA IF CAN BE DONE WITHOUT
RISK. USE H*2O TO COOL FIRE-EXPOS CNTNRS.
Unusual Fire/Explosion Hazard:GIVES OFF IRRITATING VAPORS.
* Accidental Release Measures *
Spill Release Procedures:WEAR SUITABLE PROT CLTHG. SHUT OFF IGNIT
SOURCES; NO FLARES, SMOKE/FLAMES IN AREA. W/CLEAN SHOVEL, CAREFULLY
PLACE MATL INTO CLEAN, DRY CNTNRS AND COVER; REMOVE FROM AREA.
FLUSH SPILL AREA WITH WATER.
Neutralizing Agent:
*Handling and Storage *
Handling and Storage Precautions:KEEP CNTNR TIGHTLY CLOSED. STORE IN
COOL, DRY, WELL-VENTILATED AREA AWAY FROM HEAT, SPARKS OR FLAME.
Other Precautions:DURING USE AVOID CONTACT WITH EYES, SKIN CLOTHING.
WASH THOROUGHLY AFTER HANDLING.
* Physical/Chemical Properties *
Vapor Density:4.9
Appearance and Odor:WHITE CRYSTALLINE POWDER. AMINE-LIKE ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS, STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:HEAT, FLAME, OTHER SOURCES OF IGNITION,
MOISTURE.
Hazardous Decomposition Products:AMMONIA, FORMALDEHYDE, OXIDES OF
NITROGEN, CARBON MONOXIDE, CARBON DIOXIDE.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE IN ACCORDANCE WITH ALL APPLICABLE
FEDERAL, STATE, AND LOCAL ENVIRONMENTAL REGULATIONS. EPA HAZARDOUS
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NIOSH/MSHA APPROVED SELF-CONTAINED BREATH APPAR
IF TLV IS EXCEEDED.
Ventilation:LOCAL/MECH RECOMND;USE EXPLOSION.PROOF EQUIP. SEE SUP DATA.
Other Protective Equipment:AS REQUIRED TO AVOID SKIN CONTACT BREATHING
VAPORS.
Supplemental Safety and Health
NON-DANGEROUS SPARK-FREE AREAS. AVOID POTENTIAL IGNITION SOURCES.
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:NAPHTHA (PETROLEUM SPIRITS OR BENZIN)
Fraction by Wt: 2%
* Hazards Identification *
Effects of Overexposure:INHAL:CNS DAMAGE;RESP IRRIT;MUSCULAR
WEAKNESS;CONFUSION;IMPAIRED COORDINATION;HEADACHE;NAUSEA
* First Aid Measures *
First Aid:SKIN:WASH IMMEDIATELY WITH SOAP & WATER. EYE:WASH IMMEDIATELY
FRESH AIR & REST. INGEST:DO NOT INDUCE VOMITING CALL MD
IMMEDIATELY.
* Fire Fighting Measures *
Lower Limits:1.1
Upper Limits:6.0
Extinguishing Media:MECHANICAL FOAM, DRY CHEMICAL, WATER FOG, CO*2.
Fire Fighting Procedures:WATER STREAM WILL SPREAD FIRE. USE FRESH AIR
RESPIRATORS.
Unusual Fire/Explosion Hazard:A VAPOR ACCUMULATION WOULD FLASH AND/OR
EXPLODE IF IGNITED. COMBUSTIBLE LIQUID.
* Accidental Release Measures *
Spill Release Procedures:REMOVE ALL IGNITION SOURCES, AVOID BREATHING
VAPORS, PROVIDE ADEQUATE VENTILATION, ABSORB SPILLAGE. CALL
EMERGENCY NUMBER IF SPILLAGE POSES THREAT TO MAN OR ENVIRONMENT.
*Handling and Storage *
Handling and Storage Precautions:STORE IN COOL, WELL VENTILATED AREA.
KEEP CLOSURES TIGHT AND UPRIGHT TO PREVENT LEAKAGE. KEEP CLOSED
WHEN NOT IN USE. READ ALL WARNING LABELS.
Other Precautions:DO NOT TRANSFER TO UNMARKED CONTAINER. GROUND
CONTAINERS WHEN FILLING OR EMPTYING. USE ONLY WITH ADEQUATE
VENTILATION (EQUIVALENT TO OUTDOORS VENTILATION. AVOID POTENTIAL
IGNITION SOURCES.
* Physical/Chemical Properties *
HCC:F4
Vapor Pres:1.8
Vapor Density:4.9
Solubility in Water:NEGLIGIBLE
Appearance and Odor:WHITE WATER LIQUID, MILD HYDROCARBON ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
AVOID STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:AVOID HEAT,SPARKS, FLAME & OTHER IGNITION
SOURCES.
Hazardous Decomposition Products:CARBON MONOXIDE IF BURNED WITH
INSUFFICIENT AIR.
* Disposal Considerations *
Waste Disposal Methods:MFR RECOMMENDS USING A QUALIFIED DISPOSAL
COMPANY TO INCINERATE OR OTHERWISE DISCARD AT AN APPROVED FACILITY.
DISPOSAL METHOD MUST BE IAW FEDERAL, STATE AND LOCAL CODES. DO NOT
INCINERATE CLOSED CONTA INERS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NONE REQUIRED (MFR). NIOSH/MSHA APPROVED
RESPIRATOR APPROPRIATE FOR EXPOSURE OF CONCERN .
Ventilation:NONE REQUIRED.
Other Protective Equipment:NONE REQUIRED
Work Hygienic Practices:FOLLOW GOOD HOUSEKEEPING PRACTICES.
Supplemental Safety and Health
* Product Identification *
Product ID:BATHROOM DRAIN OPENER
Preparer's Name:FRED SPAETH
CAGE:ENF0R
CAGE:ENF0R
* Composition/Information on Ingredients *
Ingred Name:ACETIC ACID, MERCAPTO-, MONOSODIUM SALT; (SODIUM
THIOGLYCOLATE).
Fraction by Wt: 5%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:PROTEOLYTIC ENZYME
Fraction by Wt: 1%
OSHA PEL:N/K
ACGIH TLV:N/K
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:NONE KNOWN. CHRONIC EFFECTS:SOME
IRRITATION OR SENSITIZATION MAY OCCUR.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE KNOWN.
* First Aid Measures *
First Aid:SEEK MEDICAL ATTENTION AS NEEDED. EYE:FLUSH EYES WITH COPIUS
WITH SOAP AND WATER. INHAL:REMOVE FROM EXPOSURE. INGEST:IF LARGE
QUANTITI ES ARE SWALLOWED SEEK MEDICAL ATTENTION.
* Fire Fighting Measures *
Flash Point Method:PMCC
Extinguishing Media:AS REQUIRED SURROUNDING FIRE.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE
* Accidental Release Measures *
Spill Release Procedures:LARGE SOLID SPILLS:SWEEP INTO PROPER CONTAINER
DISCARD AS HAZARDOUS WASTE. LARGE SOLUTION SPILLS:DISCARD TO AN
INDUSTRIAL WASTE WATER TREATMENT FACILITY.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:FOR LEAKS:SOLID MATERIAL SWEEP UP
DISCARD PROPERLY. SOLUTIONS DISCARD TO WATER TREATMENT FACILITY.
Other Precautions:KEEP OUT OF THE REACH OF CHILDREN.
* Physical/Chemical Properties *
HCC:N1
Solubility in Water:SOLUBLE
Appearance and Odor:CLEAR TO LIGHT AMBER COLOR, SLIGHT SULFUR ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:SULFUR DIOXIDE
* Disposal Considerations *
Waste Disposal Methods:ACCORDING TO LOCAL, STATE, FEDERAL REGULATIONS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:IF PERSONAL EXPOS CANNOT BE CONTROLLED BELOW
APPLIC LIMITS BY VENT, WEAR A PROPERLY FITTED NIOSH/MSHA APPRVD ORG
VAP/PARRTICULATE RESP FOR PROT AGAINST MATLS IN ING SEC. WHEN
Ventilation:USE ONLY W/ADEQ VENT. LOC EXHST PREFERABLE. GEN EXHST
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:WASH HANDS AFTER USING.
Supplemental Safety and Health
EXPLO HAZ: REQUIRES SPECIAL PRECAUTIONS. DURING EMERGENCY CONDITIONS
OVEREXPOSURE TO DECOMP PRODUCTS MAY CAUSE A HEALTH HAZARD. SYMPTOMS
MAY NOT BE IMMEDIATELY APPARENT. OBTAIN MEDICAL ATTENTION. FIRE
FIGHT PROC: CONTAINERS TO PREVENT PRESS BUILD-UP AND POSSIBLE
AUTIOIGNITION OR EXPLOSION WHEN EXPOSED TO EXTREME HEAT.
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:VENT: BELOW APPLICABLE EXPOSURE LIMITS. REFER TO OSHA
Ingred Name:KEROSENE (PETROLEUM), HYDROTREATED; (MINERAL SPIRITS). VP:
2
Ingred Name:ETHYLENE GLYCOL. VP: 0.1
Fraction by Wt: 0-5%
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:TITANIUM OXIDE; (TITANIUM DIOXIDE).
Ingred Name:WASTE DISP METH: INCINERATE CLOSED CONTAINER. DISP OF I/A/W
FEDERAL, STATE AND LOCAL REGULATIONS REGARDING POLLUTION.
Ingred Name:EFTS OF OVEREXP: HAVE ASSOC RPTD & PRLNG OVEREXP TO
SOLVENTS WITH PERMANENT BRAIN & NERVOUS SYS DMG. HDCHE, (ING 7)
Ingred Name:ING 6: DIZZ, NAUSEA & LOSS OF COORDINATION ARE INDICATIONS
OF EXCESS EXPOS TO VAPS/SPRAY MIST. REDNESS & ITCHING (ING 8)
Ingred Name:ING 7: OR BURNING SENSATION MAY INDICATE EYE OR EXCESSIVE
SKIN EXPOSURE.
Ingred Name:OTHER PREC: AVOID CONTACT WITH SKIN AND EYES. THIS COATING
Ingred Name:ING 9: SUCH AS TITANIUM DIOXIDE/CALCIUM CARBONATE, WHICH
Ingred Name:RESP PROT: WEAR NIOSH/MSHA APPROVED PARTICULATE RESP FOR
PROT AGAINST NON-VOLATILE MATLS IN INGRED SECTION.
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:IRRIT OF EYES, SKIN & RESP SYS.
MAY CAUSE NERV SYS DEPRESS. EXTREME OVEREXP MAY RSLT IN UNCON &
POSSIBLY DEATH. CHRONIC: ETHYLENE GLYCOL IS CONSIDERED AN ANIMAL
TERATOGEN. IT HAS BEEN SHOWN TO C AUSE BIRTH DEFECTS IN RATS & MICE
AT HIGH DOSES WHEN GIVEN IN DRINKING H*2O/BY GAVAGE. THERE IS NO
(EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ: EVIDENCE TO INDICATE IT CAUSES BIRTH
DEFECTS IN HUMANS. PRLNG OVEREXP TO SOLV INGRED LISTED IN INGRED
SEC MAY CAUSE ADVERSE EFTS TO LIVER & URINARY SYS. RATS EXPOS TO
SUCH EXPOS LEVELS ARE NOT ATTAINABLE IN THE WORKPLACE. REPORTS (ING
6)
Medical Cond Aggravated by Exposure:NONE GENERALLY RECOGNIZED.
* First Aid Measures *
First Aid:INHAL: IF AFFECTED, REMOVE FROM EXPOSURE. RESTORE BREATHING.
KEEP WARM AND QUIET. SKIN: WASH AFFECTED AREA THOROUGHLY WITH SOAP
AND WATER. EYES: FLUSH EYES WITH LARGE AMOUNTS OF WATER FOR AT
* Fire Fighting Measures *
Flash Point Method:PMCC
Lower Limits:0.9 %
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL, FOAM.
Fire Fighting Procedures:NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP .
H*2O SPRAY MAY BE INEFTIVE. IF H*2O IS USED, FOG NOZZ ARE
PREFERABLE. H*2O MAY BE USED TO COOL CLSD (SUPP DATA)
Unusual Fire/Explosion Hazard:KEEP CNTNRS TIGHTLY CLSD. ISOLATE FROM
HEAT/ELEC EQUIP/SPARKS/OPEN FLAME. CLSD CNTNRS MAY EXPLO WHEN
EXPOS TO EXTREME HEAT. APPLICATION TO HOT SURF (SUPP DATA)
* Accidental Release Measures *
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION. VENTILATE AND
REMOVE WITH INERT ABSORBENT.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:CONTENTS ARE COMBUST. KEEP AWAY FROM
HEAT/OPEN FLAME. CONSULT NFPA CODE. USE APPRVD BONDING & GROUNDING
PROCEDURES. KEEP CNTNRS CLSD WHEN NOT IN USE.
Other Precautions:TRANSFER ONLY TO APPRVD CNTNRS W/COMPLETE & APPROP
LABELING. DO NOT TAKE INTERNALLY. KEEP OUT OF THE REACH OF
CHILDREN. INTENTIONAL MISUE BY DELIB CONC & INHALING CONTENTS CAN
BE HARMFUL/FATAL. AVOID BREATHING VAPOR & SPRAY MIST. (ING 9)
* Physical/Chemical Properties *
HCC:F4
Vapor Pres:SEE INGRED
Vapor Density:HVR/AIR
Spec Gravity:0.9-1.2
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
NONE SPECIFIED BY MANUFACTURER.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:BY FIRE: CARBON DIOXIDE, CARBON
MONOXIDE, OXIDES OF METALS IN INGREDIENT SECTION.
* Disposal Considerations *
Waste Disposal Methods:WASTE FORM PROD MAY BE HAZ AS DEFINED UNDER RCRA
BE TESTED FOR EXTRACTABI LITY. INCIN IN APPRVD FACILITY. DO NOT
(ING 5)
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:USE NUISANCE DUST MASK WHILE GRINDING FIRED
PORCELAIN.
Ventilation:MECHANICAL/EXHAUST
Other Protective Equipment:AS REQUIRED
Supplemental Safety and Health
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:MANGANESE, MN COMPOUNDS
Fraction by Wt: <5%
OSHA PEL:(C) 5 MG/M3 DUST
Ingred Name:NICKEL (SOLUBLE)
INTENDED CHANGE (IC)
Fraction by Wt: <5%
Other REC Limits:1 MG/CUM
OSHA PEL:1 MG/CUM
Ingred Name:TIN (AS SN)
Fraction by Wt: <5%
OSHA PEL:2.0 MG/CUM
ACGIH TLV:2.0 MG/CUM
Ingred Name:TITANIUM DIOXIDE, TITANIUM(IV) OXIDE, TIO2
Fraction by Wt: <5%
Ingred Name:VANADIUM
Fraction by Wt: <5%
OSHA PEL:C,0.5 MG/M3
Ingred Name:ZIRCONIUM
Fraction by Wt: <5%
OSHA PEL:5 MG/CUM
ACGIH TLV:5 MG/CUM
Ingred Name:CALCIUM OXIDE; LIME
Fraction by Wt: <5%
OSHA PEL:5 MG/CUM
ACGIH TLV:2 MG/CUM
Ingred Name:MAGNESIUM OXIDE, MAGNESIA
Fraction by Wt: <5%
Ingred Name:SILICA, CRYSTALLINE - FUSED
Fraction by Wt: <5%
OSHA PEL:SEE TABLE Z3
Ingred Name:ZINC OXIDE
Fraction by Wt: <5%
Ingred Name:ALUMINUM OXIDE, BAUXITE, ALUMINA, DIALUMINUM TRIOXIDE
Fraction by Wt: <5%
Ingred Name:BARIUM (SOLUBLE COMPOUNDS)
Fraction by Wt: <5%
OSHA PEL:0.5 MG/CUM
ACGIH TLV:0.5 MG/CUM
Ingred Name:BORON OXIDE, TRIOXIDE
Fraction by Wt: <5%
Ingred Name:CHROMIUM METAL, CHROMIUM, CHROME (SUSPECTED A1 HUMAN
CARCINOGEN BY IARC, NTP & ACGIH)
Fraction by Wt: <5%
OSHA PEL:1 MG/CUM
ACGIH TLV:0.5 MG/CUM
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:COBALT
Fraction by Wt: <5%
OSHA PEL:0.1 MG/M3;AS CO
Ingred Name:RED IRON OXIDE/IRON (III) OXIDE/FERRIC OXIDE/YELLOW FERRIC
OXIDE/METAL OXIDE/YELLOW IRON OXIDE/IRON OXIDE PIGMENT/IRON
Fraction by Wt: <5%
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Explanation of Carcinogenicity:CHROMIUM IS A SUSPECTED HUMAN CARCINOGEN
BY ACGIH.
* Fire Fighting Measures *
Flash Point:NON-FLAMMABLE
* Accidental Release Measures *
Spill Release Procedures:SWEEP UP SPILLED MATERIAL.
*Handling and Storage *
Handling and Storage Precautions:AVOID BREATHING CERAMIC DUST & LICKING
CERAMIC APPLICATION BRUSH.
* Physical/Chemical Properties *
Solubility in Water:INSOLUBLE
Appearance and Odor:WHITE OR LIGHT PASTEL COLORED PORCELAIN POWDER W/NO
ODOR
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
CONCENTRATED HYDROFLUORIC ACID
* Disposal Considerations *
Waste Disposal Methods:DISPOSE AS SOLID WASTE IN COMPLIANCE W/STATE,
FEDERAL & LOCAL REGULATIONS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:AS REQUIRED
Ventilation:GENERAL MECHANICAL IF GROUND, HOT-STAKED OR SOLDERED. LOCAL
EXHAUST FOR GRINDING, BURINING & MOLTEN CONDITIONS.
Supplemental Safety and Health
UNDER SOME SOLDERING, HOT-STAKING OR OTHER VERY HIGH TEMPERATURE
CONDITIONS, TOLUENEDI-ISOCYANATE (TDI) OR OTHER ISOCYANATE
FRACTIONS MAY BE GIVEN OFF.
* Product Identification *
Product ID:COPPER-BASED,FILM-INSULATED MAGNET WIRE
Preparer's Name:FRANCOIS A LAVALLEE
* Composition/Information on Ingredients *
Ingred Name:COPPER (DUST & MIST), BRONZE POWDER
Other REC Limits:1 MG(CU)/M3 (DUST)
OSHA PEL:0.1 MG(CU)/M3 (FUME)
ACGIH TLV:0.2 MG/M3 (FUME)
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: RESPIRATORY TRACT
IRRITATION, METALLIC TASTE IN MOUTH, NAUSEA. SKIN: DISCOLORATION,
SENSITIZATION, MUCOUS MEMBRANES IRRITATION. EYES: IRRITATION.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:INHALATION: METAL FUME FEVER.
* First Aid Measures *
First Aid:SKIN: WASH W/SOAP & WATER. EYES: FLUSH W/PLENTY OF WATER.
INHALATION: REMOVE TO FRESH AIR. SEEK MEDICAL ATTENTION IN ALL
CASES.
* Fire Fighting Measures *
Extinguishing Media:COMPATIBLE W/ALL TYPES (A,B,C). AVOID WATER ON
MOLTEN METAL.
Fire Fighting Procedures:MATCH THE TECHNIQUE TO THE TYPE OF FIRE.
Unusual Fire/Explosion Hazard:CONTACT OF WATER W/MOLTEN COPPER CAN
CAUSE EXPLOSION.
* Physical/Chemical Properties *
Vapor Pres:<1
Evaporation Rate & Reference:NOT MEASURABLE
Solubility in Water:INSOLUBLE
Appearance and Odor:AMBER OR COLORED SOLID, W/NO ODOR
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
CONCENTRATED ACIDS & BASES. BARE CONDUCTOR SHOULD NOT CONTACT ACETYLENE
GAS OR MAGNESIUM.
Stability Condition to Avoid:HIGH TEMPERATURES
Hazardous Decomposition Products:H2O, CO, CO2, OXIDES OF NITROGEN &
COMPONENT INGREDIENTS. TOLUENEDI-ISOCYANATE OR OTHER ISOCYANATE
FRACTIONS.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/LOCAL, STATE, &
FEDERAL REGULATIONS. RECYCLE CONDUCTOR, OR SUITABLE LANDFILL.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NONE NORMALLY REQUIRED. IF EXPOSURE MAY OR DOES
EXCEED OCCUPATIONAL EXPOSURE LIMITS, WEAR A NIOSH-APPROVED ORGANIC
VAPOR RESPIRATOR.
Ventilation:USE ADEQUATE VENTILATION TO KEEP OIL MISTS OF THIS MATERIAL
BELOW APPLICABLE STANDARD(S).
Other Protective Equipment:EYE WASH STATION AND SAFETY SHOWER.
INDUSTRIAL-TYPE WORK CLOTHING AND APRON AS REQUIRED.
Work Hygienic Practices:OBSERVE GOOD PERSONAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES.
Supplemental Safety and Health
FORMULA CHANGED. FOR PREVIOUS FORMULATION, SEE PNI A, SAME NSN.
* Product Identification *
Preparer's Name:J.C. WILLETT
* Composition/Information on Ingredients *
Ingred Name:MINERAL OIL, PETROLEUM DISTILLATES,HYDROTREATED
(MILD),HEAVY PARAFFINIC
Other REC Limits:NONE RECOMMENDED
OSHA PEL:5 MG/M3 (OIL MIST)
ACGIH TLV:5 MG/M3 (OIL MIST)
Ingred Name:MINERAL OIL, PETROLEUM DISTILLATE, SOLVENT DDEWAXED
(SEVERE), HEAVY PARAFFINIC
Other REC Limits:NONE RECOMMENDED
OSHA PEL:5 MG/M3 AS OIL MIST
ACGIH TLV:5 MG/M3 AS OIL MIST
Ingred Name:MINOR ADDITIVES
Fraction by Wt: <2%
Other REC Limits:NONE RECOMMENDED
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:TARGET ORGANS:EYE, SKIN, RESPIRATORY
TRACT. ACUTE- PRESUMED TO BE NON-IRRITATING TO EYES & SKIN.
PROLONGED/REPEATED SKIN CONTACT CAUSES DERMATITIS, FOLLICULITIS/OIL
ACNE. INJECTION UNDER SKIN CAUSES L OCAL NECROSIS. INHALATION OF
VAPORS/OILMIST MAY CAUSE MILD IRRITATION. SLIGHTLY TOXIC IF
INGESTED. CHRONIC- DERMATITIS.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION
Medical Cond Aggravated by Exposure:PERSONS WITH PRE-EXISTING SKIN AND
RESPIRATORY DISORDERS MAY BE MORE SUSCEPTIBLE TO THE EFFECTS OF
THIS PRODUCT.
* First Aid Measures *
First Aid:CALL A DOCTOR IF SYMPTOMS OCCUR. EYE:FLUSH WITH WATER. HOLD
EYELIDS OPEN. SKIN:WIPE EXCESS OFF. WASH SKIN WITH SOAP & WATER OR
A WATERLESS HAND CLEANER FOLLOWED BY SOAP & WATER. IF MATERIAL IS
INJECTE D UNDER SKIN, GET MEDICAL ATTENTION PROMPTLY. DO NOT WAIT
FOR SYMPTOMS TO DEVELOP. INHALED:REMOVE TO FRESH AIR. PROVIDE
CPR/OXYGEN IF NEEDED. ORAL:DO NOT INDUCE VOMITING. GET MEDICAL
ADVICE.
* Fire Fighting Measures *
Flash Point Method:PMCC
Extinguishing Media:USE WATER FOG, CARBON DIOXIDE, FOAM/DRY CHEMICAL.
DO NOT USE A DIRECT STREAM OF WATER. PRODUCT MAY FLOAT & REIGNITE.
Fire Fighting Procedures:WEAR FIRE FIGHTING PROTECTIVE EQUIPMENT AND
NIOSH-APPROVED SELF CONTAINED BREATHING APPARATUS. COOL FIRE
EXPOSED CONTAINERS WITH WATER SPRAY.
Unusual Fire/Explosion Hazard:CONTAINER MAY BURST.
* Accidental Release Measures *
Spill Release Procedures:WEAR PROTECTIVE EQUIPMENT. STOP LEAK. DIKE AND
CONTAIN. USE PUMP TO TRANSFER LARGE SPILLS TO CONTAINER. REMAINING
LIQUID/SMALL SPILLS CAN BE TAKEN UP ON SAND, CLAY, EARTH & SHOVELD
INTO CONTAINERS. PR EVENT RUN-OFF TO ENTER WATERWAYS, SEWERS.
Neutralizing Agent:NOT RELEVANT
*Handling and Storage *
Handling and Storage Precautions:STORE IN COOL, DRY PLACE AWAY FROM
HEAT, FLAME & STRONG OXIDANTS. KEEP CONTAINERS CLOSED WHEN NOT IN
USE.
Other Precautions:DO NOT GET IN EYES, ON SKIN OR ON CLOTHING. WASH
THOROUGHLY AFTER HANDLING. WATER CONTAMINATION SHOULD BE AVOIDED.
AVOID BREATHING OIL MIST. DISCARD LUBRICANT-SOAKED SHOES. REMOVE
LUBRICANT-SOAKED CLO THING AND LAUNDER BEFORE RE-USE.
* Physical/Chemical Properties *
HCC:V6
NRC/State Lic Num:NOT RELEVANT
Solubility in Water:NEGLIGIBLE
Appearance and Odor:PALE YELLOW OIL - SLIGHT HYDROCARBON ODOR
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
OXIDIZING AGENTS
Stability Condition to Avoid:EXCESSIVE HEAT, OPEN FLAME
Hazardous Decomposition Products:A COMPLEX MIXTURE OF AIRBORNE SOLID,
LIQUID, PARTICULATES & GASES WILL EVOVLE. CARBON MONOXIDE & OTHER
COMPD. MAY FORM.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF WASTE IN COMPLIANCE WITH ALL
APPLICABLE LOCAL, STATE AND FEDERAL LAWS AND REGULATIONS. RCRA
STREAMS, PONDS OR UNDERGROUND WATER SUPPLY.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR.
Ventilation:LOCAL EXHAUST & MECHANICAL (GENERAL) RECOMMENDED.
Other Protective Equipment:COVERALLS, RUBBER BOOTS, SAFETY SHOWER & EYE
BATH.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
INGEST:WASH MOUTH OUT W/WATER & CONSULT MD.
* Product Identification *
Product ID:ACETYL ACETONE
* Composition/Information on Ingredients *
Ingred Name:2,4-PENTANEDIONE; (ACETYL ACETONE)
Ingred Name:2:4-HEXANE DIONE
Fraction by Wt: 1%
Ingred Name:ACETIC ACID
Fraction by Wt: 0.3%
Ingred Name:2-HEPTANONE
Fraction by Wt: <1%
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:IRRITANT. MAY BE HARMFUL BY
INHALATION, INGESTION OR SKIN ABSORPTION. CAUSES EYE IRRITATION.
MAY CAUSE SKIN IRRITATION. EXPOSURE CAN CAUSE NAUSEA, HEADACHE &
VOMITING. MAY BE NEUROTOXIC, GENOTOXIC W/P OSSIBLE POTENTIAL TO
PRODUCE HERITABLE MUTATION & DEVELOPMENTALLY TOXIC. HAS BEEN
REPORTED TO CAUSE (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:CONTACT DERMATITIS & CONTACT URTICARIA
IN HUMANS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
* First Aid Measures *
First Aid:IN ABSENCE OF SPECIFIC INFO, USE STD FIRST AID PROC. CONSULT
MD IN ALL INSTANCES. INHAL:REMOVE TO FRESH AIR. IF BRTHG HAS
STOPPED GIVE ARTF RESP. IF BRTHG IS DFCLT GIVE O2. EYE:IMMED FLUSH
FLUSHING BY SEPARATING EYELIDS W/FINGERS. SKIN:IMMED WASH W/SOAP &
COPIOUS AMTS OF WATER WHILE REMOVING CONTAMD CLTHG. WASH CONTAMD
CLTHG (SUPP DATA)
* Fire Fighting Measures *
Flash Point Method:CC
Lower Limits:2.4%
Extinguishing Media:CO2, DRY CHEM POWDER, ALCOHOL OR POLYMER FOAM.
WATER MAY BE EFFECTIVE FOR COOLING, BUT MAY NOT EFFECT
EXTINGUISHMENT.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:VAP MAY TRAVEL CONSIDERABLE DISTANCE TO
SOURCE OF IGNITION & FLASH BACK. CONTAINER EXPLOSION MAY OCCUR
UNDER FIRE CNDTNS. FORMS EXPLOSIVE MIXTURE IN THE AIR.
* Accidental Release Measures *
Spill Release Procedures:EVACUATE AREA. SHUT OFF ALL SOURCES OF
IGNITION. WEAR NIOSH/MSHA SCBA. COVER W/AN ACITVATED CARBON
ABSORBENT, TAKE UP & PLACE IN CLOSED CONTAINERS. TRANSPORT
OUTDOORS. VENTILATE AREA & WASH SPILL SITEAFTER MATERIAL PICKUP
IS COMPLETE.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:USE ONLY IN A WELL-VENTILATED AREA.
USE NON- SPARKING TOOLS. DO NOT BREATHE VAPOR. AVOID CONTACT
W/EYES, SKIN & CLOTHING.
Other Precautions:IRRIT. POSS MUTAGEN. KEEP TIGHTLY CLSD. KEEP AWAY
FROM HEAT, SPARKS AND OPEN FLAME. REFRIGERATE. FLAM. VAP MAY TRAVEL
CONSIDERABLE DISTANCE TO SOURCE OF IGNIT & FLASH BACK. CONTR EXPLOS
MAY OCCUR UNDE R FIRE CNDTNS. FORMS EXPLOS MIX IN AIR.
* Physical/Chemical Properties *
HCC:F4
Vapor Density:SUPP DATA
Appearance and Odor:COLORLESS OR PALE YELLOW LIQUID W/PLEASANT, SWEET
ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
OXIDIZING AGENTS, HALOGENS, STRONG REDUCING AGENTS & STRONG BASES.
Stability Condition to Avoid:HEAT, OPEN FLAME & SPARKS.
Hazardous Decomposition Products:TOXIC FUMES OF: CO & CO2.
* Disposal Considerations *
Waste Disposal Methods:DISPOSAL MUST BE IN ACCORDANCE WITH FEDERAL,
STATE & LOCAL REGULATIONS .
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NOT REQUIRED UNDER CONDIITONS OF NORMAL USE.IF
VAP MIST GENERATED USE NIOSH CERTIFIED ORG VAP RESPIRATOR
W/DUST/MIST FILTER.
Ventilation:LOCAL EXHU/HOOD OR FAN MAY BE USED.SET TO MAINTAIN BELOW
TLV.MECHANICAL:NONE REQUIRED.
Other Protective Equipment:NONE NORMALLY REQUIRED.
Work Hygienic Practices:WASH CONTAMIN CLOTH BEF REUSE.USE W/ADEQUATE
VENTILATION.WASH HANDS AFT USE.
Supplemental Safety and Health
HEALTH HAZ:EXPO TO HIGH VAP CONC MAY CAUSE SLIGHT TEMP IRRIT.SPLASHES
WILL CAUSE PAINFUL BURNING/STINGING.SKIN:PROL/REP EXPO MAY CAUSE
SKIN IRRIT,RASHES,DEFATTING.REP LONG-TERM CONTACT MAY CAUSE EXCES
SIVE DRYING/FLAKING. SPILL:BODIES OF WATER;IF IT OCCURS NOTIFY
PROPER AUTHORITIES.
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:BUTYROLACTONE; (GAMMA-BUTYROLLACTONE (BL0))
Other REC Limits:NONE RECOMMENDED
Ingred Name:N-METHYLPYRROLIDONE (NMP)
Other REC Limits:NONE RECOMMENDED
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INGEST:NO EFFECTS OF EXPO
EXPECTED.INHAL:ASPIRATION INTO LUNGS MAY CAUSE INJURY.EXCESSIVE VAP
INHAL MAY CAUSE PALLOR,NAU,LACK OF COORDINATION,STUPOR.PRODUCT LOW
VAP PRESSURE & NOT EXPECTED TO PRESENT INHAL HAZ @AMB
CONDITONS.CAUT SHOULD BETAKEN TO PREVENT AEROSOLIZATION/MIST W/O
TAKING SPEC PRECAUT.EYES:(SUPPLEMENTAL)
Effects of Overexposure:ASPIRATION INTO LUNGS HAZ MAY CAUSE INJURY.
PALLOR, NAUSEA, LACK OF COORDINATION, STUPOR. SLIGHT TEMP EYE
IRRIT, PAINFUL BURNING OR STINGING. SKIN IRRIT, RASHES, DEFATTING,
DRYING, FLAKING OF SKIN.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
* First Aid Measures *
First Aid:INGEST:DRINK 2 GLASSES OF WATER.INDUCE VOMIT.CALL PHYSICIAN.
INHAL:REMOVE TO FRESH AIR.DIFFICULT IN BREATH GIVE OXY.CALL
PHYSICIAN. SKIN:WA SH OFF IN FLOWING WATER OR SHOWER
USINGSOAP/WATER.REMOVE CONTAMIN CLOTH.
* Fire Fighting Measures *
Flash Point Method:PMCC
Autoignition Temp:Autoignition Temp Text:NP
Lower Limits:NO DATA FOUN
Upper Limits:NO DATA FOUN
Extinguishing Media:ALCOHOL FOAM, CO2, DRY CHEMICALS.
Fire Fighting Procedures:FIGHT AS HYDROCARBON FIRE. WEAR SELF-CONTAINED
NIOSH APPROVED BREATHING APPARATUS. STAY UPWIND OF FIRE.
Unusual Fire/Explosion Hazard:NON-TOXIC & TOXIC FUMES MAY FORM UPON
COMBUSTION. STAY UPWIND OF FIRE.
* Accidental Release Measures *
Spill Release Procedures:SM:REMOVE ALL IGN SOURCES.ABSORB ON
VERMICULITE ABSORBENT.LG:REMOVE ALL IGN SOURCES.PERSON NOT WEAR PPE
SHOULD BE EXCLUDED FORM AREA.DIKE TO PREVENT SPREADING.BEGIN
PUMPING INTO STORAGE/RECYCLING TK/D R.PREVENT RUNOFFS TO
SEWERS/STREAMS/OTHER (SUPPLE)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:TREAT AS COMBUSTIBLE LIQUID.ALWAYS
KEEP CNTNR CLOSED.READ LABEL BEFORE USE.AVOID EXCESSIVE CONTACT
W/FUMES/LIQUID.
SHOULD BE HANDLED W/CARE AROUND OPEN FLAME.
* Physical/Chemical Properties *
HCC:V4
Melt/Freeze Pt:M.P/F.P Text:NA
Decomp Temp:Decomp Text:NP
Vapor Pres:<1
Vapor Density:>1
pH:NP
Viscosity:NP
Evaporation Rate & Reference:<1 (N-BUTYL ACETATE=1)
Solubility in Water:COMPLETE
Appearance and Odor:CLEAR, COLORLESS LIQUID WITH MILD ODOR.
Percent Volatiles by Volume:NP
Corrosion Rate:NP
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
AVOID CONTACT W/STRONG OXIDIZING OR REDUCING AGENTS.
Stability Condition to Avoid:HEATING ABOVE FLASH POINT.
Hazardous Decomposition Products:OXIDES OF CARBON & NITROGEN MAY BE
FORMED UPON COMBUSTION.
* Disposal Considerations *
Waste Disposal Methods:MALT SHOULD BE RECYCLED & REUSED IN COMPLIANCE
W/STATE/FED REGS.PROD NOT CONSIDERED HAZ/RESTRICTED BY EPA
RCRA.MATL IN ITS PURCHASED FORM NOT REG UNDER SARA TITLE III SEC
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:IF WORKPLACE EXPOS LIM(S) OF PROD/ANY COMPONENT
IS EXCEEDED, A NIOSH/MSHA APPRVD AIR SUPPLIED RESP IS ADVISED IN
ABSENCE OF PROPER ENVIRON CONTROL. OSHA REGS ALSO PERMIT OTHER
NIOSH/MSHA APPRVD RESP ( NEG PRESS TYPE) UNDER SPECIFIED (ING 5)
Ventilation:MATERIAL SHOULD BE HANDLED OR TRANSFERRED IN AN APPROVED
FUME HOOD OR WITH ADEQUATE VENTILATION.
Other Protective Equipment:EYE WASH AND SAFETY EQUIPMENT SHOULD BE
READILY AVAILABLE.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
EXPLOS HAZ:MAY OCCUR AT TEMP BELOW PUB AUTOIGNIT/IGNIT TEMP. IGNIT TEMP
DECREASE W/INCREASED VAP VOL & VAP/AIR CONTACT TIME & ARE
INFLUENCED BY PRESS CHANGES. IGNIT MAY OCCUR AT TYPICAL ELEVATED
TEMP PROCESS CONDTNS, ESP IN PROCESS OPERATING UNDER VACUUM IF
SUBJECTED TO SUDDEN INGRESS OF AIR/OUTSIDE (ING 3)
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:ACETONE; (DIMETHYL KETONE) (2-PROPANONE) (SARA III)
Ingred Name:BENZENE (SARA III)
OSHA PEL:1 PPM;5 STEL
Ingred Name:SUPDAT:PROCESS EQUIP OPERATING UNDER ELEVATED PRESS IF
SUDDEN ESCAPE OF VAP/MIST TO ATMOSPHERE OCCURS. DANGEROUS (ING 4)
Ingred Name:ING 3:FIRE AND EXPLOSION HAZARD.
Ingred Name:RESP PROT:CONDTNS (SEE YOUR SAFETY EQUIPMENT SUPPLIER).
ENGINEERING AND/OR ADMIN CONTROLS SHOULD BE IMPLEMENTED (ING 6)
Ingred Name:ING 5:TO REDUCE EXPOSURE.
CONTACT.
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:HARMFUL IF INHALED OR INGESTED. HIGH
CONCENTRATIONS OR PROLONGED EXPOSURE CAUSES HEADACHE, DIZZINESS,
NAUSEA, IRRITATION OF EYES AND RESPIRATORY TRACT, NARCOSIS AND
EVENTUALLY UNCONSCIOUSNESS. MAY CAU SE DAMAGE TO CNS, LIVER AND
KIDNEYS. PROLONGED OR REPEATED SKIN CONTACT MAY CAUSE IRRITATION.
(EFTS OF OVEREXPOS)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:EYE CONTACT CAUSES IRRIT. ANIMAL
STUDIES SHOW ADVERSE EFS ON FERTILITY WHEN FEMALES WERE EXPOSED
CHRONICALLY DURING PREGNANCY. TESTS ON LAB ANIMALS INDICATE
MATERIAL MAY PRODUCE ADVERSE MUTAG ENIC & REPRODUCTIVE EFFECTS.
CONTAINS ATRACE AMT OF BENZENE WHICH HAS BEEN FOUND TO BE
CARCINOGENIC TO HUMANS .
Medical Cond Aggravated by Exposure:SKIN CONTACT AND PREGNANCY.
* First Aid Measures *
First Aid:GET MD ASSISTANCE FOR ALL CASES OF OVEREXPOSURE. SKIN:WASH
THOROUGHLY WITH SOAP AND WATER. EYES:IMMEDIATELY FLUSH THOROUGHLY
ARTIFIC IAL RESPIRATION IF BREATHING HAS STOPPED. INGEST:IF
CONSCIOUS, DRINK WATER AND INDUCE VOMITING IMMEDIATELY AS DIRECTED
BY MEDICAL PERSONNEL. NEVER GIVE ANYTHING BY MOUTH TO AN
UNCONSCIOUS PERSON.
* Fire Fighting Measures *
Flash Point Method:CC
Lower Limits:2.6%
Extinguishing Media:DRY CHEMICAL, "ALCOHOL" FOAM, WATER SPRAY, CARBON
DIOXIDE.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT . USE WATER SPRAY TO COOL EXPOSED CONTAINERS.
Unusual Fire/Explosion Hazard:VAP CAN TRAVEL DISTANCES TO IGNIT SOURCE
& FLASH BACK. HOT ORG CHEM VAP/MISTS ARE SUSCEPTIBLE TO SUDDEN
SPONTANEOUS COMBUST WHEN MIXED W/AIR. IGNIT (SUPDAT)
* Accidental Release Measures *
Spill Release Procedures:DIKE SPILL; TAKE UP WITH ABSORBENT.
CONTAINERIZE FOR PROPER DISPOSAL.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:KEEP CONTR CLSD. STORE IN COOL AREA
AWAY FROM IGNIT SOURCES & OXIDIZERS. DO NOT BRTH VAP. DO NOT GET IN
EYES. AVOID PRLNGD/RPTD SKIN CONTACT.
Other Precautions:ELECTRICALLY GROUND ALL EQUIPMENT WHEN HANDLING
PRODUCT. RETAINED RESIDUE MAY MAKE EMPTY CONTAINER HAZARDOUS; USE
CAUTION! DO NOT TAKE INTERNALLY. REMOVE CONTAMINATED CLOTHING AND
WASH BEFORE REUSE.
* Physical/Chemical Properties *
Vapor Density:2.0
Solubility in Water:MISCIBLE
Appearance and Odor:COLORLESS LIQUID WITH PUNGENT ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
ACIDS, OXIDIZERS, POTASSIUM T-BUTOXIDE, NITRIC AND SULFURIC ACID
MIXTURE, BROMINE AND CHLORINE.
Stability Condition to Avoid:HEAT, CONTACT WITH IGNITION SOURCE.
Hazardous Decomposition Products:CO*X.
* Disposal Considerations *
Waste Disposal Methods:TO BE PERFORMED IN COMPLIANCE WITH ALL CURRENT
LOCAL, STATE AND FEDERAL REGULATIONS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NIOSH,MSHA APPROVED AIR SUPPLIED RESPIRATOR.
Ventilation:MECHANICAL ACCEPTABLE, LOCAL EXHAUST PREFERRED.
Other Protective Equipment:METATARSAL SHOES FOR CYLINDER HANDLING
Work Hygienic Practices:STANDARD PRACTICES AND PROCEDURES.
Supplemental Safety and Health
NONE
* Product Identification *
Product ID:NITROGEN
* Composition/Information on Ingredients *
Ingred Name:NITROGEN
Other REC Limits: SPECIFIED
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ASPHYXIANT. MODERATE CONCENTRATIONS
MAY CAUSE HEADACHE, DROWSINESS, DIZZINESS, EXCITATION, EXCESS
SALIVATION, VOMITING AND UNCONSCIOUSNESS. LACK OF OXYGEN CAN CAUSE
DEATH.
Effects of Overexposure:INHALATION: ASPHYXIANT. MODERATE CONCENTRATIONS
MAY CAUSE HEADACHE, DROWSINESS, DIZZINESS, EXCITATION, EXCESS
SALIVATION, VOMITING AND UNCONSCIOUSNESS. LACK OF OXYGEN CAN CAUSE
DEATH.
Medical Cond Aggravated by Exposure:THE TOXICOLOGY AND THE PHYSICAL AND
CHEMICAL PROPERTIES OF THE MATERIAL DO NOT SUGGEST THAT
OVEREXPOSURE IS LIKELY TO AGGRAVATE EXISTING MEDICAL CONDITIONS.
* First Aid Measures *
First Aid:INHALATION: REMOVE TO FRESH AIR. GIVE ARTIFICIAL RESPIRATION
IF NOT BREATHING. GIVE OXYGEN IF BREATHING IS DIFFICULT. SEE
DOCTOR.
* Fire Fighting Measures *
Flash Point:
Extinguishing Media:USE MEDIA APPROPRIATE FOR SURROUNDING FIRE.
Fire Fighting Procedures:EVACUATE AREA. DELUGE CYLINDER WITH WATER
SPRAY FROM MAXIMUM DISTANCE UNTIL COOL.
Unusual Fire/Explosion Hazard:CONTAINER MAY RUPTURE DUE TO HEAT OF
* Accidental Release Measures *
Spill Release Procedures:EVACUATE AREA. USE SCBA. SHUT OFF LEAK IF
WITHOUT RISK. VENTILATE AREA OF LEAK OR MOVE LEAKER TO
WELL-VENTILATED AREA. TEST AREA FOR SUFFICIENT OXYGEN CONTENT PRIOR
TO PERMITTING RE-ENTRY OF PERSONNEL .
*Handling and Storage *
Handling and Storage Precautions:HIGH PRESSURE GAS. USE PIPING/EQUIP
DESIGNED TO WITHSTAND PRESSURE. CAN CAUSE RAPID SUFFOCATION DUE TO
OXYGEN DEFICIENCY. STORE W/ADEQUATE VENTILATION
Other Precautions:CLOSE VALVE WHEN NOT IN USE & WHEN EMPTY. NEVER WORK
ON A PRESSURIZED SYSTEM. IF LEAKING, CLOSE CYLINDER VALVE,BLOW DOWN
SYSTEM BY VENTING TO SAFE PLACE, THEN REPAIR THE LEAK.
* Physical/Chemical Properties *
HCC:G3
Vapor Pres:,GAS
Spec Gravity:N/R, GAS
Solubility in Water:NEGLIGIBLE
Appearance and Odor:COLORLESS, ODORLESS GAS AT NORMAL TEMPERATURE AND
PRESSURE.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
CURRENTLY KNOWN
Stability Condition to Avoid:HEAT, OPEN FLAMES.
Hazardous Decomposition Products:
* Disposal Considerations *
Waste Disposal Methods:SLOWLY RELEASE INTO ATMOSPHERE. DISCARD ANY
RESIDUE,PRODUCT,DISPOSABLE CONTAINER IN FULL COMPLIANCE WITH
FEDERAL, STATE AND LOCAL REGULATIONS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE
FOR EXPOSURE OF CONCERN .
Ventilation:PROVIDE SUFFICIENT VENTILATION TO MAINTAIN VAPOR CONC BELOW
TLV.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
* Product Identification *
CAGE:NWEST
CAGE:NWEST
* Composition/Information on Ingredients *
Ingred Name:METHANE, CHLORODIFLUORO-; (FREON TA)
OSHA PEL:N/K
Ozone Depleting Chemical:2
Ingred Name:N,N-DIALKYLTOLUIDINE
Fraction by Wt: <1%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:HYDROQUINONE
Fraction by Wt: <1%
OSHA PEL:2 MG/M3
ACGIH TLV:2 MG/M3
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:HEADACHE, DIZZINESS, SHORTNESS OF
BREATH. CHLOROFLUOROCABON MATERIALS HAVE PRODUCED SENSITIZATION OF
MYOCARDIUM TO EPINEPHRINE IN LAB ANIMALS AND COULD HAVE SIMILAR
EFFECT IN HUMANS. ADRENOMIMETICS (E .G., EPINEPHRINE) MAY BE
CONTRAINDICATED EXCEPT FOR LIFE-SUSTAINING USES IN HUMANS ACUTELY
OR (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ: CHRONICALLY EXPOSED TO CFCS .
Medical Cond Aggravated by Exposure:
* First Aid Measures *
First Aid:INGEST: DO NOT INDUCE VOMIT. KEEP CALM. OBTAIN MED ATTN.
INHAL: REMOVE TO FRESH AIR. IF SYMPS PERSIST, OBTAIN MED ATTN.
* Fire Fighting Measures *
Flash Point Method:TCC
Flash Point:NONE
Extinguishing Media:CO*2, FOAM, DRY CHEMICAL.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED PRESSURE DEMAND SCBA
AND FULL PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:THERMAL DECOMPOSITION PRODUCTS MAY
INCLUDE CHLORIDES, FLUORIDES AND PHOSGENE .
* Accidental Release Measures *
Spill Release Procedures:ALLOW TO EVAPORATE WITH GOOD VENTILATION.
Neutralizing Agent:
*Handling and Storage *
Other Precautions:NO SMOKING IN AREA OF USE. DO NOT USE IN GENERAL
VICINITY OF ARC WELDING, OPEN FLAMES/HOT SURFACES. HEAT &/OR UV
RADIATION MAY CAUSE FORMATION OF CHLORIDES FLUORIDES AND PHOSGENE .
* Physical/Chemical Properties *
Vapor Density:2.6
Solubility in Water:SLIGHT
Appearance and Odor:AMBER LIQUID, MILD ODOR
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
NONE.
Stability Condition to Avoid:
Hazardous Decomposition Products:BY FIRE OR THERMAL DECOMPOSITION:
TOXIC CHLORIDES AND FLUORIDES. PHOSGENE .
* Disposal Considerations *
Waste Disposal Methods:BURY OR INCINERATE I/A/W EPA AND LOCAL, FEDERAL
AND STATE REGULATIONS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NIOSH APPROVED RESPIRATOR APPROPRIATE FOR
WORKPLACE CONDITIONS WAR RANT A RESPIRATOR'S USE.
Ventilation:USE ADEQUATE VENTILATION TO KEEP AIRBORNE CONCENTRATIONS
LOW.
Other Protective Equipment:ANSI APPRVD EYE WASH & DELUGE SHOWER . WEAR
APPROP PROT CLTHG TO PREVENT SKIN EXPOSURE.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING. REMOVE
CONTAMINATED CLOTHING & WASH BEFORE REUSE.
Supplemental Safety and Health
FIRST AID PROC:TO FRESH AIR IMMED. IF NOT BRTHG, GIVE ARTF RESP. IF
BRTHG IS DFCLT, GIVE OXYG. NOTES TO PHYS:TREAT SYMPTOMATICALLY &
SUPPORTIVELY.
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:1,3 PROPANEDIOL, 2-AMINO-2-(HYDROXYMETHYL)-;
(TRIS-(HYDROXYMETHYL)AMINOMETHANE)
OSHA PEL:N/K
ACGIH TLV:N/K
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:EYE:MAY CAUSE IRRITATION.
SKIN:MAY CAUSE IRRITATION. INGEST:MAY CAUSE SEVERE GASTROINTESTINAL
TRACT IRRITATION WITH NAUSEA, VOMITING & POSSIBLE BURNS. INHAL:MAY
CAUSE IRRITATION OF RESPIRATORY T RACT WITH BURNING PAIN IN NOSE &
THROAT, COUGHING, WHEEZING, SHORTNESS OF BREATH AND PULMONARY
EDEMA. (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ:CHRONIC:PROLONGED OR REPEATED SKIN
CONTACT MAY CAUSE DERMATITIS. SENSITIZER.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
* First Aid Measures *
LIFTING UPPER & LOWER LIDS. GET MED AID IMMED. SKIN:GET MED AID.
CONTAMD CLTHG & SHOES. INGEST:IF VICTIM IS CONSCIOUS & ALERT, GIVE
2-4 CUPFULS OF MILK/WATER. NEVER GIVE ANYTHING BY MOUTH TO UNCON
PERSON. GET MED AID IMMED. INHAL:GET MED AID IMMED. REMOVE FROM
EXPOS (SUPDAT)
* Fire Fighting Measures *
Extinguishing Media:USE WATER, DRY CHEMICAL, CHEMICAL FOAM, OR
ALCOHOL-RESISTANT FOAM.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE SPECIFIED BY MANUFACTURER.
* Accidental Release Measures *
Spill Release Procedures:CLEAN UP SPILLS IMMED, OBSERVING PRECAUTIONS
IN PROTECTIVE EQUIPMENT SECTION. SWEEP UP, THEN PLACE INTO A
SUITABLE CLEAN, DRY CONTAINER FOR DISPOSAL.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:STORE IN A COOL, DRY PLACE. KEEP AWAY
FROM ACIDS. KEEP CONTAINERS TIGHTLY CLOSED.
Other Precautions:USE WITH ADEQUATE VENTILATION. AVOID CONTACT WITH
EYES, SKIN, AND CLOTHING. AVOID INGESTION AND INHALATION. DISCARD
CONTAMINATED SHOES.
* Physical/Chemical Properties *
Evaporation Rate & Reference:NOT AVAILABLE
Solubility in Water:MODERATELY SOLUBLE
Appearance and Odor:FINE, WHITE CRYSTALLINE POWDER. DELIQUESCENT. ABINE
ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
BASES, OXIDIZING AGENTS, ACIDS, ALDEHYDES, COPPER, BRASS, AND ALUMINUM.
Stability Condition to Avoid:INCOMPATIBLE MATERIALS.
Hazardous Decomposition Products:NITROGEN OXIDES, CARBON MONOXIDE,
CARBON DIOXIDE, NITROGEN.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF IN A MANNER CONSISTENT WITH FEDERAL,
STATE, AND LOCAL REGULATIONS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NONE NEEDED UNDER NORMAL USE CONDITIONS.
Ventilation:LOCAL EXHAUST RECOMMENDED.
Other Protective Equipment:RUBBER BOOTS & APRON, PLASTIC COVERALLS,
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
Supplemental Safety and Health
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:3-BROMO-1-CHLORO-5,5-DIMETHYL-HYDANTOIN; 2,4-IMIDAZOLIDINE
DIONE, 1-BR-3-CL-5,5-DIMETHYLHYDANTOIN
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SKIN: MAY IRRITATE/BURN. EYES: WILL
BURN/SEVERELY IRRITATE. INGESTION: MAY IRRITATE/BURN MOUTH, THROAT
& STOMACH & CAUSE SERIOUS DAMAGE. INHALATION: MAY CAUSE SEVERE
RESPIRATORY PROBLEMS.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, BURNS, DIZZINESS, NAUSEA,
DIFFICULTY BREATHING.
* First Aid Measures *
FORCE OPEN. INGESTION: IF UNCONSCIOUS/HAVING CONVULSIONS, GIVE
MILK/WA TER IMMEDIATELY. INHALATION: REMOVE TO FRESH AIR. OBTAIN
MEDICAL ATTENTION IN ALL CASES.
* Fire Fighting Measures *
Flash Point Method:PMCC
Flash Point:NONE
Extinguishing Media:WATER SPRAY, DRY CHEMICAL, CO2/FOAM.
Fire Fighting Procedures:DON'T USE AMMONIUM PHOSPHATE. WEAR SCBA & FULL
PROTECTIVE GEAR.
Unusual Fire/Explosion Hazard:FORMS EXPLOSIVE MIXTURES W/COMBUSTIBLE
ORGANIC/OXIDIZABLE MATERIALS. MAY RELEASE HYDROGEN BROMIDE/BROMINE
GAS/NITROGEN OXIDES/HYDROGEN CHLORIDE WHEN WET/HEATED.
* Accidental Release Measures *
Spill Release Procedures:WEAR PROTECTIVE CLOTHING. SHOVEL INTO PLASTIC
BAGS.
*Handling and Storage *
Handling and Storage Precautions:KEEP CONTAINER COVERED & SEALED WHEN
NOT IN USE. STORE IN COOL, DRY AREA. DON'T ADD WATER/ANY OTHER
MATERIAL TO DRUM OF PRODUCT/CONTAMINATE IT.
* Physical/Chemical Properties *
Vapor Pres:<0.1
Solubility in Water:MODERATE
Appearance and Odor:WHITE TO OFF-WHITE TABLETS W/FAINT CHLORINE ODOR
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
HYDROCARBONS, REDUCING AGENTS, OXIDIZING MATERIALS.
Stability Condition to Avoid:HEAT.
Hazardous Decomposition Products:HYDROGEN BROMIDE/BROMINE GAS, NITROGEN
OXIDES, HYDROGEN CHLORIDE.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF IN A WASTE FACILITY, IAW/FEDERAL,
STATE & LOCAL REGULATIONS. IF NOT CONTAMINATED, YOU MAY BE DISPOSE
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN .
Ventilation:NONE SPECIFIED BY MANUFACTURER.
Other Protective Equipment:LONG SLEEVE SHIRT AND LONG TROUSERS IS
RECOMMENDED TO PREVENT SKIN CONTACT.
Work Hygienic Practices:FLUSH PROD FROM HANDS W/SOAPY WATER. CARE
SHOULD BE TAKEN TO AVOID CONTACT W/EYES UNTIL HANDS HAVE BEEN (SEE
SUPP DATA)
Supplemental Safety and Health
PH: 6-9 IN AQUEOUS SLURRY. HNDLG/STOR PREC: WITH STRONG OXIDIZING
AGENTS SUCH AS NITRIC ACID. OTHER PREC: IN THE WORK SPACE MUST BE
OBSERVED. HYGIENE PRACT: COMPLETELY CLEANED. PROD HAS A TENDENCY TO
CLING TO SKIN DUE TO STATIC CHARGE. CARE MUST BE EXERCISED TO
REMOVE ALL PRODUCT FROM SKIN.
* Product Identification *
Product ID:ION EXCHANGE RESIN, IONAC CFS
Preparer's Name:REGULATORY AFFAIRS
* Composition/Information on Ingredients *
Ingred Name:BENZENE DIETHENYL-, POLYMER WITH ETHENYLBENZENE AND
ETHENYLETHYLBENZENE, SULFONATED, SODIUM SALTS.
* Hazards Identification *
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE/CHRONIC: CAN PRODUCE MECHANICAL
IRRITATION TO THE EYE. MAY CAUSE SKIN IRRITATION OF HYPERSENSITIVE
PERSONNEL.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:RED, IRRITATED EYES, ITCHING AND FEELING THAT A
PARTICLE EXISTS BETWEEN THE EYELID AND EYE.
* First Aid Measures *
First Aid:EYES/SKIN: FLUSH WITH COPIOUS QUANTITIES OF WATER FOR AT
CROSS. INGEST: CALL MD IMMEDIATELY . INHAL: REMOVE TO FRESH AIR.
SUPPORT B REATHING (GIVE O*2/ARTIFICIAL RESPIRATION) .
* Fire Fighting Measures *
Extinguishing Media:DRY CHEMICAL, CARBON DIOXIDE OR WATER FOG.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT . GUARD AGAINST CONTACT OF PRODUCT WITH EYE
DURING SALVAGE OPERATION.
Unusual Fire/Explosion Hazard:NONE SPECIFIED BY MANUFACTURER.
* Accidental Release Measures *
Spill Release Procedures:SWEEP AREA OF PRODUCT, COLLECTING IN A
CONTAINER FOR DISPOSAL. AREAS OF SPILL CAN BECOME EXTREMELY
SLIPPERY. ALL NORMAL SAFETY PRECAUTIONS SHOULD BE OBSERVED.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
BECAUSE PRODS CONTAINS WATER WHICH WILL FREEZE & DAM PROD/DRY-OUT
ALSO DAMAGING PROD. AVOID CONT (SEE SUPP DATA)
Other Precautions:AVOID PACKING PROD IN AN UNPROTECTED GLASS COLUMN.
EXPANSION OF THE PROD CAN CAUSE GLASS COLUMN TO SHATTER. WHEN
TRANSFERRING PROD TO OTHER CNTNRS VIA HYDRAULIC (WATER) SLURRY ALL
SAFETY PRACTICES EST ABLISHED FOR USE OF WATER (SUPP DATA)
* Physical/Chemical Properties *
Vapor Pres:SEE ING 2
Vapor Density:SEE ING 2
Spec Gravity:1.3
pH:SUPDAT
Evaporation Rate & Reference:1 (H*2O=1)
Solubility in Water:INSOLUBLE
Appearance and Odor:SOLID SPHERICAL BEADS; ODORLESS
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS SUCH AS NITRIC ACID.
EXPLOSIVE REACTIONS CAN OCCUR IN THE PRESENCE OF STRONG OXIDIZING
AGENTS.
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE,
STYRENE, DIVINYLBENZENE.
* Disposal Considerations *
Waste Disposal Methods:NEW, UNUSED PRODUCT CAN BE DISPOSED OF AS
ORDINARY TRASH I/A/W ALL FEDERAL, STATE, AND LOCAL REGULATIONS.
USED PRODUCT MUST BE TESTED FOR CONTAMINATION BY HAZARDOUS MATERIAL
AND DISPOSED OF ACCORDINGL Y.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:WEAR SELF-CONTAINED BREATHING APPARATUS FOR
CONCENTRATIONS ABOVE TLV LIMITS.
Ventilation:USE W/ADEQUATE VENTILATION, SUFFICIENT TO PREVENT
INHALATION OF SOLVENT VAPORS.
Supplemental Safety and Health
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:HEXANE, N-HEXANE
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:TITANIUM DIOXIDE, TIO2
Ingred Name:TOLUENE
Ingred Name:V M & P NAPHTHA, LIGROINE, MINERAL SPIRITS
Ingred Name:XYLENE, DIMETHYLBENZENE, XYLOL
Fraction by Wt: 2-6%
Ingred Name:PROPANE
ACGIH TLV:SIMPLE ASPHYXIANT
Ingred Name:ISOBUTANE, 2-METHYLPROPANE
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: RESPIRATORY SYSTEM
IRRITATION. EYES: IRRITATION. INGESTION: ACCIDENTAL INGESTION IS
UNLIKELY FROM AN AEROSOL CAN.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:INHALATION:
IRRITATION/HEADACHE/DIZZINESS/NAUSEA/UNCONSCIOUS/ASPHYXIA. SKIN:
DEFATTING LEADING TO IRRITATION/DERMATITIS. HEXANE MAY CAUSE
PERIPHERAL POLYNEUROPATHY. VM&P CAUSES SKIN IRRITATION/CNS DEP
RESSION. TOLUENE CAUSES CARDIAC EFFECTS.
* First Aid Measures *
First Aid:INHALATION: REMOVE TO FRESH AIR. IF BREATHING STOPS, BEGIN
ARTIFICIAL RESPIRATION. EYES: IMMEDIATELY FLUSH W/PLENTY OF WATER
MEDICAL ATTENTION IN ALL CASES.
* Fire Fighting Measures *
Flash Point Method:TOC
Lower Limits:0.7%
Upper Limits:9.5%
Extinguishing Media:CO2, DRY CHEMICAL, OR FOAM
Fire Fighting Procedures:WATER SPRAY MAY BE INEFFECTIVE. WATER MAY BE
USED TO COOL CONTAINERS TO PREVENT BURSTING. IF WATER IS USED, FOG
Unusual Fire/Explosion Hazard:EXPOSURE TO HEAT OR PROLONG EXPOSURE TO
SUN MAY CAUSE BURSTING.
* Accidental Release Measures *
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION. AVOID
BREATHING VAPORS. VENTILATE AREA. WIPE UP W/INERT MATERIALS & PLACE
IN APPROPRIATE CONTAINER.
*Handling and Storage *
DIRECTED. AVOID CONTINUOUS BREATHING OF VAPORS & SPRAY MIST.
Other Precautions:INTENTIONAL MISUSE BY DELIBERATELY CONCENTRATING
VAPORS & INHALING CONTENTS CAN BE HARMFUL OR FATAL.
* Physical/Chemical Properties *
Vapor Density:>1
Evaporation Rate & Reference:FASTER THAN ETHER
Solubility in Water:INSOLUBLE
Appearance and Odor:PAINT SOLVENT ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
FLAME, SUN, OR OTHER SOURCES OF IGNITION
Hazardous Decomposition Products:HAZARDOUS FUMES SUCH AS CO, CO2,
PHOSGENE, HYDROGEN CHLORIDE, & CHLORINATED ACIDS, ALDEHYDES, &
KETONES
* Disposal Considerations *
Waste Disposal Methods:DON'T INCINERATE AEROSOL, DISPOSE OF IN
ACCORDANCE W/LOCAL, STATE, & FEDERAL REGULATIONS. DON'T PLACE
AEROSOL CANS IN HOME COMPACTOR. DON'T PUNCTURE.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:SELF-CNTND BRTHG APP,POS PRESSURE HOSE
MASK/AIR-LINE MASK W/FACEPIEC
Ventilation:LOCAL EXHAUST TO MINIMIZE VAPOR CONCENTRATION
Other Protective Equipment:SOLVENT RESISTANT BOOTS & APRON(NEOPRENE)
Supplemental Safety and Health
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:METHYLENE CHLORIDE(SARA III)
Ingred Name:ISOPROPYL ALCOHOL (SARA III)
* Hazards Identification *
Effects of Overexposure:EYES:SEV IRRIT;MAY DAMAGE
PERMANENTLY;INH:DIZZ,HEAD,INTOXIC;SKIN:IRRIT,DEFAT,MAY ABSORB TOXIC
AMOUNT
* First Aid Measures *
First Aid:SEV CHEST PAIN MAY INDICATE DANGER LEV OF CARBOXY
HEMOGLOBIN.GET MED ATTN;INH:REMOVE TO FRESH AIR,GIVE OXY/CPR IF
NEEDED;EYES:FLUSH W/LG AMT OF WATER;SKIN:WASH W/SOAP & WATER;ING:DO
NOT INDUCE VOMIT,D ILUTE W/H*2O OR MILK.GET MED ATTN FOR ANY
PROBLEM.
* Fire Fighting Measures *
Flash Point:NONE TO BOIL-SCC
Lower Limits:UNK
Upper Limits:UNK
Extinguishing Media:CO*2,FOAM,DRY CHEM
Fire Fighting Procedures:USE SELF-CNTND BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:THERMAL DECOMP MAY EMIT TOXIC OXIDES OC C
& CL. MOD HEAT MAY CAUSE DRUMS TO BUILD INT PRESS & RUPTUR
* Accidental Release Measures *
Spill Release Procedures:VENTILATE AREA.WEAR PROTECTVE EQUIP.ELEMINATE
IGN SOURCE.WEAR PROTECTVE EQUIP.ELEMINATE IGN SOURCE.STOP LEAK W/O
RISK.DIKE/CONTAIM SPILLAGE.WIPE UP OR ABSORB SPILLAGE ONTO
ABSORBENT MATL.RECOVER IN DR UMS/CONTNRS WHICH ARE SUITABLE FOR
SHIPMENT TO DIS
*Handling and Storage *
Handling and Storage Precautions:STORE AWAY FROM HEAT/IGN SOURCES.USE
CARE IN OPENING DRUMS TO AVOID SPURTING OF CONTENTS.PROTECT CONTNRS
AGAINST PHYSICAL DAMAGE.
Other Precautions:VAP HEAVR THAN AIR WILL TRAVL ALONG GRD COLLECTING IN
LOW AREAS SUCH AS SUMPS.PERSONS ENTERING THIS AREA SHOULD USE
PROTECT EQUIP & BE OBSERVD WHILE IN THE AREA; AVOID REPEATD CONT W
SKIN/EYES
* Physical/Chemical Properties *
HCC:T5
Vapor Density:>1.0
Evaporation Rate & Reference:>1.0(BU ACETATE)
Solubility in Water:MODERATE
Appearance and Odor:CLEAR COLORLESS LIQ,CHLORINATED HYDROCARBON ODOR
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS
Hazardous Decomposition Products:TOXIC OXIDES OF CARBON &
CHLORINE(CARBON MONOXIDE & PHOSGENE
* Disposal Considerations *
Waste Disposal Methods:MFGR RECOMMENDS ONE OR ALL OF THE FOLLOWING
METHODS:(1) INCINERATE IN APPRVD INCIN. W APPROPRIATE FUME
SCRUBBER;(2)LANDFILL IAW LOCAL,STATE,FED REGS;(3) TRANSFER/SHIP TO
RECLAIMING FACILITY FOR SOLVEN T RECOVERY.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NONE REQUIRED FOR NORMAL WORK SITUATIONS WHEE
ADEQUATE VENTILATION IS PROVIDED. USE NIOSH APPROVED
SELF-CONTAINED, POSITIVE PRESSURE RESPIRATORS FOR EMERGENCIES AND
IN SITUATIONS WHERE AIR MAY BE DISP LACED BY VAPORS.
Ventilation:LOCAL EXHAUST: AT FILLING ZONES & WHERE LEAKAGE IS
Other Protective Equipment:ANSI APPRVD EYE WASH & DELUGE SHOWER.
Work Hygienic Practices:GOOD PERSONAL HYGIENE TO BE FOLLOWED AT ALL
TIMES. CONTACT LENSES SHOULD NOT BE WORN.
Supplemental Safety and Health
EXPLO HAZ: FINELY DIVIDED METALS MAY CAUSE AN EXOTHERMIC RXN &/OR EXPLO
COMBINATIONS. VAPS CONC IN A CONFINED OR POORLY VENTD SPACE SUCH AS
AIR-VAP INTERFACE OF VAP DEGREASER CAN BE IGNITED W/FLAME OR HIGH
INTENSITY SOURCE OF HEAT. CNDTNS TO AVOID: NON-EXPLO CNDTNS MAY
YIELD TOXIC &/OR CORR DECOMP PRODS.
* Product Identification *
* Composition/Information on Ingredients *
DISPOSAL.
Ingred Name:HNDLG/STOR PRECS:STORE IN OPEN, UNLABELED OR MISLABELED
BE EASILY CORRECTED.
Ingred Name:VENT: SHOULD BE DESIGNED IN ACCORDANCE WITH OSHA STANDARDS
Ingred Name:ETHANE, 1,1-DICHLORO-1-FLUORO-; (1,1
OSHA PEL:N/K
ACGIH TLV:N/K
Ozone Depleting Chemical:2
Ingred Name:STODDARD SOLVENT; (STODDARD SOLVENT/MINERAL SPIRITS)
Fraction by Wt: 1.5%
Ingred Name:TRIMETHYLATED SILICA
Fraction by Wt: 1.4%
OSHA PEL:N/K
ACGIH TLV:N/K
Fraction by Wt: 0.5%
Ingred Name:BENZENE, 1,2,4-TRIMETHYL-; (1,2,4-TRIMETHYL BENZENE) (SARA
Ingred Name:MATL TO AVOID: REACTION), SODIUM, POTASSIUM, CALCIUM,
MAGNESIUM, ZINC, MOLTEN ALUMINUM, BARIUM & LITHIUM (ING 7)
Ingred Name:ING 6: SHAVINGS. STRONG OXIDIZING AGENTS. ALSO, SOME
DESICCANTS MAY REACT.
Ingred Name:EFTS OF OVEREXP: FOR INHALATION. DISCOMFORT DUE TO
VOLATILITY WOULD BE EXPECTED. EYES: IRRITANT; LIQUID CONTACT (ING
9)
Ingred Name:ING 8: WILL IRRITATE EYES & MAY CAUSE CONJUNCTIVITIS.
Ingred Name:FIRST AID PROC: OR MD. EYES: FLUSH EYES W/LARGE AMOUNTS OF
ATTENTION IMMEDIATELY.
Ingred Name:SPILL PROC: CONTAM OF GROUND & SURFACE WATERS. RECOVER OR
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:CHLOROFLUOROCARBON (CFC) MATLS HAVE
PRDCED SENSIT OF THE MYOCARDIUM TO EPINEPHRINE IN LAB ANIMALS &
COULD HAVE A SIMILAR EFT IN HUMANS. ADRENOMIMETICS (IE,
EPINEPHRINE) MAY BE CONTRA-INDICATED EXCEPT FOR LIFE-SUSTAINING
USES IN HUMANS ACUTELY OR CHRONICALLY EXPOSED TO CFCS . INHAL:
HEADACHE, (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ: DIZZINESS, NAUSEA, LOSS OF CONC &
IRRIT. W/HIGH EXPOS LEVELS: CNS DEPRESS (INTOXICATION), CARD
ARRHYTHMIA, DECREASED BODY WT. PROD VAPS DISPLACE AIR & CAN CAUSE
ASPHYXIATION ESP IN CONFINED SPACES. SKIN: DEFATTING OF SKIN CAN
CAUSE IRRIT. NO ABSORPTION TOXICITY DATA IS AVAIL. INGEST: SIMILAR
SYMPS AS (ING 8)
Medical Cond Aggravated by Exposure:NO INFORMATION.
* First Aid Measures *
First Aid:INHAL: REMOVE PATIENT TO FRESH AIR. GIVE MOUTH TO MOUTH
RESUSCITATION IF BRTHG HAS STOPPED. GIVE OXYGEN AS NECESSARY IF
QUALIFIED OPERATOR IS AVAIL. DO NOT GIVE STIMULANTS OR ADRENALINE
(EPINEPHRINE). GET MED ATTN IMMED. SKIN: WASH PROMPTLY W/SOAP &
INGEST: DO NOT INDUCE VOMIT. DO NOT GIVE STIMULANTS. TAKE IMMED TO
* Fire Fighting Measures *
Flash Point Method:TCC
Flash Point:NONE
Lower Limits:7.6%
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL OR WATER SPRAY.
Fire Fighting Procedures:WEAR NIOSH APPROVED PRESSURE DEMAND SCBA AND
FULL PROTECTIVE EQUIPMENT . USE WATER SPRAY TO KEEP CONTAINERS
COOL.
DECOMP PRODS CAN INCL HYDROCHLORIC & HYDROFLUORIC ACIDS & CARBONYL
HALIDES SUCH AS PHOSGENE. CONTACT W/CERTAIN (SUPDAT)
* Accidental Release Measures *
Spill Release Procedures:IMMED EVACUATE AREA & PROVIDE MAXIMUM VENT.
UNPROTECTED PERS SHOULD MOVE UPWIND OF SPILL. ONLY PERS EQUIPPED
W/PROPER NIOSH APPRVD RESP & SKIN/EYE PROT SHOULD BE PERMITTED IN
AREA. DIKE AREA TO CONTAI N SPILL. TAKE PRECS AS NECESSARY TO PVNT
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:DO NOT USE IN POORLY VENTD OR CONFINED
SPACES. PROD VAPS ARE HVR/AIR & WILL COLLECT IN LOW AREAS. KEEP
Other Precautions:NO SMOKING IN AREA OF USE. DO NOT USE IN THE GENERAL
VICINITY OF ARC WELDING, OPEN FLAMES OR HOT SURFACES. HEAT AND/OR
UV RADIATION MAY CAUSE THE FORMATION OF CHLORIDES, FLUORIDES OR
PHOSGENE .
* Physical/Chemical Properties *
Vapor Density:4.1
Evaporation Rate & Reference:>1 (BUTYL ACETATE=1)
Solubility in Water:SLIGHT
Appearance and Odor:COLORLESS LIQUID WITH ETHEREAL AND FAINT SWEETISH
ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS & ALKALIS, REACTIVE METALS, EG POWDERED OR FRESHLY ABRADED
ALUMINUM (MAY CAUSE STRONG EXOTHERMIC (ING 6)
Stability Condition to Avoid:AVOID SOURCES OF IGNIT SUCH AS SPKS, HOT
SPOTS, WELDING FLAMES & CIGARETTES. EXPLOS MAY RSLT IF IN FLAM
RANGE. (SUPDAT)
Hazardous Decomposition Products:HYDROCHLORIC AND HYDROFLUORIC ACIDS
AND CARBONYL HALIDES SUCH AS PHOSGENE.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF ACCORDING TO FEDERAL, STATE AND LOCAL
REGULATIONS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:WEAR NIOSH/MSHA APPROVED MASK.
Ventilation:MECHANICAL EXHAUST REQUIRED.
Other Protective Equipment:USE PROTECTIVE CLOTHING. SAFETY SHOWER AND
EYE BATH.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
* Product Identification *
* Composition/Information on Ingredients *
DIMETHYL ETHER)
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:MAY BE HARMFUL BY INHALATION,
INGESTION, OR SKIN ABSORPTION. MAY CAUSE EYE IRRITATION. MAY CAUSE
ALLERGIC SKIN REACTION. EXPOSURE CAN CAUSE NAUSEA, HEADACHE AND
VOMITING. TO THE BEST OF OUR KNOWLEDGE, THE CHEMICAL, PHYSICAL,
AND TOXICOLOGICAL PROPERTIES HAVE NOT BEEN THOROUGHLY INVESTIGATED.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:
* First Aid Measures *
First Aid:EYES: IMMEDIATELY FLUSH WITH COPIOUS AMOUNTS OF WATER FOR AT
AMOUNTS OF WATER. WASH CONTAMINATED CLOTHING BEFORE REUSE.
INHALATION: REMOV E TO FRESH AIR. IF NOT BREATHING GIVE ARTIFICIAL
RESPIRATION. IF BREATHING IS DIFFICULT, GIVE OXYGEN. INGESTION:
WASH OUT MOUTH WITH WATER PROVIDED PERSON IS CONSCIOUS. CALL A
PHYSICIAN.
* Fire Fighting Measures *
Extinguishing Media:WATER SPRAY, CARBON DIOXIDE, DRY CHEMICAL POWDER OR
APPROPRIATE FOAM.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:
* Accidental Release Measures *
Spill Release Procedures:WEAR NIOSH/MSHA APPROVED SCBA, RUBBER BOOTS
CLOSED CONTAINERS FOR DISPOSAL. VENTILATE AREA AND WASH SPILL SITE
AFTER MATERIAL PICKUP IS COMPLETE.
Neutralizing Agent:
*Handling and Storage *
Handling and Storage Precautions:KEEP CONTAINER CLOSED. AIR SENSITIVE.
FORMS EXPLOSIVE PEROXIDES ON PROLONGED STORAGE. STORE IN A COOL DRY
PLACE.
Other Precautions:AVOID CONTACT AND INHALATION.
* Physical/Chemical Properties *
Vapor Density:7.7
Appearance and Odor:COLORLESS LIQUID.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS, OXIDIZING AGENTS, OXYGEN.
Stability Condition to Avoid:
Hazardous Decomposition Products:TOXIC FUMES OF CARBON MONOXIDE, CARBON
DIOXIDE.
* Disposal Considerations *
Waste Disposal Methods:DISSOLVE OR MIX THE MATERIAL WITH A COMBUSTIBLE
SOLVENT AND BURN IN A CHEMICAL INCINERATOR EQUIPPED WITH AN
AFTERBURNER AND SCRUBBER. OBSERVE ALL FEDERAL, STATE AND LOCAL
ENVIRONMENTAL REGULATIONS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:IF PEL/TLV IS EXCEEDED USE NIOSH/MSHA APPROVED
ACID GAS RESPIRATOR.
Ventilation:NO SPECIAL REQUIREMENTS. IF PEL/TLV IS EXCEEDED, PROVIDE
ADEQUATE VENTILATION.
Other Protective Equipment:RUB APRON, RUB BOOTS & OTHER IMPERVIOUS
CLTHG AS NEC TO PREVENT SKIN CONT. EMER EYEWASH & DELUGE SHOWER
(SUP DAT)
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
EYE PROT: & FULL LENGTH FACESHIELD. OTHER PROT EQUIP: MEETING ANSI
DESIGN CRITERIA .
* Product Identification *
* Composition/Information on Ingredients *
OSHA PEL:C 5 PPM
ACGIH TLV:C 5 PPM
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: CORROSIVE TO EYES, SKIN AND
MUCOUS MEMBRANES WHICH CAN RESULT IN STRONG IRRITATION, BURNING AND
TISSUE DAMAGE. CHRONIC: PROLONGED OR REPEATED CONTACT CAN CAUSE
ULCERATION OF MUCOUS MEMBRANES AN D SKIN.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
* First Aid Measures *
First Aid:EYES/SKIN: FLOOD AREA W/WATER WHILE REMOVING ANY CONTAM
W/LGE AMTS OF WATER. CONT MD. INGEST: DO NOT INDUCE VOMIT. IF
CONSCIOUS, DILUTE STOMACH CONTENTS WITH LIMEWATER OR MILKOF
MAGNESIA. CONTACT MD IMMED. INHAL: REMOVE TO FRESH AIR. SUPPORT
BREATHING (GIVE OXYGEN/ARTF RESP) .
* Fire Fighting Measures *
Flash Point:NON-FLAMMABLE
Extinguishing Media:USE MEDIA SUITABLE FOR SURROUNDING FIRE .
Fire Fighting Procedures:COOL EXPOSED CONTAINERS WITH WATER. WEAR
NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:HEATING CAN CAUSE RELEASE OF HYDROGEN
CHLORIDE & OTHER TOXIC FUMES. HYDROCHLORIC ACID WILL ATTACK MOST
METALS W/THE EVOLUTION OF POTENTIALLY EXPLOSIVE HYDROGEN.
* Accidental Release Measures *
Spill Release Procedures:EVACUATE AREA. PROVIDE ADEQUATE VENT. CONTAIN
SPILL TO A SMALL AREA. PICK UP W/ABSORB MATL (E.G., SAWDUST, SAND,
CLAY, ETC.) & TRANSPORT TO A SUITABLE CONTR FOR DISP. CAREFULLY
FLUSH AREA W/WATER.
Neutralizing Agent:LIME OR SODA ASH MAY BE USED TO NEUTRALIZE THE FINAL
TRACES AFTER FLUSHING.
*Handling and Storage *
Handling and Storage Precautions:STORE AND MIX IN NON-METALLIC
CONTAINERS, PREFERABLY PLASTIC.
Other Precautions:NONE.
* Physical/Chemical Properties *
Vapor Density:>1 (AIR=1)
Spec Gravity:1.2
Evaporation Rate & Reference:<1 (ETHER=1)
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
HYDROCHLORIC ACID REACTS WITH METAL TO GENERATE HYDROGEN AND HEAT.
Stability Condition to Avoid:NONE.
Hazardous Decomposition Products:HYDROGEN CHLORIDE AND OTHER TOXIC
FUMES.
* Disposal Considerations *
Waste Disposal Methods:INCINERATE OR NEUTRALIZE ABSORBED MATERIAL.
CHECK LOCAL, STATE, AND FEDERAL REGULATIONS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:SCBA IF INVOLVED IN FIRE, OTHERWISE GAS MASK.
Ventilation:PROVIDE MECHAN(GEN/LOCAL EXHAUST)VENT TO MAINTN <TLV
Other Protective Equipment:EYE WASH STATION. APRONS. SPECIAL IMPERVIOUS
CLOTHING.
Supplemental Safety and Health
SOURCE OF DATA-EXAM OF STOCK IN WHSE. SAFETY & HEALTH DATA DEVELOPED BY
DGSC-STF.
* Product Identification *
* Composition/Information on Ingredients *
* Hazards Identification *
Effects of Overexposure:HAZ DEGREE DEPENDS ON TYPE/QUANT OF RADIATION.
LATENT EFFECTS:SOMATIC/GENETIC DAMAGE.
* First Aid Measures *
First Aid:USE FIRST AID. CALL MEDICAL EMERGENCY CARE. REMOVE/ISOLATE
COMTAMINATED CLOTHING.SHOWER VICTIM(S) W. SOAP & H*2O. DETAIN
PERSONNEL/EQUIPMENT EXPOSED. ADVISE MEDICAL PERSONNEL THAT
VICTIM(S) MAY BE CON TAMINATED.
* Fire Fighting Measures *
Extinguishing Media:EXTINQUISH W. AGENT SUITABLE FOR SURROUNDING FIRE.
Fire Fighting Procedures:WEAR CHEMICAL PROTECTIVE SUIT WITH SELF CONTD
BRTHG APP.
Unusual Fire/Explosion Hazard:SOME OF MATL MAY BURN. CONT MAY EXPLODE
IN HEAT OF FIRE.
* Accidental Release Measures *
*Handling and Storage *
Handling and Storage Precautions:SHIELD ACCORDING TO EMITTED RADIATION.
PROTECT FROM FILM/FILM PLATES. KEEP CONTAINERS CLOSED. STORE IN
AREA FOR RADIOACTIVE MATERIALS.
* Physical/Chemical Properties *
HCC:A3
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
ISOLATE,SEGREGATE FROM MOST OTHER TYPE MATERIAL
Hazardous Decomposition Products:DEPENDS ON CHEMICAL COMPOSITION;
FISSION PRODUCTS
* Disposal Considerations *
Waste Disposal Methods:CONTROLLED DISPOSAL REQUIRED-IN ACCORDANCE WITH
DOD REGULATIONS AND FEDERAL,STATE & LOCAL REGULATIONS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:RESPIRATORS ARE NOT NEEDED FOR NORMAL USE.A
NIOSH/MSHA APPROVED AIR PURIFYING RESPIRATOR WITH AN ORGANIC VAPOR
CARTRIDGE/CANISTER WITH DUST/MIST FILTER OR A POSITIVE PRESSURE AIR
SUPPLIED RESPIRATOR W HERE AIRBORNE CONCENTRATIONS > TLV.
Ventilation:GOOD GENERAL VENTILATION SHOULD BE SUFFICIENT.
Other Protective Equipment:EYE WASH STATION & SAFETY SHOWER.IMPERVIOUS
CLOTHING SUCH AS BOOTS,APRON,WHOLE BODY SUIT MADE FROM NEOPRENE.
Work Hygienic Practices:USE OF A NON-ALKALINE TYPE OF SKIN CLEANSER AND
REACTION.
Supplemental Safety and Health
ITEM IS 4 PARTS PRODUCT WHICH CONSISTS OF EKTAPRINT 2 DEVELOPER,PARTS
* Product Identification *
Kit Part:Y
* Composition/Information on Ingredients *
Ingred Name:BENZYL ALCOHOL
Other REC Limits:NONE SPECIFIED
Ingred Name:TRIETHANOLAMINE
Other REC Limits:NONE SPECIFIED
Ingred Name:STILBENE BRIGHTENER - NON-HAZARDOUS PER MSDS. PREVIOUSLY
Fraction by Wt: 1 - 5%
Other REC Limits:NONE SPECIFIED
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE-INHALATION:VAPOR HAS A
DISAGREEABLE ODOR.MAY CAUSE IRRITATION OF THE UPPER RESPIRATORY
TRACT IN SOME INDIVIDUAL.EYES/SKIN:CAUSES
IRRITATION.INGESTION:HARMFUL.CHRONIC-NOT GIVEN.
Explanation of Carcinogenicity:THIS PRODUCT CONTAINS NO INGREDIENT
LISTED AS CARCINOGEN BY IARC,NTP, OR OSHA.
Effects of Overexposure:SEE HEALTH HAZARDS SECTION.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
* First Aid Measures *
First Aid:GET MEDICAL ATTENTION.EYE:IMMEDIATELY FLUSH WITH WATER FOR AT
WATER.INHALATION:REMOVE TO FRESH AIR.INGESTION:CALL A PHYSICIAN.
* Fire Fighting Measures *
Flash Point:NONE
Extinguishing Media:WATER SPRAY; CARBON DIOXIDE; DRY CHEMICAL
Fire Fighting Procedures:USE SELF-CONTAINED BREATHING APPARATUS AND
PROTECTIVE CLOTHING TO PREVENT CONTACT WITH SKIN AND EYES.
Unusual Fire/Explosion Hazard:FIRE OR EXCESSIVE HEAT MAY CAUSE
PRODUCTION OF HAZARDOUS DECOMPOSITION PRODUCTS.
* Accidental Release Measures *
Spill Release Procedures:FLUSH SMALL SPILLS TO THE SEWER WITH LARGE
AMOUNT OF WATER.ABSORB LARGE SPILLS WITH INERT MATERIAL AND PLACE
IN A CONTAINER FOR CHEMICAL WASTE.PREVENT RUNOFF FROM ENTERING
DRAINS,SEWERS AND STREAMS.FL USH RESIDUAL SPILL AND AREA WITH
WATER.
Neutralizing Agent:WEAK ACID
*Handling and Storage *
Handling and Storage Precautions:STORAGE-KEEP FROM CONTACT WITH
OXIDIZING MATERIALS.
Other Precautions:AVOID BREATHING VAPORS OR MIST. AVOID CONTACT WITH
EYES,SKIN,OR CLOTHING. WASH THOROUGHLY AFTER HANDLING.USE
VENTILATION THAT IS ADEQUATE TO KEEP EMPLOYEE EXPOSURE TO AIRBORNE
CONCENTRATIONS BELOW REC OMMENDED EXPOSURE LIMITS.
* Physical/Chemical Properties *
HCC:B3
Vapor Density:3.2
Solubility in Water:COMPLETE
Appearance and Odor:AMBER LIQUID, AMINE ODOR
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:HIGH TEMPERATURES AND FLAMES
Hazardous Decomposition Products:CARBON DIOXIDE AND PROBABLY CARBON
MONOXIDE. OXIDES OF NITROGEN MAY BE PRESENT. AMMONIA
* Disposal Considerations *
Waste Disposal Methods:CONTRACT WITH LICENSED CHEMICAL WASTE DISPOSAL
AGENCY. FEDERAL, STATE, AND LOCAL REGULATIONS TAKE PRECEDENCE.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NIOSH/MSHA APPROVED SCBA IS REQUIRED IF A LARGE
RELEASE OCCURS.
Ventilation:NORMAL VENT FOR STD MFG PROCEDURES IS GENERALLY ADEQUATE.
LOCAL EXHAUST SHOULD BE USED WHEN LARGE AMOUNTS ARE(ING 4)
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
DECOMP PRODS: FORMING HYDROFLUORIC ACID AND POSSIBLY CARBONYL FLUORIDE.
CONSDIERED A POTENTIAL ROUTE OF EXPOSURE. NOTE TO MD: BECAUSE O F
POSS DISTURBANCES OF CARDIAC RHYTHM, CATECHOLAMINE DRUGS, SUCH AS
EPINEPHRINE, SHOULD ONLY (ING 2)
* Product Identification *
CAGE:0ERJ7
CAGE:0ERJ7
* Composition/Information on Ingredients *
REQUIRE HIGHER PRESSURE FOR COMBUSTIBILITY.
Ingred Name:MATLS TO AVOID: IN PRESENCE OF CERTAIN CONC OF CHLORINE.
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:SUPP DATA: BE USED WITH SPECIAL CAUTION IN SITUATIONS OF
EMERGENCY LIFE SUPPORT.
Ingred Name:SPILL PROC: APPROVED SCBA IF LARGE SPILL OR LEAK OCCURS.
Ingred Name:VENT: RELEASED. MECHNICAL VENTILATION SHOULD BE USED IN LOW
OR ENCLOSED PLACES.
Ingred Name:OTHER PREC: NOT BE MIXED WITH AIR FOR LEAK TESTING OR USED
WITH AIR FOR ANY OTHER PURPOSE ABOVE ATMOSPHERIC (ING 6)
Ingred Name:ING 5: PRESSURE. CONTACT WITH CHLORINE OR OTHER STRONG
OXIDIZING AGENTS SHOULD ALSO BE AVOIDED.
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHAL OF HIGH CONCS OF VAP IS HARMFUL
& MAY CAUSE HEART IRREGULARITIES, UNCON OR DEATH. INTENTIONAL
MISUSE OR DELIBERATE INHAL MAY CAUSE DEATH WITHOUT WARNING. VAP
REDUCES OXYGEN AVAIL FOR BRTHG AND I S HVR/AIR. LIQ CNTCT CAN CAUSE
FROSTBITE. HUMAN HLTH EFTS: OVEREXP BY INHAL TO VERY HIGH CONCS
(EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ: MAY CAUSE TEMPORARY ALTERATION OT THE
HEAT'S ELECTRICAL ACTIVITY WITH IRREGULAR PULSE, PALPITATIONS, OR
INADEQUATE CIRCULATION. SKIN CONTACT WITH LIQUID MAY CAUSE
FROSTIBITE.
Medical Cond Aggravated by Exposure:INDIVIDUALS WITH PREEXISTING
DISEASES OF THE CNS OR CARDIOVASCULAR SYSTEM MAY HAVE INCREASED
SUSCEPTIBILITY TO THE TOXICITY OF EXCESSIVE EXPOSURE.
* First Aid Measures *
First Aid:INHAL: IF HIGH CONCS ARE INHALEED, IMMED REMOVE TO FRESH AIR.
KEEP PERSOM CALM. IF NOT BRTHG, GIVE ARTF RESP. IF BRTHG IS DFCLT,
GIVE OXYGEN. CALL MD. SKIN: IMMED FLUSH SKIN WITH PLENTY OF WATER
FROSTBITE IF NECESSARY BY GENTLY WARMING AFFECTED AREA. WASH CONTAM
CLTHG BEFORE REUSE. EYE: IMMED FLUSH EYES W/PLENTY OF WATER (SUPP
DATA)
* Fire Fighting Measures *
Flash Point Method:TOC
Flash Point:WILL NOT BURN
Extinguishing Media:AS APPROPRIATE FOR COMBUSTIBLE IN AREA.
Fire Fighting Procedures:COOL CYLINDERS WITH WATER SPRAY. USE
NIOSH/MSHA APPROVED PRESSURE DEMAND SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:CYLINDERS MAY RUPTURE UNDER FIRE
CONDITIONS. DECOMPOSITION MAY OCCUR. TESTS OF PROD SHOW COMBUST @
* Accidental Release Measures *
Spill Release Procedures:NOTE:REVIEW FIRE AND EXPLOSION HAZS & SFTY
PREC BEFORE PROCEEDING W/CLEAN UP. USE APPROP PERSONAL PROT EQUIP
DURING CLEAN UP. VENT AREA, ESPECIALLY LOW OR ENCLOSED PLACES WHERE
HVY VAPS MIGHT COLLECT. REMOVE OPEN FLAMES. USE NIOSH/MSHA (ING 3)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Other Precautions:DO NOT USE IN MEDICAL APPLICATIONS INVOLVING
PERMANENT IMPLANTATION IN THE HUMAN BODY. AVOID CONTACT WITH EYES &
SKIN. AVOID BRTHG VAPS. USE W/SUFFICIENT VENT TO KEEP EMPLOYEE
* Physical/Chemical Properties *
HCC:G3
Appearance and Odor:CLEAR COLORLESS LIQUEFIED GAS, SLIGHT ETHEREAL
ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
INCOMPATIBLE WITH ALKALI OR ALKALINE EARTH METALS-POWDERED AL, ZN, BE,
ETC. EXPERIMENTAL INFO REPORTS COMBUST (ING 8)
Stability Condition to Avoid:AVOID OPEN FLAMES AND HIGH TEMPERATURES.
Hazardous Decomposition Products:DECOMP PRODS ARE HAZ. CAN BE DECOMP BY
HIGH TEMPS (OPEN FLAMES, GLOWING METAL SURFS, ETC.) (SUPP DATA)
* Disposal Considerations *
DISTILLATION OR REMOVED TO A PERMITTED WASTE DISPOSAL FACILITY.
COMPLY WITH FEDERAL, STATE, AND OR LOCAL REGULATIONS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:SUPPLIED AIR W/FULL FACEPIECE,HELMET OR HOOD
Ventilation:LOCAL EXHAUST
Other Protective Equipment:FULL CLOTHING TO PREVENT SKIN CONTACT
Supplemental Safety and Health
OVEREXPOS:CAN CAUSE FORMATION OF CYSTS,CAUSES STILLBIRTHS.IRRITATES
EYES,NOSE THROAT.
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:POLYCHLORINATED BIPHENYLS (PCBS) (SARA III)
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
* Hazards Identification *
Effects of Overexposure:ABSORBED THRU SKIN,LUNGS,INTESTINE.CAUSES
CANCER,LIVER,KIDNEY,STOMACH,EYE,HEARING DISORDER(SUP DATA)
* First Aid Measures *
First Aid:EYES:FLUSH W/WATER IMMEDIATELY.SKIN:WASH W/SOAP
IMMEDIATELY.INHAL:REMOVE TO FRESH AIR,GIVE ART.RESPIR. AS
NEEDED.INGEST:GET MEDICAL ATTN.GIVE LARGE QTY OF SALT WATER,INDUCE
VOMITING,BUT DO NOT MAKE UN CONSCIOUS PERSON VOMIT.
* Accidental Release Measures *
Spill Release Procedures:USE ABSORBENT & DIKES TO PREVENT
RUNOFF.ISOLATE & NOTIFY PROPER AUTHORITIES.
*Handling and Storage *
Handling and Storage Precautions:STORAGE MUST FOLLOW RCRA REQUIREMENTS.
* Physical/Chemical Properties *
HCC:Z3
Appearance and Odor:LIGHT STRAW-COLORED LIQUID,AROMATIC ODOR
* Stability and Reactivity Data *
STRONG OXIDIZERS
* Disposal Considerations *
Waste Disposal Methods:CONTROLLED DISPOSAL REQUIRED-GENERALLY HIGH
TEMPERATURE INCINERATION.ONLY APPROVED DISPOSAL OPERATOR PERMITTED.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:IN OUTDOOR/OPEN AREAS, WHERE SUFFICIENT VENT HAS
BEEN DETERMINED TO EXIST, A RESP IS GENERALLY NOT REQD. IN
RESTRICTED VENT AREAS, A NIOSH/MSHA APPRVD ORG VAP RESP IS RECOM.
DURING SPRAY APPLICATN, A NIOSH/MSHA APPRVD RESP (SUPP DATA)
Ventilation:IN CONFINED SPACES MECH VENT IS REQD TO KEEP AIR CONTAM
CONC BELOW CURRENT APPLIC OSHA PERMISSIBLE EXPOS UNITS.
Other Protective Equipment:PREVENT PROLONGED SKIN CONTACT WITH
CONTAMINATED CLOTHING.
Work Hygienic Practices:WASH HANDS BEFORE EATING, SMOKING OR USING
WASHROOM FACILITIES.
Supplemental Safety and Health
FIRST AID PROC: CONSULT PHYSICIAN OR POISON CONTROL CENTER IMMEDIATELY.
RESP PROT: PROVIDING BOTH ORGANIC VAPOR AND SPRAY MIST PROTECTION
IS RECOMMENDED.
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:TITANIUM OXIDE; (TITANIUM DIOXIDE)
Fraction by Wt: >1%
Ingred Name:BUTYL BENZYL PHTHALATE
Fraction by Wt: 3%
Fraction by Wt: 5%
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: IRRIT OF EYES & SKIN MAY OCCUR
W/OVEREXP. CONTINUED BRTHG OF VAPS MAY IRRITATE RESP TRACT CAUSING
HDCH, NAUS & DIZZ. CHRONIC: RPTS HAVE ASSOC RPTD & PRLNGD OVEREXP
TO SOLV W/PERM BRAIN & NERV S YS DAM. TARGET ORGAN EFTS: MAY
AFFECT: CARDIAC SYS; EYES; LIVER; KIDNEY; DERMAL SYSTEM; PULM SYS;
(EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ: NERV SYS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
* First Aid Measures *
First Aid:INHAL: REMOVE TO FRESH AIR. RESTORE RESP IF NEC. TREAT
SYMPTOMATICALLY. EYE: FLUSH IMMED W/COPIOUS QTY OF WATER FOR @ LST
REMOVE CONTAM D CLTHG. CONSULT PHYS IF IRRIT PERSISTS. INGEST:
DRINK 1-2 GLASSES OF WATER TO DILUTE. DO NOT INDUCE VOMIT. IF SPONT
VOMIT OCCURS KEEP HEAD @/BELOW KNEE LEVEL TO PVNT ASPIR INTO LUNGS.
(SUPP DATA)
* Fire Fighting Measures *
Flash Point Method:TOC
Lower Limits:SEE INGRED
Extinguishing Media:FOAM, CARBON DIOXIDE, DRY CHEMICAL, WATER MIST.
Fire Fighting Procedures:NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP.
SMOTHER FLAMES W/ONE OF THE ABOVE EXTINGUISHING MEDIA. WATER MAY BE
USED TO COOL DOWN UNOPENED CONTRS IN VICIN.
Unusual Fire/Explosion Hazard:CONTAINS FLAMMABLE SOLVENT. DO NOT USE IN
AREAS WHERE SPARKS OR OPEN FLAMES ARE PRESENT.
* Accidental Release Measures *
Spill Release Procedures:ELIM ALL IGNITION SOURCES. WEAR APPROPRIATE
PERSONAL PROTECTION EQUIPMENT AND NIOSH/MSHA APPROVED RESPIRATOR.
PREVENT MATERIAL FROM CONTACTING ANY WATER SOURCES OR SEWERS
LEADING TO SURFACE WATERS.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:STORE IN AREAS DESIGNED TO COMPLY WITH
Other Precautions:GROUND CONTAINERS WHEN POURING LIQUIDS & POWDERS TO
AVOID STATIC CHARGE BUILD UP. DO NOT HANDLE UNTIL MFRS SFTY PREC
HAVE BEEN READ & UNDERSTOOD. PROVIDE ADEQ VENT/RESP PROT TO REMOVE
DECOMP PROD DURI NG WELD/FLAME CUTTING COATED SURFACES.
* Physical/Chemical Properties *
HCC:F3
Vapor Pres:SEE INGRED
Vapor Density:HVR/AIR
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
OXIDIZING AGENTS.
Stability Condition to Avoid:EXTREME HEAT, SPARKS OR OPEN FLAMES.
Hazardous Decomposition Products:MAY PRODUCE HAZARDOUS FUMES WHEN
HEATED.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH FEDERAL, STATE AND
LOCAL REGULATIONS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Other Protective Equipment:CHEMICAL RESISTANT LABORATORY COAT &/RUBBER
APRON, USE APPROPRIATE OSHA/MSMA APPROVED SAFETY EQUIPMENT.
Supplemental Safety and Health
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:2,3,6-TRICHLOROBIPHENYL
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:TOXIC; IRRITANT. TOXIC MATERIAL
CAUSING OTHER TOXIC EFFECTS.
Explanation of Carcinogenicity:NONE
* First Aid Measures *
First Aid:EYES/SKIN: FLUSH W/COPIOUS AMOUNTS OF WATER. INHALATION:
REMOVE TO FRESH AIR. GIVE OXYGEN IF NECESSARY. OBTAIN MEDICAL
ATTENTION IN ALL CASES.
* Fire Fighting Measures *
Extinguishing Media:CO2, DRY CHEMICAL POWDER/WATER SPRAY.
* Accidental Release Measures *
Spill Release Procedures:LEAKING BOTTLE MAY BE PLACED IN A PLASTIC BAG
& NORMAL DISPOSAL PROCEDURES FOLLOWED. LIQUID SAMPLES MAY BE
ABSORBED ON VERMICULITE/SAND.
*Handling and Storage *
Handling and Storage Precautions:KEEP TIGHTLEY CLOSED & STORE IN A
COOL/DRY PLACE.
Other Precautions:THIS MATERIAL SHOULD ONLY BE USED BY THOSE PERSONS
TRAINED IN THE SAFE HANDLING OF HAZARDOUS CHEMICALS. PREVENT
CONTACT W/SKIN, EYES & CLOTHING. ALL CHEMICALS SHOULD BE CONSIDERED
HAZARDOUS, DIRECT PH YSICAL CONTACT SHOULD BE AVOIDED.
* Physical/Chemical Properties *
Melt/Freeze Pt:M.P/F.P Text:(SEE SUPP)
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS
* Disposal Considerations *
Waste Disposal Methods:BURN IN CHEMICAL INCINERATOR EQUIPPED W/AN
AFTERBURNER & SCRUBBER IAW/FEDERAL, STATE & LOCAL REGULATIONS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NONE REQD IN NORMAL CONDITIONS.
Ventilation:MECHANICAL(GEN) IF NEEDED
Other Protective Equipment:AS NEEDED BY LOCAL AUTHORITIES.
Supplemental Safety and Health
ITEM IS 8 PARTS KIT.THE KIT CONSISTS OF BLEACH,COLR DEVLPR,FIRST
DEVLPR,FIXER,NEUTRLZR,PREHARDNR,STABILIZER & STOP BATH;THIS ENTRY
DESCRIBES PART A(NEW FORMULATION) OF BLEACH,ADDENDUM SHEET DATED
W/O REPLACEMENT.KEY1:N1.
* Product Identification *
Kit Part:Y
* Composition/Information on Ingredients *
* Hazards Identification *
Effects of Overexposure:MSDS FM MFR STATES THAT EFFECTS OF OVEREXPOSURE
ARE OF LOW HAZARD TO HEALTH.
* First Aid Measures *
First Aid:PER MFR MSDS,"NONE INDICATED.";HOWEVER,FLUSH W/LG AMT OF
WATER IN CASE OF SKIN/EYE CONTACT.GET MED ATTN IF NEEDED OR
SYMPTOMS OCCUR.
* Fire Fighting Measures *
Flash Point:NONE
Lower Limits:NONE
Upper Limits:NONE
Extinguishing Media:CO*2,FOAM,DRY CHEM
Fire Fighting Procedures:WEAR SELF-CNTND BRTHG APP.COOL FIRE EXPSD
CONTNRS W/H*2OSPRA
Unusual Fire/Explosion Hazard:NONE KNOWN
* Accidental Release Measures *
Spill Release Procedures:EVACUATE UNPROTECTED PERSONS.ELIM IGN
SOURCES.USE PROTECTV CLOTHNG/SAFETY GLASSES.STOP LEAK W/O
RISK.PROVIDE VENT.DIKE LG SPILL & PUMP INTO COVRD
DRUMS;ABSORB/CONTAIN SM SPILL IN CONT;MFGR RECOMMENDS, FLUSH TO
SEWER W/LG AMT OF WATER IAW EXISTING LAWS
*Handling and Storage *
Handling and Storage Precautions:STORE IN COOL,DRY,WELL VENTILATED
AREA.KEEP CONTNRS TIGHTLY CLOSED.PROTECT CONTNRS FROM PHYSICAL
DAMAGE.STORE AWAY FROM STRONG ACID & DIRECT SUNLIGHT.
Other Precautions:AVOID PROLONGED/REPEATED CONTACT W/PRODUCT.REMOVE &
WASH CONTAMINATED CLOTHING.WASH HANDS AFTER USE;PH OF PRODUCT
APPROX:7.0
* Physical/Chemical Properties *
HCC:T6
Vapor Density:0.6
Solubility in Water:COMPLETE
Appearance and Odor:WHITE CLEAR TO PINKISH CLEAR-ODORLESS LIQUID
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
NONE
Stability Condition to Avoid:UNK
Hazardous Decomposition Products:NONE KNOWN
* Disposal Considerations *
Waste Disposal Methods:KEEP IN COVERED CONTAINERS PENDING DISPOSAL.SHIP
WASTE MATL TO DISPOSL FACILTY IAW DOT/EPA REGS.HANDLE/DISPOSE IN
FULL COMPLIANCE W/ALL INTNL,FED,STATE/LOCAL REGS;MFGR
RECOMMENDS,FLUSH TO SEWER W/LG A MT OF WATER IAW FED,STATE/LOCAL
EFFLUENTLAWS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:USE NIOSH/MSHA APPRVD RESPIRATION IF REQUIRED.
Other Protective Equipment:NONE REQUIRED
Supplemental Safety and Health
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:SODIUM BISULFITE (SASA III)
OSHA PEL:5 MG/M3
* Hazards Identification *
Effects of Overexposure:INGEST: HARMFUL. EYE & SKIN: IRRITANT.
* First Aid Measures *
First Aid:INGEST: DO NOT INDUCE VOMITING. GIVE 1 OZ MAGNESIA GEL;CALL
* Fire Fighting Measures *
Flash Point:NONE
Fire Fighting Procedures:NONE
Unusual Fire/Explosion Hazard:NONE
* Accidental Release Measures *
Spill Release Procedures:SWEEP UP EXCESS, FLUSH WITH PLENTY OF WATER.
*Handling and Storage *
Handling and Storage Precautions:STORE IN TIGHTLY CLOSED CONTAINER IN
COOL,DRY LOCATION.
* Physical/Chemical Properties *
Solubility in Water:APPRECIABLE
Appearance and Odor:WHITE ODORLESS POWDER
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
ALKALIES
Stability Condition to Avoid:CONTACT W/ WATER LIBERATES SULFURIC ACID
Hazardous Decomposition Products:NONE KNOWN
* Disposal Considerations *
Waste Disposal Methods:MFR RECOMMENDS FLUSHING DOWN DRAIN W/ PLENTY OF
COLD WATER. DISPOSAL METHOD MUST BE IAW FEDERAL, STATE ANS LOCAL
CODES.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
FITTED HALF-MASK OR FULL FACEPIECE RESPIRATOR (NIOSH/MSHA).
Ventilation:SUFFICIENT VENTILATION REQUIRED; REMOVE DECOMP PRODUCTS
FORMED DURING WELDING/FLAME CUTTING.
Other Protective Equipment:CHEMICAL RESISTANT CLOTHING.
Work Hygienic Practices:WASH IMMED UPON CONTAMINATION; REMOVE ANY WET
CLOTHING AND WASH BEFORE REUSE; WASH BEFORE EATING, SMOKING, USING
TOILET
Supplemental Safety and Health
NK
* Product Identification *
Preparer's Name:MICHAEL LICHATOWICH
* Composition/Information on Ingredients *
Ingred Name:NO INGREDIENT FOR THIS FORMULATION_INGREDIENT
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES: SEVERE IRRITATION, LACRIMATION,
REDNESS, BLURRED VISION; SKIN: REDNESS, IRRITATION, DEFATTING,
DERMATITIS; INHALE: NASAL/RESP IRRITATION, CNS DEPRESSION, NAUSEA,
HEADACHE, VERTIGO, UNCONSCIOUSNE SS, ASPHYXIATION; SWALLOWING: GI
IRRITATION, ABDOMINAL PAIN, NAUSEA, VOMITING, DIARRHEA.
Explanation of Carcinogenicity:NO
Effects of Overexposure:DERMOTITIS, LUNG/BLOOD HAZARD, CHRONIC HEALTH
EFFECTS, EUPHORIA, NERVOUSNESS INSOMNIA, PARESTHESIA, PHOTOPHOBIA
* First Aid Measures *
First Aid:INHALE: REMOVE TO FRESH AIR IMMED; GIVE CPR; GET MED AID
ASAP. SKIN: WASH WITH SOAP/WATER. EYE: IMMED FLUSH WITH MUCH WATER
NOT WEAR CONTACT LENSES WHILE WORKING. INGEST: DRI 1 OR 2
GLASSES OF WATER; DO NOT INDUCE VOMITING; GET MED AID IMMED; TREAT
SYMPTOMATICALLY.
* Fire Fighting Measures *
Flash Point Method:TCC
Lower Limits:0.8
Upper Limits:7.6
Extinguishing Media:DRY CHEMICAL, FOAM, CO2
Fire Fighting Procedures:WEAR SCUBA WITH FULL FACEPIECE IN POSITIVE
PRESSURE MODE; FULL PROTECTIVE CLOTHING; WATER MAY BE USED TO COOL
CONTAINERS TO PREVENT EXPLOSION.
Unusual Fire/Explosion Hazard:KEEP CONTAINERS TIGHTLY CLOSED; ISOLATE
FROM ALL IGNITABLES; CLOSED CONTAINERS MAY EXPLODE WHEN EXPOSED TO
HEAT; EXPOSURE TO DECOMP PRODUCTS MAY CAUSE HAZARDS.
* Accidental Release Measures *
Spill Release Procedures:ELIMINATE ALL IGNITABLES; MINIMIZE ALL CONTACT
WITH PRODUCT;DIKE; AVOID RUNOFF INTO SOIL, SEWERS, OR WATERWAYS.
ABSORB WITH INERT MATERIAL SUCH AS CLAY, SOIL, OR A COMMERCIALLY
AVAILABLE ABSORBENT; SH OVEL INTO SALVAGE DRUMS FOR DISPOSAL.
*Handling and Storage *
Handling and Storage Precautions:AVLOID STORAGE IN HIGH TEMPERATURE
AREAS OR NEAR IGNITABLES; KEEP CONTAINERS CLOSED; AVOID ROUGH
HANDLING.
Other Precautions:EMPTY CONTAINERS MAY BE HAZARDOUS; DO NOT WELD/FLAME
CUT ON EMPTY DRUMS; SHOCK FROM DROPPING MAY SPLIT CONTAINER.
* Physical/Chemical Properties *
Vapor Density:>AIR
Evaporation Rate & Reference:<ETHER
Solubility in Water:YES
Appearance and Odor:LIQUID, ODOR OF SOLVENTS
Corrosion Rate:MINIMAL
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDEZERS, NITRATES, ALDALIES, ACIDS, STRONG ACIDS
Stability Condition to Avoid:HIGH TEMPERATURES
Hazardous Decomposition Products:CO, CO2
* Disposal Considerations *
Waste Disposal Methods:PER ALL LOCAL, STATE, AND FEDERAL REGULATIONS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:USE ORGANIC VAPOR RESPIRATOR (AIR
PURIFYING/FRESH AIR). OBSERVE OSHA REGULATIONS (RESPIRATOR USE).
PROVIDE VENT (KEEP EXPOSURE LEVELS BELOW OSHA LIMITS). VAPOR PARTIC
LIMITS
Ventilation:EXHAUST VENT SUFFICIENT TO KEEP AIRBORNE CONC (SOLVENT/
POLYISOCYANATES/HDI) BELOW TLV'S. REMOVE ALL IGNITION SOURCES.
Other Protective Equipment:FACE SHIELDS. THE USE OF LONG SLEEVE AND
LONG LEG CLOTHING IS RECOMMENDED.
Work Hygienic Practices:REMOVE AND WASH CONTAMINATED CLOTHING BEFORE
REUSE. WASH HANDS BEFORE EATING, SMOKING OR USING WASHROOM.
Supplemental Safety and Health
POSSIBLE ISOCYANATE SENSITIZATION WHICH WILL CAUSE THEM TO REACT TO A
LATER EXPOSURE OF ISOCYANATES LEVELS WELL BELOW THE TLV VALUE OF
ISOCYANATES.
* Product Identification *
Kit Part:Y
Preparer's Name:NORM GAUL
* Composition/Information on Ingredients *
Ingred Name:ALIPHATIC ISOCYANATE HEXAMETHYLENE DIIOSOCYANATE (HDI) CAS
Other REC Limits:MOBAY TLV: 1 MG/M3
Fraction by Wt: <5.0%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:NOT EST.
ACGIH TLV:NOT EST.
Fraction by Wt: <5.0%
Other REC Limits:NONE RECOMMENDED
Other REC Limits:NONE RECOMMENDED
Other REC Limits:NONE SPECIFIED
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE; IRRITATING TO EYES, NOSE &
THROAT. INHAL: HEADACHES, DIZZINESS, STAGGERING, DIFFICULT
BREATHING, CONFUSION, UNCONSCIOUSNESS, COMA. SKIN: IRRITATING
(SWELLING, REDNESS, RASH). EYES: IRRIT (TEARI NG, REDNESS, SWELLING
W/STINGING). INGEST: IRRITATION, CORROSIVE TO GI TRACT. ASPIRATION
(VOMITING, CHEMICAL PNEUMONITIS
Effects of Overexposure:INHAL: DIFFICULT BREATHING, HEADACHE,
DIZZINESS, STAGGERING GAIT, CONFUSION, UNCONSCIOUSNESS, COMA. SKIN:
IRRIT (SWELLING/REDNESS/RASH). EYES: REDNESS, TEARING, SWELLING
W/STINGING. SKIN: PROLONGED/RE PEATED--MODERATE IRRIT, DRYING, SKIN
CRACKING. INGEST: VOMIT. IRRIT. CORROSIVE TO MOUTH, STOMACH &
DIGESTIVE TRACT.
Medical Cond Aggravated by Exposure:ASTHMA AND ANY OTHER RESPIRATORY
DISORDERS. SKIN ALLERGIES, ECZEMA, AND DERMATITIS.
* First Aid Measures *
First Aid:INHALE-MOVE TO AN AREA FREE FROM RISK OF FUTHER EXPOSURE.
RESTORE BREATHING. OBTAIN MEDICAL ATTENTION. SKIN-REMOVE
CONTAMINATED CLOTHING. WASH AFFECTED AREAS THOROUGHLY WITH SOAP &
WATER. EYES-FLUSH W ITH CLEAN LUKEWARM WATER (LOW PRESSURE)FOR AT
GIVE ANYTHING TO UNCONSCIOUS PERSON. GET MED AID.
* Fire Fighting Measures *
Flash Point Method:TCC
Lower Limits:1.0
Upper Limits:8.0
Extinguishing Media:FOAM, ALCOHOL FOAM, CO2, DRY CHEMICAL, WATER FOG,
WATER SPRAY.
Fire Fighting Procedures:FULL FIRE FIGHT EQUIP W/SCBA & FULL PROTECT
CLOTH. USE WATER TO COOL CLOSED CNTNRS/PREVENT PRESSURE
BUILD-UP/AUTO IGNITE/EXPLOSION. HDI/IRRIT VAPORS GENERATED.
Unusual Fire/Explosion Hazard:KEEP FROM IGNITE SOURCES. CLOSED CNTNR
MAY EXPLODE W/HEAT. USE SPECIAL PRECAUTION W/APPLIC TO HOT SRFCS.
DURING EMERG COND, OVEREXPOS TO DECOMP PROD/HEALTH HZD.
* Accidental Release Measures *
Spill Release Procedures:EVACUATE ALL NON-ESSENTIAL PERSONNEL. REMOVE
ALL SOURCES OF IGNITION (FLAME, SPARK SOURCES, HOT SURFACES).
VENTILATE AREA. CONTAIN AND REMOVE WITH INERT ABSORBENT AND
NON-SPARKING TOOLS.
*Handling and Storage *
Handling and Storage Precautions:STORE IN BLDG IN COMPLIANCE W/OSHA
CLOSED CONTAINERS. STORE IN WELL VENT AREAS.
Other Precautions:KEEP CNTNRS TIGHT/UPRIGHT (PREVENT LEAKAGE). NO
PROLONGED BREATHING OF VAPORS/SPRAY MISTS. AVOID CONTACT
W/SKIN/EYES. DO NOT TAKE INTERNALLY. DO NOT HANDLE UNTIL THE SAFETY
PRECAUTIONS HAVE BEEN READ/ UNDERSTOOD. SMOKE ONLY IN SMOKING
AREAS.
* Physical/Chemical Properties *
Vapor Density:> AIR
Solubility in Water:INSOLUBLE
Appearance and Odor:AMBER LIQUID WITH SOLVENT ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
WATER, AMINES, STRONG BASES, ALCOHOLS, METAL COMPOUNDS AND SURFACE
ACTIVE MATERIALS.
Stability Condition to Avoid:CONTACT WITH MOISTURE, MATERIALS WHICH
REACT WITH ISOCYANATES AND HIGH TEMPERATURES.
Hazardous Decomposition Products:BY HIGH HEAT/TEMPERATURE: CARBON
MONOXIDE, CARBON DIOXIDE, AND OXIDES OF NITROGEN, TRACES OF HCN AND
HDI.
* Disposal Considerations *
Waste Disposal Methods:WASTE MUST BE DISPOSED IN ACCORD W/FEDERAL,
STATE & LOCAL ENVIRONMENTAL CONTROL REGULATIONS. EMPTY CONTAINERS
MUST BE HANDLED W/CARE (PRODUCT RESIDUE/FLAMMABLE VAPOR). DON'T
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:USE NIOSH APPROVED CHEMICAL CARTRIDGE RESPIRATOR
DURING SPRAY APPLICATION. IN CONFINED AREAS:USE NIOSH APPROVED
Ventilation:PROVIDE GENERAL DILUTION OR LOCAL EXHAUST VENT IN VOLUME &
PATTERN TO KEEP TLV OF HAZ INGS BELOW ACCEPTABLE LIMITS.
Other Protective Equipment:EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET
ANSI DESIGN CRITERIA . USE IMPERVIOUS CLTHG TO PVNT PRLNG SKIN
CONT.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
FIRE FIGHT PROC:NOT APPLY TO HOT SURFACES. EXPLO HAZ:OR EXPLOSION. IF
WATER IS USED, FOG NOZZLES ARE PREFERRED. EFTS OF
OVEREXP:INHALATION CONTENTS CAN BE HARMFUL OR FATAL.
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:SOLVENT NAPHTHA (PETROLEUM), LIGHT AROMATIC; (AROMATIC
ACGIH TLV:N/K
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:INHAL:HARMFUL IF INHALED. MAY
AFFECT BRAIN/NERV SYS, CAUSING DIZZ, HDCH/NAUS. RPTD OVEREXPS MAY
PROGRESSIVELY LEAD TO STAG GAIT, CONFUSN, UNCON/COMA. CAUSES NOSE &
THROAT IRRIT. SKIN/EYE CONT:CA USES IRRIT WHICH CAN LEAD TO DERM
W/RPTD OVEREXPS. INGEST:MAY CAUSE GI IRRIT, NAUS, VOMIT & DIARR.
(EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:CHRONIC:RPTS HAVE ASSOC RPTD & PRLNG
OCCUP OVEREXP TO SOLVS W/PERM BRAIN & NERV SYS DMG. OVEREXP TO
XYLOL IN LAB ANIMALS HAS ALSO BEEN ASSOC W/LIVER ABNORMS, KIDNEY,
LUNG, SPLEEN & EYE DMG AS WELL AS ANEMIA. EFTS IN HUMANS HAVE INCL
LIVER & CARDIAC ABNORMS. INTENTIONAL MISUSE BY DELIB CONCENTRATING
& (SUPDAT)
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
* First Aid Measures *
First Aid:INHAL:REMOVE FROM EXPOSURE, RESTORE BREATHING & NOTIFY MD.
MINUTES. NOTIFY MD. SKIN:WASH AFFECTED AREA W/SOAP & WATER, REMOVE
CONTAMINAT ED CLOTHING & WASH BEFORE REUSE. INGEST:DO NOT INDUCE
VOMITING. KEEP PERSON WARM, QUIET & GET MEDICAL ATTENTION.
ASPIRATION OF THIS MATL INTO LUNGS CAN CAUSE CHEMICAL PNEUMONITIS
WHICH CAN BE FATAL.
* Fire Fighting Measures *
Flash Point Method:TCC
Lower Limits:SEE INGS
Extinguishing Media:NFPA CLASS B EXTINGUISHERS (CARBON DIOXIDE, DRY
CHEMICAL OR FOAM).
Fire Fighting Procedures:USE NIOSH APPRVD SCBA & FULL PROT EQUIP .
WATER SPRAY MAY BE INEFT. WATER MAY BE USED TO COOL CLSD CNTNRS TO
PVNT PRESS BUILD-UP & POSS AUTO-IGNIT(SUPDAT)
Unusual Fire/Explosion Hazard:EXTREMELY FLAMM. KEEP CNTNRS TIGHTLY
CLSD. KEEP AWAY FROM HEAT, ELEC EQUIP, SPKS & OPEN FLAME. CLSD
CNTNRS MAY EXPLODE WHEN EXPOS TO EXTREME HEAT. DO(SUPP DATA)
* Accidental Release Measures *
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION, VENTILATE AREA
& REMOVE W/INERT ABSORBENT & NON-SPARKING TOOLS.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
PUNCTURE CONTAINERS.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
* Physical/Chemical Properties *
Vapor Pres:SEE INGS
Vapor Density:LTR/AIR
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
INCOMPATIBLE W/STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:BY OPEN FLAME - CARBON MONOXIDE &
CARBON DIOXIDE.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF ACCORDING TO LOCAL, STATE & FEDERAL
REGULATIONS. DO NOT INCINERATE CONTAINERS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:USE NIOSH CHEMICAL CARTRIDGE RESPIRATOR. FOR
SPRAYING USE MECHANICAL PREFILTER. IN CONFINED AREAS USE AIR
SUPPLIED RESPIRATOR.
Ventilation:LOCAL EXHAUST.
Other Protective Equipment:EYEWASH FACILITY, SAFETY SHOWER.
Supplemental Safety and Health
MORE INFORMATION ON FILE.
* Product Identification *
Kit Part:Y
Preparer's Name:BETTY SMITH
* Composition/Information on Ingredients *
Other REC Limits:NONE RECOMMENDED
Other REC Limits:NONE RECOMMENDED
OSHA PEL:1 MG/M3
ACGIH TLV:1 MG/M3
Other REC Limits:NONE RECOMMENDED
OSHA PEL:NOT RELEVANT
ACGIH TLV:NOT RELEVANT
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INGEST: BURNS, STOMACH PAIN, NAUSEA,
VOMITING, GI IRRIT, CHEMICAL PNEUMONITIS. INHAL: IRRITATION,
(COUGH, THROAT BURN, CHOKING SENSATION), PULMONARY EDEMA. EYE:
IRRITATION, CORNEAL DAMAGE. SKIN: BURN. CHRONIC: DERMATITIS,
EROSION OF TEETH,BRAIN/NS DAMAGE. INHAL: HARMFUL/FATAL.
* First Aid Measures *
First Aid:INGEST: DONT INDUCE VOMIT. GIVE 1-2 GLASSES WATER. NEVER GIVE
ANYTHING BY MOUTH TO UNCONCIOUS PERSON. CALL POISON
CONTROL/EMERGENCY ROOM/DR IMMED. INHAL: REMOVE TO FRESH AIR. IF
BREATHING STOPPED, GIV E ARTIFICIAL RESPIRATION. KEEP WARM/QUIET.
LIDS. GET MED AID. SKIN: FLUSH W/LARGE AMOUNTS WATER. REMOVE CONTAM
CLOTHES. CALL DR.
* Fire Fighting Measures *
Extinguishing Media:CLASS B EXTINGUISHERS (CO2, DRY CHEMICAL, ALCOHOL
FOAM) FOR FLAMMABLE LIQUID. POLYMER FOAM PREFERRED FOR LARGE FIRES.
Fire Fighting Procedures:WATER MAY BE INEFFECTIVE, USE H2O (FOG NOZZLES
PREFERRED) TO COOL FIRE EXPOSED CONTAINERS, PREVENT PRESSURE
BUILDUP/AUTOIGNITION/EXPLOSION.
Unusual Fire/Explosion Hazard:DURING EMERGENCY CONDITIONS, OVEREXPOSURE
TO DECOMPOSITION PRODUCTS MAY BE HEALTH HAZARD. SYMPTOMS MAY NOT BE
IMMEDIATELY APPARENT. GET MED AID.
* Accidental Release Measures *
Spill Release Procedures:USE APPROPRIATE PROTECTIVE EQUIPMENT, VENT
AREA, STOP SPILL, DIKE. DILUTE. NEUTRALIZE. ELIMINATE IGNITS.
ABSORB. EVACUATE AREA. TRANSPORT LIQUID TO COVERED METAL CONTAINER.
USE ONLY NON-SPARKING TOOLS . PREVENT SEWER/STREAM/GROUNDWATER
CONTAMINATION.
*Handling and Storage *
Other Precautions:CLOSE CONTAINER AFTER EACH USE. KEEP AWAY FROM
CHILDREN. DONT REUSE EMPTY CONTAINERS FOR ANY PURPOSE. GROUND &
BOND TO RECEIVING CONTAINER WHEN TRANSFERING. DONT WELD/BRAZE/CUT
ON EMPTY CONTAINER. DON T USE PRESSURE TO EMPTY CONTAINER.
* Physical/Chemical Properties *
Vapor Density:>AIR
Spec Gravity:0.9
OF IGNITION.
Hazardous Decomposition Products:SMOKE, CARBON MONOXIDE & CARBON
DIOXIDE.
* Disposal Considerations *
Waste Disposal Methods:IN ACCORDANCE W/FEDERAL, STATE & LOCAL
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NONE NORMALLY REQUIRED.
Ventilation:NONE
Other Protective Equipment:EYE WASH STATION, EMERGENCY SHOWER,
APPROPRIATE LABORATORY COAT TO COVER EXPOSED SKIN
Work Hygienic Practices:DO NOT BREATHE VAPORS OR MIST. DO NOT GET IN
EYES, ON SKIN OR ON CLOTHING. LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE.
Supplemental Safety and Health
THIS PRODUCT IS A KIT CONSISTING OF THREE PARTS, PART A, HAS PIN A;
PART B HAS PIN B, PART C HAS PIN C, SAME NSN.
* Product Identification *
Kit Part:Y
* Composition/Information on Ingredients *
Ingred Name:NON HAZARDOUS INGREDIENTS
Other REC Limits:NONE RECOMMENDED
* Hazards Identification *
Routes of Entry: Inhalation:NOSkin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE- EYES:MILD IRRITATION. SKIN:MILD
IRRITATION ON PROLONGED CONTACT. INHALATION:NON-HAZARDOUS.
INGESTION:NOT CONSIDERED TO BE A PRIMARY ROUTE OF EXPOSURE.
CHRONIC- NONE KNOWN.
Effects of Overexposure:MILD EYE IRRITATION. MILD SKIN IRRITATION ON
PROLONGED CONTACT.
Medical Cond Aggravated by Exposure:NONE KNOWN.
* First Aid Measures *
First Aid:GET MEDICAL ATTENTION IF SYMPTOMS PERSIST. EYE/SKIN:FLUSH
FRESH AIR & PROVIDE OXYGEN/CPR IF NEEDED. ORAL:FLUSH OUT MOUTH WITH
WATER. SEE K MEDICAL ATTENTION.
* Fire Fighting Measures *
Extinguishing Media:WATER SPRAY, CARBON DIOXIDE, FOAM OR DRY CHEMICAL
FOR SURROUNDING FIRE. USE WATER SPRAY TO COOL FIRE EXPOSED
CONTAINERS.
Fire Fighting Procedures:WEAR NIOSH-APPROVED SELF-CONTAINED BREATHING
APPARATUS IF NEEDED.
Unusual Fire/Explosion Hazard:NO FIRE OR EXPLOSION HAZARDS EXIST.
* Accidental Release Measures *
Spill Release Procedures:THIS MATERIAL IS NOT A HAZARDOUS WASTE
ACCORDING TO RCRA. SPILLS ARE NOT COVERED BY EPA REGULATIONS.
MATERIAL SPILLED SHOULD BE CONTAINED; ABSORBED ON SUITABLE
ABSORBENT AND TRANSFERRED TO A CONTAINER . AREA MAY BE FLUSHED WITH
WATER TO REMOVE TRACES.
Neutralizing Agent:NOT APPLICABLE.
*Handling and Storage *
Handling and Storage Precautions:STORAGE- STORE IN CLOSED CONTAINER
AWAY FROM INCOMPATIBLE MATERIALS.
Other Precautions:DUE TO THE ACIDIC NATURE OF THIS PRODUCT, MIXING WITH
HYPOCHLORITE SOLUTIONS SHOULD BE RESTRICTED TO LOW CONCENTRATIONS
AND ALKALINE PH. FAILURE TO CONFORM MAY RESULT IN THE RELEASE OF
CHLORINE GAS FR OM THE HYPOCHLORITE.
* Physical/Chemical Properties *
HCC:N1
pH:3-4
Evaporation Rate & Reference:>1 (WATER=1)
Solubility in Water:COMPLETE
Appearance and Odor:PALE YELLOW VISCOUS LIQUID - FAINT ODOR
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG HYPOCHLORITE SOLUTIONS
Stability Condition to Avoid:NONE KNOWN.
Hazardous Decomposition Products:NONE KNOWN.
* Disposal Considerations *
Waste Disposal Methods:MATERIAL MAY BE DILUTED WITH WATER AND FLUSHED
TO AN APPROVED DRAIN. DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE
AND FEDERAL REGULATIONS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:IF PERSONAL EXPOSURE CANNOT BE CONTROLLED BELOW
APPLICABLE LIMITS BY VENTILATION,WEAR A PROPERLY FITTED ORGANIC
VAPOR/PARTICULATE RESPIRATOR APPROVED BY NIOSH/MSHA FOR PROTECTION.
Ventilation:LOCAL EXHAUST PREFERABLE,GENERAL EXHAUST ACCEPTABLE.
Work Hygienic Practices:WASH HANDS AFTER USING.
Supplemental Safety and Health
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:ETHYLENE GLYCOL (SARA III)
Fraction by Wt: <5%
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:SILICA, CRYSTALLINE - CRISTOBALITE
Fraction by Wt: <5%
OSHA PEL:SEE TABLE Z3
Ingred Name:TITANIUM DIOXIDE
Ingred Name:NICKEL ANTIMONY TITANATE
Fraction by Wt: 5%
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Health Hazards Acute and Chronic:IRRITATION OF EYES,SKIN AND UPPER
RESPIRATORY SYSTEM.IN A CONFINED AREA VAPORS IN HIGH CONCENTRATION
MAY CAUSE HEADACHE,NAUSEA OR DIZZINESS.
Effects of Overexposure:REDNESS AND ITCHING OR BURNING SENSATION MAY
INDICATE EYE OR EXCESSIVE SKIN EXPOSURE.
Medical Cond Aggravated by Exposure:NONE GENERALLY RECOGNIZED.
* First Aid Measures *
First Aid:INHALATION:IF AFFECTED,REMOVE FROM EXPOSURE.RESTORE
BREATHING.KEEP WARM AND QUIET.SKIN:WASH AFFECTED AREA THOROUGHLY
WITH SOAP AND WATER.REMOVE CONTAMINATED CLOTHING AND LAUNDER BEFORE
MEDICAL ATTEN.
* Fire Fighting Measures *
Extinguishing Media:CARBON DIOXIDE,DRY CHEMICAL,ALCOHOL FOAM
Fire Fighting Procedures:FULL PROTECTIVE EQUIPMENT INCLUDING
SELF-CONTAINED BREATHING APPARATUS.WATER MAY BE INEFFECTIVE.IF
WATER IS USED,FOG NOZZLES ARE PREFERABLE.
Unusual Fire/Explosion Hazard:CLOSED CONTAINERS MAY EXPLODE (DUE TO THE
BUILD-UP OF PRESSURE) WHEN EXPOSED TO EXTREME HEAT.
* Accidental Release Measures *
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION.VENTILATE AND
REMOVE WITH INERT ABSORBENT.
*Handling and Storage *
Handling and Storage Precautions:KEEP CONTAINER CLOSED WHEN NOT IN
USE.TRANSFER ONLY TO APPROVED CONTAINERS WITH COMPLETE AND
APPROPRIATE LABELING.KEEP OUT OF REACH OF CHILDREN.
* Physical/Chemical Properties *
Vapor Density:>THAN AIR
Evaporation Rate & Reference:SLOWER THAN ETHER
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
Hazardous Decomposition Products:CARBON DIOXIDE,CARBON MONOXIDE
* Disposal Considerations *
Waste Disposal Methods:INCINERATE IN APPROVED FACILITY.DO NOT
INCINERATE CLOSED CONTAINER.DISPOSE OF IN ACCORDANCE WITH
FEDERAL,STATE AND LOCAL REGULATIONS REGARDING POLLUTION.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE
FOR EXPOSURE OF CONCERN .
Ventilation:NO SPECIAL VENTILATION PRECAUTIONS ARE NECESSARY.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:NO SPECIAL PERSONAL HYGIENE PRECAUTIONS ARE
NECESSARY.
Supplemental Safety and Health
HAZ DECOMP PRODS:OXIDES OF NITROGEN.
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:BISPHENOL A/EPICHLOROHYDRIN RESIN WITH NON HAZ FILLERS, AND
PIGMENTS; (BISPHENOL A/EPICHLOROHYDRIN-BASED EPOXY RESIN)
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:CURING AGENTS, PROCESSING AIDS, AND PIGMENTS;
(NON-HAZARDOUS CURING AGENTS)
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:FILLERS; (NON-HAZARDOUS GLASS FILLERS, (CURED
STATE:NON-REACTIVE))
OSHA PEL:N/K
ACGIH TLV:N/K
* Hazards Identification *
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION/EYE CONTACT/SKIN
CONTACT/INGESTION:NONE KNOWN.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
* First Aid Measures *
First Aid:INGEST:CALL MD IMMEDIATELY . INHAL:REMOVE TO FRESH AIR.
SUPPORT BREATHING (GIVE O*2/ARTF RESP) . EYES:IMMEDIATELY FLUSH
MD. SKIN:FLUSH W/COPIOUS AMOUNTS OF WATER. CALL MD .
* Fire Fighting Measures *
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL, FOAM, WATER FOG.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:TOXIC FUMES MAY BE INVOLVED UPON EXPOSURE
TO HEAT OR OPEN FLAME.
* Accidental Release Measures *
Spill Release Procedures:FOR SMALL/LARGE SPILLS:NOT APPLICABLE.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:NO SPECIAL STORAGE PRECAUTIONS ARE
Other Precautions:AVOID PROLONGED DIRECT CONTACT WITH OPEN FLAME, AS
TOXIC FUMES MAY BE EVOLVED.
* Physical/Chemical Properties *
Appearance and Odor:HOLLOW, NATURAL COLOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
NONE KNOWN.
Stability Condition to Avoid:DIRECT CONTACT WITH OPEN FLAME.
Hazardous Decomposition Products:HAZ THERMAL DEGRADATION PRODS
RESULTING FROM FIRE MAY INCLUDE:CARBON MONOXIDE, CARBON DIOXIDE,
HYDROCARBONS, (SUP DAT)
* Disposal Considerations *
Waste Disposal Methods:DISPOSAL MUST BE I/A/W FEDERAL, STATE & LOCAL
REGULATIONS . ECCOSPHERES EP SPHERES MAY BE DISPOSED OF WITH NORMAL
SOLID WASTE. EPA HAZARDOUS WASTE CLASSIFICATION IS NON-HAZARDOUS.
| 1 | eyes_protection_mandatory |
Control Measures
*
Kit Part: Y
*
Ingredients
*
*
Health Hazards Data
*
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: MATERIAL CONSIDERED NON HAZARDOUS. ALL CHARACTERISTICS OF
THIS SUBSTANCE MAY NOT BE INVESTIGATED.
Signs And Symptions Of Overexposure: NONE
First Aid: EXTERNAL: WASH AFFECTED PARTS WITH PLENTY OF WATER. INTERNAL: IF
INGESTED WASH MOUTH AND CONSULT PHYSICIAN.
*
Handling and Disposal
*
Spill Release Procedures: ABSORB WITH SAND OR VERMILCULITE AND PLACE IN
SUITABLE CONTAINER.
Waste Disposal Methods: PLACE CONTAINER IN TRASH.
*
Fire and Explosion Hazard Information
*
Flash Point Text: NON FLAMMABLE
Extinguishing Media: NON FLAMMABLE
*
*
#1 AND 2) AMMONIA TEST SOLUTION #2.
*
Physical/Chemical Properties
*
HCC: N1
Appearance and Odor: CLEAR, COLORLESS LIQUID
*
Reactivity Data
*
Stability Indicator: YES
*
Toxicological Information
*
*
Ecological Information
*
*
*
Transport Information: NOT REGULATED
*
Regulatory Information
*
*
Other Information
*
*
Transportation Information
*
Multiple KIT Number: 0
Kit Part IND: Y
Unit Of Issue: CY
Type Of Container: CYLINDER
*
Detail DOT Information
*
DOT PSN Code: ZZZ
DOT Proper Shipping Name: NOT REGULATED BY THIS MODE OF TRANSPORTATION
*
Detail IMO Information
*
IMO PSN Code: ZZZ
IMO Proper Shipping Name: NOT REGULATED FOR THIS MODE OF TRANSPORTATION
*
Detail IATA Information
*
IATA PSN Code: ZZZ
IATA Proper Shipping Name: NOT REGULATED BY THIS MODE OF TRANSPORTATION
*
Detail AFI Information
*
AFI PSN Code: ZZZ
AFI Proper Shipping Name: NOT REGULATED BY THIS MODE OF TRANSPORTATION
*
HAZCOM Label
*
Assigned IND: Y
Company Name: LAB-AIDS, INC
Label Required IND: Y
Status Code: A
Origination Code: F
Skin Protection IND: NO
Signal Word: NONE
Respiratory Protection IND: NO
Health Hazard: None
Contact Hazard: None
Fire Hazard: None
Reactivity Hazard: None
Hazard And Precautions: TARGET ORGANS: N/P. MATERIAL CONSIDERED NON HAZARDOUS.
ALL CHARACTERISTICS OF THIS SUBSTANCE MAY NOT BE INVESTIGATED.
*
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN .
Ventilation:LOCAL AND GENERAL VENTILATION NECESSARY TO KEEP AIR
CONCENTRATION BELOW LEVEL OF CONCERN .
Work Hygienic Practices:N/K
Supplemental Safety and Health
ROUTES OF ENTRY:INHALATION/SKIN/INGESTION .
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:BUTYL BENZYL PHTHALATE (SARA III)
Other REC Limits:N/K
* Hazards Identification *
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SEE SIGNS AND SYMPTOMS OF
OVEREXPOSURE.
Explanation of Carcinogenicity:INDEFINITE IN ANIMALS (MFR).
Effects of Overexposure:EYES/SKIN:IRRITATION.INGESTION/INHALATION:N/K .
Medical Cond Aggravated by Exposure:N/K
* First Aid Measures *
LARGE VOLUMES OF WATER.INGESTION:CALL MD IMMEDIATELY
.INHALATION:IMMEDIATELY MOVE TO FRESH AIR.
* Fire Fighting Measures *
Lower Limits:N/K
Upper Limits:N/K
Extinguishing Media:CO*2,DRY CHEMICAL.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
* Accidental Release Measures *
Spill Release Procedures:TAKE UP WITH ABSORBENT MATERIAL.
Neutralizing Agent:N/K
*Handling and Storage *
Handling and Storage Precautions:STORE IN SEALED CONTAINER IN COOL,DRY
LOCATION.KEEP AWAY FROM OXIDIZERS.
Other Precautions:POSSIBLE CANCER HAZARD.AVOID EYE OR SKIN CONTACT.
* Physical/Chemical Properties *
Decomp Temp:Decomp Text:N/K
Appearance and Odor:CLEAR,OILY LIQUID.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
OXIDIZING AGENTS.
* Disposal Considerations *
Waste Disposal Methods:DISPOSAL MUST BE IN ACCORDANCE WITH
FEDERAL,STATE AND LOCAL REGULATIONS .
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:POSITIVE PRESSURE AIRLINE WITH MASK OR SELF-
CONTAINED BREATHING APPARATUS SHOULD BE AVAILABLE FOR EMERGENCY
USE.
Ventilation:LOCAL EXHST:PREVENT ACCUMULATION OF HIGH CONCN SO AS TO
Other Protective Equipment:SAFETY SHOES.
Work Hygienic Practices:ARGON IS NONCORROSIVE-MAY BE USED W/ANY COMMON
STRUCTURAL MATERIAL. CYLINS NOT TO BE FILLED BY ANYBODY BUT
PRODUCERS.
Supplemental Safety and Health
CNTNR IS SECURED W/VALVE OUTLET PIPED TO USE POINT. DO NOT
DRAG,SLIDE,ROLL CYLINDERS. USE PROPER HAND TRUCK FOR CYLIN
MOVEMENT. USE PRESSURE REDUCING REGULATOR FOR CONNECTING CYLIN TO
INCREASE DISCHARGE RATE. USE CHECK VALVE/TRAP IN DISCHARGE LINE.
* Product Identification *
Product ID:ARGON
* Composition/Information on Ingredients *
Ingred Name:ARGON
Other REC Limits:NONE SPECIFIED
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Health Hazards Acute and Chronic:EFFECTS OF EXPOSURE TO HIGH
CONCENTRATIONS SO AS TO DISPLACE THE OXYGEN IN AIR NECESSARY FOR
LIFE MAY INCLUDE ANY, ALL OR NONE OF THE FOLLOWING: TINGLING OF THE
TONGUE, FINGERTIPS OR TOES, WEAKENED SP EECH LEADING TO THE
INABILITY TO UTTER SOUNDS, RAPID REDUCTION IN THE ABILITY TO
PERFORM MOVEMENTS, REDUCED CONSCIOUS-
Effects of Overexposure:NESS OF THE SURROUNDINGS, LOSS OF TACTILE
SENSATIONS, HEIGHTENED MENTAL ACTIVITY. ARGON IS NONTOXIC BUT THE
LIBERATIN OF A LARGE AMOUNT IN A CONFINED AREA COULD DISPLACE THE
AMOUNT OF OXYGEN IN AIR NE CESSARY TO SUPPORT LIFE. IT IS
POSSIBLETHAT NONE OF THE ABOVE SYMPTOMS MAY OCCUR IN ARGON ASPHYXIA
WITH NO WARNING..
* First Aid Measures *
First Aid:PROMPT MEDICAL ATTENTION IS MANDATORY IN ALL CASES OF
OVEREXPOSURE TO ARGON. INHALE: CONSCIOUS PERSONS SHOULD BE ASSISTED
TO AN UNCONTAMINATED AREA AND INHALE FRESH AIR. QUICK REMOVAL FROM
THE CONTAMI NATED AREA IS MOST IMPORTANT. UNCONSCIOUS PERSONS
SHOULD BE MOVED TO AN UNCONTAMINATED AREA, GIVEN ARTIFICIAL
RESPIRATION AND SUPPLEMENTAL OXYGEN. MEDICAL ATTENTION SHOULD BE
SOUGHT IMMEDIATELY.
* Fire Fighting Measures *
Extinguishing Media:NONFLAMMABLE, INERT GAS
* Accidental Release Measures *
Spill Release Procedures:EVACUATE ALL PERSONNEL FROM AFFECTED AREA. USE
APPROPRIATE PROTECTIVE EQUIPMENT. LEAK IN EQUIP: PURGE PIPING WITH
AN INERT GAS PRIOR TO REPAIR.IF LEAK IS IN CONTAINER/CONTAINER
VALVE, CONTACT THE CLOS EST AIRCO LOCATION OR CALL CHEMTREC:
*Handling and Storage *
Handling and Storage Precautions:PROTECT FROM PHYSICAL DAMAGE. STORE IN
COOL, DRY, WELL-VENTILATED AREA AWAY FROM HEAVILY TRAFFICKED AREAS
Other Precautions:CYLINDERS TO BE STORED UPRIGHT & FIRMLY SECURED TO
PREVENT FALLING OR BEING KNOCKED OVER. FULL & EMPTY CYLINDERS
SHOULD BE SEGREGATED. ROTATE STOCK. USE ONLY IN WELL-VENTILATED
AREAS. VALVE PROTECTION CAPS MUST REMAIN IN PLACE UNLESS
* Physical/Chemical Properties *
HCC:G3
Solubility in Water:VERY SLIGHTLY
Appearance and Odor:COLORLESS, ODORLESS GAS
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
Hazardous Decomposition Products:NONE
* Disposal Considerations *
Waste Disposal Methods:DO NOT ATTEMPT TO DISPOSE OF RESIDUAL/UNUSED
QUANTITIES. RETURN IN THE SHIPPING CONTAINER PROPERLY LABELED, WITH
ANY VALVE OUTLET PLUGS OR CAPS SECURED AND VALVE PROTECTION CAP IN
PLACE TO AIRCO FOR P ROPER DISPOSAL.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:IF ENGINEERING AND ADMINISTRATIVE CONTROLS OF
AIR CONTAMINANTS ARE NOT POSS, USE RESPIRATORY DEVICES APPROVED BY
NIOSH/MSHA FOR PROTECTION AGAINST SPRAY MIST AND VAPORS.
Ventilation:LOCAL EXHAUST PREFERABLE. MECHANICAL (GENERAL) EXHAUST
ACCEPTABLE. SPECIAL VENTILATION REQD TO KEEP BELOW TLV & LEL.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:REMOVE & WASH CONTAMD CLTHG, DISCARD
CONTAMINATED SHOES. WASH HANDS AFTER USING.
Supplemental Safety and Health
FIRE FIGHT PROC: OBTAIN MEDICAL ATTENTION. WATER SPRAY MAY BE
INEFFECTIVE. WATER MAY BE USED TO COOL CLOSED CONTAINERS TO PREVENT
PRESSURE BUILD-UP AND POSSIBLE AUTO IGNITION OR EXPLOSION WHEN
EXPOSED TO EXTREME HEAT.
* Product Identification *
CAGE:ACEHA
CAGE:ACEHA
* Composition/Information on Ingredients *
FLASH). VP: 0.5.
Ingred Name:KEROSENE (PETROLEUM), HYDROTREATED; (MINERAL SPIRITS). VP:
2.
Fraction by Wt: 8.5%
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION IS ANESTHETIC. IRRITATION
OF RESPIRATORY TRACT OR NERVOUS SYSTEM DEPRESSION, HEADACHE,
DIZZINESS, NAUSEA, CONFUSION, UNCONSCIOUSNESS, OR COMA. SKIN OR EYE
CONTACT: PRIMARY IRRITATION.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:REPORTS HAVE ASSOCIATED REPEATED AND PROLONGED
OCCUPATIONAL OVEREXPOSURE TO SOLVENTS WITH PERMANENT BRAIN AND
NERVOUS SYSTEM DAMAGE.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
* First Aid Measures *
First Aid:INHAL: REMOVE FROM EXPOSURE, RESTORE BREATHING, KEEP WARM AND
QUIET, NOTIFY MD. EYES: FLUSH IMMEDIATELY WITH RUNNING WATER FOR AT
CREAM. NOTIFY MD IN ALL CASES. INGEST: CALL MD IMMEDIATELY .
* Fire Fighting Measures *
Flash Point Method:PMCC
Lower Limits:0.9%
Extinguishing Media:FOAM, "ALCOHOL" FOAM, CO2, DRY CHEMICAL.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP
. DURING EMER CNDTNS OVEREXP TO DECOMP PRODS MAY CAUSE HLTH HAZ.
SYMPS MAY NOT BE IMMED APPARENT.(SUPP DATA)
Unusual Fire/Explosion Hazard:KEEP CNTNRS TIGHTLY CLSD. ISOLATE FROM
HEAT, ELEC EQUIP, SPKS & OPEN FLAME. HEAT MAY CAUSE PRESS BUILD-UP
IN CLOSED CONTAINERS, WATER MAY BE USED TO COOL.
* Accidental Release Measures *
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION. VENTILATE AND
REMOVE WITH INERT ABSORBENT.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:DOL STORAGE CATEGORY - 2. CONTENTS ARE
COMBUSTIBLE, KEEP AWAY FROM HEAT & OPEN FLAME. USE ONLY WITH
ADEQUATE VENTILATION.
Other Precautions:AVOID BREATHING VAPOR & SPRAY MIST. AVOID CONT W/SKIN
& EYES. KEEP CNTNR CLSD WHEN NOT IN USE. DO NOT TRANSFER CONTENTS
TO OTHER CNTNRS FOR STORAGE. DO NOT TAKE INTERNALLY. KEEP OUT OF
REACH OF CHILDR EN.
* Physical/Chemical Properties *
HCC:F4
Vapor Pres:SEE ING
Vapor Density:HVR/AIR
Spec Gravity:1.5
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
NONE REASONABLY FORESEEABLE.
Stability Condition to Avoid:HIGH TEMPERATURES, OPEN FLAME.
Hazardous Decomposition Products:BY FIRE: CO, CO2.
* Disposal Considerations *
Waste Disposal Methods:INCINERATE IN APPROVED FACILITY. DO NOT
INCINERATE CLOSED CONTAINERS. DISPOSE OF I/A/W FEDERAL, STATE AND
LOCAL REGULATIONS REGARDING POLLUTION.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:AVOID BREATHING VAPOR AND/OR MIST. USE WITH
ADEQUATE VENTILATION. IF VENTILATION IS INADEQUATE, USE NIOSH/MSHA
CERTIFIED RESPIRATOR WHICH WILL PROTECT AGAINST ORGANIC VAPOR/MIST.
Ventilation:LOCAL EXHAUST AND MECHANICAL (GENERAL) VENTILATION TO
MAINTAIN EXPOSURE LEVELS.
Other Protective Equipment:PROTECTIVE CLOTHING AS REQUIRED TO AVOID
SKIN CONTACT. AN EMERGENCY EYE WASH STATION AND SHOWER SHOULD BE
AVAILABLE.
Work Hygienic Practices:WASH WITH SOAP AND WATER AFTER HANDLING PRODUCT
AND BEFORE EATING DRINKING OR SMOKING.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
* Product Identification *
Product ID:JET FUEL JP-4
Preparer's Name:G. I. BRESNICK
* Composition/Information on Ingredients *
Ingred Name:PETROLEUM NAPHTHA
Other REC Limits:NONE RECOMMENDED
Ingred Name:PETROLEUM DISTILLATE
Other REC Limits:NONE RECOMMENDED
Ingred Name:BENZENE (SARA III)
Fraction by Wt: 4%
Other REC Limits:NONE RECOMMENDED
Ingred Name:ETHYL BENZENE (SARA III)
Fraction by Wt: 2%
Other REC Limits:NONE RECOMMENDED
Ingred Name:TOLUENE (SARA III)
Other REC Limits:NONE RECOMMENDED
Ingred Name:CYCLOHEXANE (SARA III)
Fraction by Wt: 5%
Other REC Limits:NONE RECOMMENDED
Ingred Name:XYLENES (O-,M-,P- ISOMERS)(SARA III)
Other REC Limits:NONE RECOMMENDED
Ingred Name:METHYL TERT-BUTYL ETHER (SARA III)
Fraction by Wt: 7%
Other REC Limits:NONE RECOMMENDED
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:MAY BE MILDLY IRRITATING TO THE EYES.
PROLONGED OR REPEATED CONTACT MAY CAUSE DERMATITIS. VAPORS MAY
IRRITATE THE NOSE, THROAT AND UPPER RESPIRATORY TRACTAND CAUSE
CENTRAL NERVOUS SYSTEM DEPRESSION. A SPIRATION HAZARD.
LISTED BY NTP AND IARC AND REGULATED BY OSHA AS A CARCINOGEN.
Effects of Overexposure:EYE IRRITATION, SKIN IRRITATION, DERMATITIS,
UPPER RESPIRATORY TRACT IRRITATION, NAUSEA, VOMITING, DIARRHEA,
HEADACHES, DIZZINESS, DROWSINESS.
Medical Cond Aggravated by Exposure:PRE-EXISTING SKIN AND/OR
RESPIRATORY DISORDERS MAY BE AGGRAVATED BY EXPOSURE TO THIS
PRODUCT.
* First Aid Measures *
OPEN. GET MEDICAL ATTENTION. SKIN: REMOVE CONTAMINATED CLOTHING.
WASH WITH SOAP AND WATER. IF IRRITATION PERSISTS, GET MEDICAL
ATTENTION. IN HALATION: REMOVE TO FRESH AIR. RESTORE BREATHING. GET
MEDICAL ATTENTION. INGESTION: DO NOT INDUCE VOMITING. GET MEDICAL
ATTENTION.
* Fire Fighting Measures *
Flash Point Method:CC
Lower Limits:1.3 %
Upper Limits:8 %
Extinguishing Media:AGENTS APPROVED FOR CLASS B HAZARDS (DRY CHEMICAL,
CARBON DIOXIDE, HALOGENATED AGENTS, FOAM, STEAM) AND WATER FOG.
Fire Fighting Procedures:FIRE FIGHTERS SHOULD USE NIOSH APPROVED SCBA &
FULL PROTECTIVE EQUIPMENT WHEN FIGHTING CHEMICAL FIRE. USE WATER
SPRAY TO COOL NEARBY CONTAINERS EXPOSED TO FIRE.
Unusual Fire/Explosion Hazard:DO NOT USE DIRECT STREAM OF WATER ON
FIRE. TOXIC GASES ARE RELEASED DURING COMBUSTION. VAPOR MAY EXPLODE
IF IGNITED IN ENCLOSED AREA.
* Accidental Release Measures *
Spill Release Procedures:ELIMINATE SOURCES OF IGNITION. EVACUATE AREA.
WEAR PROPER PERSONAL PROTECTIVE EQUIPMENT. CONTAIN SPILL. STOP LEAK
IF CAN DO SO WITHOUT RISK. ABSORB LIQUID WITH SUITABLE ABSORBENT
MATERIAL. COLLECT FOR DISPOSAL.
Neutralizing Agent:
*Handling and Storage *
Handling and Storage Precautions:STORE IN A FLAMMABLE LIQUIDS AREA.
STORE AWAY FROM HEAT, IGNITION SOURCES AND OPEN FLAMES IN
ACCORDANCE WITH APPLICABLE FEDERAL, STATE AND LOCAL RULES
Other Precautions:AVOID SKIN CONTACT. LAUNDER CONTAMINATED CLOTHING
BEFORE REUSE.
* Physical/Chemical Properties *
HCC:F2
Melt/Freeze Pt:M.P/F.P Text:NOT GIVEN
Vapor Pres:2-3 PSI
Vapor Density:NOT GIVEN
Evaporation Rate & Reference:NOT GIVEN
Solubility in Water:NEGLIGIBLE
Appearance and Odor:COLORLESS LIQUID, FUEL OIL ODOR
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:HEAT, OPEN FLAME, SPARKS
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE,
UNIDENTIFIED ORGANIC COMPOUNDS.
* Disposal Considerations *
Waste Disposal Methods:PREVENT WASTE FROM CONTAMINATING SURROUNDING
ENVIRONMENT. DISCARD ANY PRODUCT, RESIDUE, DISPOSAL CONTAINER OR
LINER IN ACCORDANCE WITH ALL FEDERAL, STATE AND LOCAL REGULATIONS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:FULL FACEPIECE RESPIRATOR W/APPROPRIATE FILTER
PAD OR CARTRIDGE(S)
Ventilation:LOCAL EXHAUST & MECHANICAL
Other Protective Equipment:LONG SLEEVE, LOOSE FITTING CLOTHING &
BARRIER CREAM.
Supplemental Safety and Health
* Product Identification *
Product ID:T-BAR MODULE C
* Composition/Information on Ingredients *
Ingred Name:ALUMINUM SILICATE (AS NUISANCE DUST OR PARTICULATES NOT
OTHERWISE REGULATED)
* Hazards Identification *
Effects of Overexposure:INHALATION, INGESTION AND SKIN IRRITATION.
* First Aid Measures *
First Aid:TERMINATE EXPOSURE.
* Fire Fighting Measures *
Fire Fighting Procedures:N/K _
*Handling and Storage *
Handling and Storage Precautions:REMOVAL OF THIS PRODUCT AFTER USE MAY
RESULT IN THE GENERATION OF DUST.
Other Precautions:REPEATED INHALATION OF RESPIRABLE FREE CRYSTALLINE
SILICA MAY CAUSE DELAYED LUNG INJURY (SILICOSIS).
* Physical/Chemical Properties *
Boiling Pt:B.P. Text:N/
Solubility in Water:INSOLUBLE
Appearance and Odor:WOOL-LIKE FIBROUS MATERIAL. NO ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
* Disposal Considerations *
Waste Disposal Methods:ROUTINE HOUSEKEEPING
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:WEAR APPROPRIATE, PROPERLY FITTED-NIOSH/MSHA
APPROVED RESPIRATOR IF LEVELS ARE ABOVE APPLICABLE LIMITS.
Ventilation:ADEQUATE
Supplemental Safety and Health
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:PROPYLENEGLYCOL MONOMETHYL ETHER ACETATE,
1-METHOXY-2-PROPANOL ACETATE
Fraction by Wt: 4%
Ingred Name:CELLOSOLVE ACETATE (ETHYLENE GLYCOL ETHYL ETHER ACETATE),
2-ETHOXYETHYL ACETATE
ACGIH TLV:5 PPM SKIN
Fraction by Wt: 2%
Fraction by Wt: 1%
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES: CAN CAUSE SEVERE IRRITATION.
SKIN: CAN CAUSE MODERATE IRRITATION & DERMATITIS. INHALATION: CAN
CAUSE NASAL & RESPIRATORY IRRITATION & ASPHYXIATION. INGESTION:
HARMFUL, CAN CAUSE BURNING SENSATIO N.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, TEARING, REDDENING, BLURRED,
SWELLING, SCALING, BLISTERING, DIZZINESS, WEAKNESS, FATIGUE,
NAUSEA, HEADACHE, UNCONSCIOUSNESS, SENSATION, VOMITING, DIARRHEA.
* First Aid Measures *
First Aid:SKIN: WASH THOROUGHLY W/SOAP & WATER. EYES: FLUSH W/LARGE
INHALATION: REMOVE TO FRESH AIR. IF BREATHING HAS STOPPED, GIVE
CPR. IF BREATH ING IS DIFFICULT, GIVE OXYGEN. OBTAIN MEDICAL
ATTENTION IN ALL CASES.
* Fire Fighting Measures *
Flash Point Method:TCC
Lower Limits:1.2
Upper Limits:7
Extinguishing Media:DRY CHEMICAL, FOAM.
Fire Fighting Procedures:KEEP AWAY FROM ALL IGNITION SOURCES. USE FULL
PROTECTIVE CLOTHING INCLUDING SCBA.
Unusual Fire/Explosion Hazard:CLOSED CONTAINERS MAY EXPLODE WHEN
EXPOSED TO EXTREME HEAT. VAPORS MAY IGNITE EXPLOSIVELY. VAPORS MAY
SPREAD LONG DISTANCES & BEYOND CLOSED DOORS. (SUPP)
* Accidental Release Measures *
Spill Release Procedures:SMALL: ABSORB ON INERT MATERIAL SUCH AS PAPER,
VERMICULITE, FLOOR ABSORBENT & TRANSFER TO HOOD. LARGE ELIMINATE
ALL IGNIOTN SOURCES. CONTAIN AREA TO PREVENT SPREADING. PUMP LIQUID
TO SALVAGE TANK. ABS ORB REMAINING LIQUID W/INERT MATERIAL.
*Handling and Storage *
Handling and Storage Precautions:KEEP CLOSURE TIGHT & UPRIGHT TO
PREVENT LEAKAGE. KEEP CLOSED WHEN NOT IN USE. DON'T STORE ABOVE
* Physical/Chemical Properties *
Vapor Density:>1
Evaporation Rate & Reference:SLOWER THAN ETHER
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
OXIDIZING MATERIALS.
Stability Condition to Avoid:EXCESS HEAT.
Hazardous Decomposition Products:CO, CO2, OXIDES OF NITROGEN.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF IAW/FEDERAL, STATE & LOCAL
REGULATIONS. ALLOW VOLATILE PORTION TO EVAPORATE IN HOOD BEING SURE
TO ALLOW SUFFICIENT TIME FOR VAPORS TO COMPLETELY CLEAR HOOD DUCT
WORK. DON'T INCINERATE.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NIOSH/MSHA APPROVED DUST AND FUME, RESPIRATOR
SHOULD BE USED TO AVOID EXCESSIVE INHALATION OF PARTICULATES WHEN
EXPOSURE EXCEEDS TLV'S.
Ventilation:LOC EXHAUST VENT SHOULD BE UTILIZED WHEN WELD/BURN/SAW/
BRAZING, GRINDING, OR MACHINING WHEN EXPOS EXCEEDS TLV'S.
Other Protective Equipment:OTHER PROTECTIVE EQUIPMENT.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
HNDLG/STOR PREC: BE A SOURCE OF IGNITION FOR COMBUSTIBLE AND FLAMMABLE
MATERIALS.
* Product Identification *
Product ID:NICKEL BASED ALLOY STEEL, NICKEL 2XX
* Composition/Information on Ingredients *
Ingred Name:CHROMIUM
Fraction by Wt: <2%
OSHA PEL:1 MG/M3
ACGIH TLV:0.5 MG/M3
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:MANGANESE. TLV: 5 MG/M3 DUST; 1 MG/M3 FUME.
Fraction by Wt: <5%
OSHA PEL:(C) 5 MG/M3 DUST
Ingred Name:NICKEL
OSHA PEL:1 MG/M3
ACGIH TLV:1 MG/M3
Ingred Name:TITANIUM
Fraction by Wt: <5%
Ingred Name:TUNGSTEN
Fraction by Wt: <5%
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:SHORT TERM EXPOS TO FUMES/DUST MAY
PRDCE IRRIT OF EYES/RESP SYS. INHAL OF HIGH CONC OF FRESHLY FORMED
OXIDE FUMES OF IRON, MANGANESE & COPPER MAY CAUSE METAL FUME FEVER
CHARACTERIZED BY METALLIC TASTE IN MOUTH, DRYNESS & IRRIT OF
THROAT & INFLUENZALIKE SYMP. CHRONIC INHAL OF HIGH CONC OF IRON
OXIDE(SEE EFTS OF OVEREXP)
Explanation of Carcinogenicity:NICKEL IARC -2B,NTP 2
Effects of Overexposure:HLTH HAZ:FUMES/DUST MAY LEAD TO BENIGN
PNEUM(SIDEROSIS). INHAL OF HIGH CONC OF FERRIC OXIDE MAY POSS
ENHANCE RISK OF LUNG CANCER DEVELOPMENT IN WORK EXPOS TO PULM
CARCIN. EXPOS TO HIGH CONC OF DUST/FU MES CAN CAUSE SENSIT, DERM,
INFLAMMATION &/OR ULCERATION OF UPPER RESP TRACT & POSS CANCER OF
NASAL PASSAGES & LUNGS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
* First Aid Measures *
First Aid:INHAL: REMOVE TO FRESH AIR, SEEK MED AID IMMED. EYES: FLUSH
WATER. CALL MD . INGEST: CALL MD IMMED .
* Fire Fighting Measures *
Extinguishing Media:MEDIA SUITABLE FOR SURROUNDING FIRE .
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT . STEEL PRODUCTS IN SOLID STATE PRESENT NO
FIRE OR EXPLOSION HAZARD.
* Accidental Release Measures *
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:IN WELD, PREC SHOULD BE TAKEN FOR
AIRBORNE CONTAM WHICH MAY ORIGINATE FROM COMPONENTS OF WELDING ROD.
ARC/SPRAY GENERATED WHEN WELD/BURN COULD(SUPDAT)
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
* Physical/Chemical Properties *
HCC:N1
Spec Gravity:7
Appearance and Odor:GRAY-BLACK, ODORLESS.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
REACTS WITH STRONG ACIDS TO PRODUCE HYDROGEN GAS.
Hazardous Decomposition Products:METALLIC DUST OR FUMES MAY BE PRODUCED
DURING WELDING, BURNING, GRINDING AND POSSIBLY MACHINING. REFER TO
* Disposal Considerations *
Waste Disposal Methods:ACCORDING TO LOCAL, STATE AND FEDERAL
REGULATIONS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:U.S.B.M.APPRV. SELF-CONTAIN. BRTH APPARAT; IF <
3% USE CANISTER-MASK
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:AMMONIUM HYDROXIDE(SARA III)
* Hazards Identification *
Effects of Overexposure:EYES:CAUSES SEVERE DAMAGE;SKIN:LIQUID
BURNS;VAPOR IRRITATES
* First Aid Measures *
First Aid:SKIN:WASH IMMEDIATELY W/WATER.CALL PHYSICIAL.; EYE:FLUSH
IMMED. W/WATER.CALL DR. INHAL: MOVE FROM EXPOSURE.
* Fire Fighting Measures *
Flash Point:NONE
Extinguishing Media:WATER FOG
Fire Fighting Procedures:NONE
* Accidental Release Measures *
Spill Release Procedures:FLUSH W/LARGE QUANTITIES OF COLD WATER.KEEP
VAPOR TO MINIMIUM WITH WATER FOG. DONT DISCHARGE THIS SOLUTION INTO
SEWERS,CONFINED DRAINS OR SURFACE WATERS.
*Handling and Storage *
Handling and Storage Precautions:KEEP AWAY FROM HEAT,SUN, & STRONG
ACIDS.CORRODES COPPER, ALUMINUM, & GALVANIZED SURFACES.
Other Precautions:USE PROPER PROTECT.EQUIP.
Other Protective Equipment:NONE
Supplemental Safety and Health
* Physical/Chemical Properties *
HCC:B1
Vapor Pres:9.0
Vapor Density:< 1.
Appearance and Odor:COLORLESS LIQUID; STRONG PUNGENT ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
MERCURY,COPPER & ITS ALLOYS,ACID, ALUMINUM ALLOYS,GALVANIZE
Stability Condition to Avoid:HEATING LIQ. TO FORM EXPLOSVIE NH*3 VAPORS
IN AIR
Hazardous Decomposition Products:AMMONIA VAPORS
* Disposal Considerations *
Waste Disposal Methods:OBSERVE FEDERAL,STATE, OR LOCAL DISPOSAL
REGULATIONS.
| 1 | eyes_protection_mandatory |
Control Measures
*
*
Contractor Summary
*
*
Ingredients
*
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
-----------------------------
------------------------------
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
------------------------------
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
-----------------------------
DISPOSAL.
-----------------------------
EXPLO VAPS. KEEP AWAY FROM HEAT, SPARKS &
-----------------------------
ALL HAZ PREC GIVEN IN THIS MSDS UNTIL
-----------------------------
AVOID SPONT COMBUST OF SOILED RAGS,
-----------------------------
W/THIS PROD BY IMMED IMMERSING THEN IN A
-----------------------------
-----------------------------
-----------------------------
REUSE.
*
Health Hazards Data
*
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: YES
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: ACUTE: INHAL: SOLV VAP/MIST CAN CAUSE DIZZ, BRTHG DFCLTY,
HDCH, IRRIT TO NOSE & THROAT, LOSS OF COORD. CONTINUED OVEREXP CAN LEAD
TO CNS DEPRESS. EYES: LIQ/VAP CAN CAUSE IRRIT, TEARING, DISCOMFORT, RE DNESS
& BLURRED VISION. SKIN CONT: CAN CAUSE IRRIT. CAN CAUSE DEFAT WHICH CAN
LEAD TO DERM. (EFTS OF OVEREXP)
Explanation Of Carcinogenicity: NOT RELEVANT.
Signs And Symptions Of Overexposure: HLTH HAZ: SKIN ABSORPTION: CAN CAUSE
IRRIT, DEFAT & DERM. INGEST: CAN CAUSE MOUTH, THROAT, ESOPHAGUS &
STOM IRRIT, NAUS, VOMIT & DIARR. CHRONIC: RPTS HAVE ASSOC RPTD &
PRLNG OCCUP OVEREXP TO SOLVS W/P ERM BRAIN & NERV SYS DMG. INTENTIONAL
MISUSE BY DELIB CONCENTRATING & INHALING CONTENTS MAY BE HARMFUL/FATAL.
Medical Cond Aggravated By Exposure: PREEXISTING EYE, SKIN, LIVER, KIDNEY AND
RESPIRATORY DISORDERS.
First Aid: INHALATION: MOVE TO FRESH AIR. IF BREATHING STOPS, APPLY ARTIFICIAL
RESPIRATION AND SEEK MEDICAL ATTENTION. EYES: FLUSH IMMEDIATELY WITH LARGE
WASH THOROUGHLY WITH SOAP AND WATER WHILE REMOVING CONTAMINATED CLOTHING AND
SHOES. INGESTION: DO NOT INDUCE VOMITING! CONTACT MD OR LOCAL POISON CONTROL
CENTER IMMEDIATELY.
*
Handling and Disposal
*
Spill Release Procedures: ELIMINATE ALL SOURCES OF IGNITION (FLAMES, HOT
SURFACES, AND ELECTRICAL, STATIC, OR FRICTIONAL SPARKS). AVOID BREATHING
VAPORS. VENTILATE AREA. CONTAIN AND REMOVE WITH INERT ABSORBENT AND
NON-SPARKINGTOOLS. KEEP OUT OF SEWERS.
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: COLLECT ABSORBENTS/SPILLED LIQUID INTO METAL
CONTAINERS. DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE AND FEDERAL
REGULATIONS. DO NOT INCINERATE CLOSED CONTAINERS. INCINERATE IN APPROVED
FACILITY. OBEY RELEVANT LAWS.
Handling And Storage Precautions: KEEP AWAY FROM EXCESS HEAT, SPKS/OPEN FLAMES.
KEEP CONTRS CLOSED WHEN NOT IN USE. STORE IN A COOL, WELL-VENTILATED APPRVD
AREAS. AVOID EYE CONT.
Other Precautions: AVOID FREE FALL OF LIQ IN EXCESS OF A FEW INCHES &
GROUND CONTR WHEN POURING. USE NON-SPKG UTENSILS WHEN HNDLG. KEEP CONTRS CLSD
& UPRIGHT WHEN NOT IN USE. DO NOT TAKE INTERNALLY. STORE LGE QTYS IN BL
DGS DESIGNED TO COMPLY WITH
*
Fire and Explosion Hazard Information
*
Flash Point Method: TCC
Lower Limits: 1%
Upper Limits: 6%
Extinguishing Media: FOAM, CARBON DIOXIDE, DRY CHEMICAL.
Fire Fighting Procedures: WEAR NIOSH APPRVD SCBA & FULL PROT EQUIP (FP N).
WATER SPRAY MAY BE INEFFECTIVE. WATER MAY BE USED TO COOL CLSD CONTRS TO PVNT
PRESS BUILD-UP & POSS (SUP DAT)
Unusual Fire/Explosion Hazard: HANDLE AS IGNITABLE LIQ. KEEP CONTRS TIGHTLY
CLSD & ISOLATE FROM HEAT, ELEC EQUIP, SPKS/FLAME. VAPS FORM EXPLO MIXT IN
AIR BETWEEN UPPER & LOWER LIMS. (SUP DAT)
*
*
Respiratory Protection: DO NOT BREATHE VAPS/SPRAY MIST. WEAR APPROP, PROPERLY
FITTED RESP (NIOSH APPRVD) DURING USE UNTIL VAP & MISTS ARE EXHAUSTED,
UNLESS AIR MONITORING DEMONSTRATES VAP & MIST LEVELS ARE BELOW APPLIC
Ventilation: PROVIDE GENERAL CLEAN AIR DILUTION/LOCAL EXHAUST VENTILATION IN
VOLUME & PATTERN TO KEEP AIR CONTAMINANT
Other Protective Equipment: ANSI APPROVED EMERGENCY EYEWASH AND DELUGE SHOWER
(FP N). USE OF PROTECTIVE CREAMS, HEAD CAPS, ETC, IS RECOMMENDED.
Work Hygienic Practices: WASH HANDS BEFORE EATING OR USING WASHROOM, SMOKE IN
SMOKING AREAS ONLY. AVOID CONTACT W/CONTAMINATED CLOTHING.
Supplemental Safety and Health: FIRE FIGHT PROC: AUTO-IGNIT/EXPLO FROM HEATING.
EXPLO HAZ: NEVER USE WELDING/CUTTING TORCH ON/NEAR DRUM (EVEN EMPTY) BECAUSE
PROT (EVEN JUST RESIDUE) CAN IGNITE EXPLO. AVOID SPONT COMBUST OF SOILED RA
GS, STEEL WOOL, SPRAY BOOTH FILTERS, SPRAY RESIDUES & OTHER WASTE MATL
CONTAM W/THIS PROD BY IMMED IMMERSING
*
Physical/Chemical Properties
*
Vapor Density: LTR/AIR
Evaporation Rate & Reference: SLOWER THAN ETHER
Solubility in Water: NEGLIGIBLE
Appearance and Odor: LIQUID WITH ALIPHATIC ODOR
*
Reactivity Data
*
Stability Indicator: YES
Stability Condition To Avoid: EXCESSIVE HEAT, ALL POSSIBLE SOURCES OF IGNITION,
POOR VENTILATION, CORROSIVE ATMOSPHERES, EXCESSIVE AGING.
Materials To Avoid: ALKALINE MATERIALS, STRONG ACIDS AND OXIDIZING MATERIALS.
IF THIS PRODUCT IS NOT WATER-REDUCIBLE, AVOID WATER.
Hazardous Decomposition Products: THERMAL DECOMPOSITION OR COMBUSTION CAN
PRODUCE FUMES CONTAINING ORGANIC ACIDS, CARBON DIOXIDE AND CARBON MONOXIDE.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT.
*
Toxicological Information
*
*
Ecological Information
*
*
*
*
Regulatory Information
*
*
Other Information
*
*
HAZCOM Label
*
Assigned IND: Y
Company Name: HILLYARD INDUSTRIES
Label Required IND: Y
Status Code: C
Origination
Chronic Hazard IND: Y
Skin Protection IND: YES
Signal Word: WARNING
Respiratory Protection IND: YES
Health Hazard: Moderate
Contact Hazard: Moderate
Fire Hazard: Moderate
Reactivity Hazard: None
Hazard And Precautions: COMBUSTIBLE. ACUTE: INHALATION: CAN CAUSE DIZZINESS,
BREATHING DIFFICULTY, HEADACHE, IRRITATION TO NOSE AND THROAT, LOSS OF
COORDINATION. CAN LEAD TO CENTRAL NERVOUS SYSTEM DEPRESSION. EYES: CAN CAUSE
IRRITATION, TEARING, DISCOMFORT, REDNESS AND BLURRED VISION. SKIN CONTACT:
CAN CAUSE IRRITATION. CAN CAUSE DEFATTING WHICH CAN LEAD TO DERMATITIS. SKIN
ABSORPTION: CAN CAUSE IRRITATION, DEFATTING AND DERMATITIS. INGESTION:
MOUTH, THROAT, ESOPHAGUS AND STOMACH IRRITATION, NAUSEA, VOMITING AND
DIARRHEA. CHRONIC: MAY CAUSE PERMANENT BRAIN AND NERVOUS SYSTEM DAMAGE.
MISUSE MAY BE HARMFUL OR FATAL.
*
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:USE AIR PURIFYING OR FRESH AIR-SUPPLIED
RESPIRATOR.
Ventilation:SUFFICIENT TO KEEP AIRBOURNE CONCENTRATIONS BELOW TLV'S.
Other Protective Equipment:LONG SLEEVED/LEGGED CLOTHING.
Work Hygienic Practices:WASH HANDS BEFORE EATING/SMOKING/USING
WASHROOM. SMOKE IN SMOKING AREAS ONLY.
Supplemental Safety and Health
NK
* Product Identification *
Kit Part:Y
* Composition/Information on Ingredients *
Other REC Limits:NONE RECOMMENDED
Other REC Limits:NONE RECOMMENDED
Other REC Limits:NONE RECOMMENDED
Fraction by Wt: NA
Other REC Limits:NONE RECOMMENDED
OSHA PEL:NOT RELEVANT
ACGIH TLV:NOT RELEVANT
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: RESP TRACT IRRITATION. NS
DEPRESSION (HEADACHE/DIZZINESS/STAGGERING
GAIT/CONFUSION/UNCONSCIOUSNESS/COMA). SKIN:
IRRIT/SWELLING/REDNESS/RASH. EYE:
IRRIT/TEARING/REDNESS/SWELLING/STINGING SE NSATION. SKIN
ABSORPTION: MOD IRRIT/DRYING/DEFATTING/CRACKING. INGEST:
IRRIT/CORROSIVE TO MOUTH/STOMACH/DIGESTIVE TRACT*
Effects of Overexposure:*VOMITING (CHEMICAL PNEUMONITIS). ACUTE: VAPORS
IRRITATE EYES/NOSE/THROAT. INHAL: HEADACHE/TROUBLE
BREATHING/UNCONSCIOUSNESS. CHRONIC: DRYING/CRACKING OF SKIN DUE TO
DEFATTING. SKIN SENSITIZATION/ASTH MA/OTHER ALLERGIC RESPONSE.
POTENTIAL KIDNEY/LIVER DAMAGE.
Medical Cond Aggravated by Exposure:ASTHMA & ANY OTHER RESPIRATORY
DISORDER. SKIN ALLERGIES, EXEMA, DERMATITIS.
* First Aid Measures *
First Aid:INHALATION: MOVE TO FRESH AIR. RESTORE BREATHING. GET MEDICAL
AID. SKIN: REMOVE CONTAM CLOTHES/WASH BEFORE REUSE. WASH THOROUGHLY
MI N/LIFT LIDS. GET MEDICAL AID. INGEST: DON'T INDUCE VOMITING.
NEVER FIVE ANYTHING BY MOUTH TO UNCONSCIOUS PERSON. GET MEDICAL
AID.
* Fire Fighting Measures *
Flash Point Method:TCC
Lower Limits:1.0
Upper Limits:9.8
Extinguishing Media:FOAM, ALCOHOL FOAM, CO2, DRY CHEMICAL, WATER FOG.
Fire Fighting Procedures:WEAR SCBA W/FULL PROTECTIVE CLOTHING. USE
WATER TO COOL CLOSED CONTAINERS PREVENT PRESSURE
BUILD-UP/AUTOIGNIT/EXPLOSION.
Unusual Fire/Explosion Hazard:CLOSED CONTAINERS MAY EXPLODE WHEN
EXPOSED TO EXTREME HEAT. APPLICATION TO HOT SURFACE REQUIRES
SPECIAL PRECAUTIONS. DECOMP PRODUCTS MAY CAUSE HEALTH HAZARD.
* Accidental Release Measures *
Spill Release Procedures:EVACUATE. REMOVE IGNIT SOURCES. VENTILATE.
CONTAIN/REMOVE W/INERT ABSORBENT & NONSPARKING TOOLS.
*Handling and Storage *
Handling and Storage Precautions:IN BUILDINGS THAT COMPLY W/OSHA
CONTAINERS IN WELL-VENTILATED AREA.
Other Precautions:KEEP CONTAINERS TIGHT/UPRIGHT/PREVENT LEAKAGE. READ
SAFETY PRECAUTIONS.
* Physical/Chemical Properties *
Vapor Density:>AIR
pH:NA
Viscosity:*
Evaporation Rate & Reference:1.1 (BUAC=1)
Solubility in Water:INSOLUBLE
Appearance and Odor:RED LIQUID, SOLVENT ODOR
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
OXIDIZING MATERIALS, STRONG ACIDS, EPOXY RESINS UNDER UNCONTROLLED
CONDITIONS.
Stability Condition to Avoid:HIGH TEMPERATURES & EPOXY RESINS UNDER
UNCONTROLLED CONDITIONS.
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE,
OXIDES OF NITROGEN.
* Disposal Considerations *
Waste Disposal Methods:ACCORDING TO FEDERAL, STATE, LOCAL ENVIRONMENTAL
CONTROL REGULATIONS. HANDLE CONTAINERS W/CARE (RESIDUE/FLAMMABLE
VAPORS). DON'T INCINERATE CLOSED CONTAINERS. EPA HAZARDOUS WASTE
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NOT REQUIRED IF PROPERLY DILUTED.
* Product Identification *
Product ID:SHOWER, TUB & TILE (HARD WATER/SCUM REMOVER)
Preparer's Name:ALI ABYANE
CAGE:0PWJ2
CAGE:0PWJ2
* Composition/Information on Ingredients *
Ingred Name:GLYCOLIC ACID
Other REC Limits:NONE RECOMMENDED
OSHA PEL:NOT EST.
ACGIH TLV:NOT EST.
Ingred Name:VOC = 4%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:NOT EST.
ACGIH TLV:NOT EST.
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES: IRRIT. DAMAGE W/BRIEF CONTACT
LIQUIDS/MISTS. POS PERM INJURY W/EXTENDED CONTACT. SKIN: IRRIT BY
VAPORS. VAPOR/LIQ/MISTS CORROSIVE. INHAL: IRRIT/BURNS W/EXTENDED
CONTACT. INGEST: BURNS TISSUES. C HRONIC-SKIN: ALLERGIC REACTIONS
W/OVEREXPOSURE.
Effects of Overexposure:INGEST: ABDOMINAL PAIN, NAUSEA, VOMITING. EYES:
STINGING, WATERING.
Medical Cond Aggravated by Exposure:INHALATION/INGESTION: POSSIBLE
AGGRAVATION OF PREEXISTING LUNG DISEASE.
* First Aid Measures *
MINUTES. CALL DR. SKIN: WASH W/SOAP & WATER. INHALATION: IF
DISCOMFORT, GET FRESH AIR. IF BREATHING DIFFICULT, IMMEDIATELY GET
MEDICAL AID. IN GESTION: GET PLENTY WATER. DO NOT INDUCE VOMITING.
WASH OUT MOUTH AREA. CALL DR.
* Fire Fighting Measures *
Extinguishing Media:WATER SPRAY, FOAM, CO2, DRY CHEMICAL.
Fire Fighting Procedures:POSITIVE PRESSURE SCBA W/FULL FACEPIECE FOR
FIREFIGHTERS.
Unusual Fire/Explosion Hazard:USE WATER FOG/SPRAY TO COOL/LOWER
PRESSURE OF FIRE-EXPOSED CONTAINERS, TO FLUSH VAPORS AWAY.
* Accidental Release Measures *
SAFE. DIKE/CONTAIN. TRANSFER LIQ TO PLASTIC DRUMS/CONTAINERS FOR
RECOVERY/DISPOSAL.
*Handling and Storage *
Handling and Storage Precautions:KEEP AWAY FROM CHILDREN. DO NOT GET
IN/ON EYES, SKIN, CLOTHES. DO NOT TAKE INTERNALLY.
Other Protective Equipment:*ESPECIALLY W/CONCENTRATE.
Supplemental Safety and Health
NK
* Physical/Chemical Properties *
HCC:C2
Vapor Density:>1
pH:1-2
Evaporation Rate & Reference:<1
Appearance and Odor:CLEAR LIQUID, CHERRY ODOR
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS/ALKALIES, EXTENDED EXPOSURE TO UNPAINTED METALS.
Stability Condition to Avoid:HEAT.
Hazardous Decomposition Products:CARBON OXIDES.
* Disposal Considerations *
Waste Disposal Methods:IN ACCORDANCE W/FEDERAL, STATE, LOCAL
REGULATIONS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NONE REQUIRED WHERE ADEQUATE VENTILATION
CONDITIONS EXIST. WEAR APPROPRIATE NIOSH APPROVED DUST RESPIRATOR
IF AIRBORNE DUST CONCENTRATION IS HIGH.
Ventilation:GENERAL/LOCAL EXHAUST: ADEQUATE TO KEEP FUME & DUST LEVELS
AS LOW AS POSSIBLE.
Other Protective Equipment:FULL COVER CLOTHING.
Work Hygienic Practices:WASH THOROUGHLY W/COLD WATER AFTER HANDLING.
Supplemental Safety and Health
PRODUCT IS A BLENDED MIX OF TWO SEPARATE COMPONENTS. EACH BUFFER
CONTAINS SAME COMPONENTS, BUT IN DIFFERENT RATIOS. OMEGA BUFFERS
ARE MANUFACTURED & FORMULATED FOR LABORATORY USE ONLY & REQUIRE NO
SPE CIAL HANDLING, LABELLING/MARKINGS.
* Product Identification *
Kit Part:Y
* Composition/Information on Ingredients *
* Hazards Identification *
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:PROLONGED SKIN CONTACT W/BULK POWDER
COULD CAUSE IRRITATION/ALLERGIC REACTION.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION.
* First Aid Measures *
First Aid:EYES: THOROUGHLY FLUSH W/COLD WATER. SKIN: WASH W/SOAP & COLD
WATER. INHALATION: REMOVE TO FRESH AIR. INGESTION: IF CONSCIOUS
INDUCE VOMITING. OBTAIN MEDICAL ATTENTION IN ALL CASES.
* Fire Fighting Measures *
Flash Point:NON-FLAMMABLE
Extinguishing Media:USE ANY SUITABLE MEDIA FOR SURROUNDING FIRE.
Fire Fighting Procedures:NONE REQUIRED.
Unusual Fire/Explosion Hazard:NONE
* Accidental Release Measures *
Spill Release Procedures:SWEEP POWDER INTO CONTAINER. CLEAN AREA
W/WATER. PREPARED BUFFER SOLUTION: NEUTRALIZE & MOP AREA.
Neutralizing Agent:DILUTION W/COLD WATER.
*Handling and Storage *
Handling and Storage Precautions:STORE IN COOL, DRY PLACE W/CONTAINER
TIGHTLY CLOSED. PRODUCT IS HYGROSCOPIC. STORE AT CONTROLLED ROOM
TEMP IN DRY LOCATIONS.
Other Precautions:DON'T BREATHE DUST. DON'T GET IN EYES. AVOID
PROLONGED/REPEATED SKIN CONTACT. DON'T TAKE INTERNALLY.
* Physical/Chemical Properties *
Appearance and Odor:COLORLESS GRANULAR/CRYSTALLINE POWDER W/NO ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
NONE
Stability Condition to Avoid:MOISTURE.
Hazardous Decomposition Products:NONE
* Disposal Considerations *
Waste Disposal Methods:NEUTRALIZE BUFFER SOLUTIONS BEFORE DISPOSAL.
DISPOSE OF AT APPROVED SITE IAW/FEDERAL, STATE & LOCAL REGULATIONS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Ventilation:PROVIDE ADEQUATE VENTILATION.
Supplemental Safety and Health
* Product Identification *
Product ID:STEAMO STEAM MACHINE SHAMPOO
* Composition/Information on Ingredients *
Ingred Name:2-BUTOXYETHANOL
Fraction by Wt: 4%
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES/INHALATION: IRRITATION. SKIN:
IRRITATION & DEFATTING. INGESTION: RED BLOOD CELL HEMOLYSIS &
HARMFUL.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:EYES/INHALATION: IRRITATION. SKIN: IRRITATION &
DEFATTING. INGESTION: RED BLOOD CELL HEMOLYSIS & HARMFUL.
* First Aid Measures *
WASH W/SOAP & WATER. INHALATION: REMOVE TO FRESH AIR. INGESTION:
DRINK LARGE AMOUNTS OF WATER. DON'T INDUCE VOMITING. OBTAIN MEDICAL
ATTENTION IN ALL CASES.
* Fire Fighting Measures *
Extinguishing Media:WATER, CO2 & FOAM
Unusual Fire/Explosion Hazard:NON-FLAMMABLE
* Accidental Release Measures *
Spill Release Procedures:CLEAN-UP W/WATER.
*Handling and Storage *
Handling and Storage Precautions:KEEP CLOSURE UP TO PREVENT LEAKAGE.
* Physical/Chemical Properties *
Solubility in Water:COMPLETE
Appearance and Odor:BLUE LIQUID W/LEMON ODOR
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/LOCAL, STATE, &
FEDERAL REGULATIONS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:SCBA IF INVOLVED IN FIRE, OTHERWISE GAS MASK.
Ventilation:PROVIDE MECHAN(GEN/LOCAL EXHAUST)VENT TO MAINTN <TLV
Other Protective Equipment:EYE WASH STATION. APRONS. SPECIAL IMPERVIOUS
CLOTHING.
Supplemental Safety and Health
BY DGSC-STF.
* Product Identification *
* Composition/Information on Ingredients *
* Hazards Identification *
Effects of Overexposure:HAZ DEGREE DEPENDS ON TYPE/QUANT OF RADIATION.
LATENT EFFECTS:SOMATIC/GENETIC DAMAGE.
* First Aid Measures *
First Aid:USE FIRST AID. CALL MEDICAL EMERGENCY CARE. REMOVE/ISOLATE
COMTAMINATED CLOTHING.SHOWER VICTIM(S) W. SOAP & H*2O. DETAIN
PERSONNEL/EQUIPMENT EXPOSED. ADVISE MEDICAL PERSONNEL THAT
VICTIM(S) MAY BE CON TAMINATED.
* Fire Fighting Measures *
Extinguishing Media:EXTINQUISH W. AGENT SUITABLE FOR SURROUNDING FIRE.
Fire Fighting Procedures:WEAR CHEMICAL PROTECTIVE SUIT WITH SELF CONTD
BRTHG APP.
Unusual Fire/Explosion Hazard:SOME OF MATL MAY BURN. CONT MAY EXPLODE
IN HEAT OF FIRE.
* Accidental Release Measures *
*Handling and Storage *
Handling and Storage Precautions:SHIELD ACCORDING TO EMITTED RADIATION.
PROTECT FROM FILM/FILM PLATES. KEEP CONTAINERS CLOSED. STORE IN
AREA FOR RADIOACTIVE MATERIALS.
* Physical/Chemical Properties *
HCC:A3
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
ISOLATE,SEGREGATE FROM MOST OTHER TYPE MATERIAL
Hazardous Decomposition Products:DEPENDS ON CHEMICAL COMPOSITION;
FISSION PRODUCTS
* Disposal Considerations *
Waste Disposal Methods:CONTROLLED DISPOSAL REQUIRED-IN ACCORDANCE WITH
DOD REGULATIONS AND FEDERAL,STATE & LOCAL REGULATIONS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NONE REQUIRED WHERE ADEQUATE VENTILATION
CONDITIONS EXIST. IF AIRBORNE CONCENTRATION IS HIGH, USE AN
APPROPRIATE NIOSH/MSHA APPROVED RESPIRATOR OR DUST MASK.
Ventilation:USE ADEQUATE GENERAL OR LOCAL EXHAUST VENTILATION TO KEEP
FUME OR DUST LEVELS AS LOW AS POSSIBLE.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:FLUORESCEIN
OSHA PEL:N/K
ACGIH TLV:N/K
* Hazards Identification *
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: SKIN CONTACT:IRRITATION. EYE
CONTACT/ INHALATION/INGESTION:NONE IDENTIFIED.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE IDENTIFIED.
* First Aid Measures *
First Aid:INGEST:IF SWALLOWED & PERSON IS CONSCIOUS, IMMEDIATELY GIVE
LARGE AMOUNTS OF WATER. GET MEDICAL ATTENTION. INHAL:IF PERSON
BREATHES IN LARGE AMOUNTS, MOVE EXPOSED PERSON TO FRESH AIR. SKIN:
* Fire Fighting Measures *
Extinguishing Media:USE EXTINGUISHING MEDIA APPROPRIATE FOR SURROUNDING
FIRE.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE IDENTIFIED.
* Accidental Release Measures *
Spill Release Procedures:WEAR SUITABLE PROTECTIVE CLOTHING. CAREFULLY
SWEEP UP & REMOVE.
Neutralizing Agent:
*Handling and Storage *
Handling and Storage Precautions:KEEP CONTAINER TIGHTLY CLOSED.
SUITABLE FOR ANY GENERAL CHEMICAL STORAGE AREA.
Other Precautions:DURING USE AVOID CONTACT W/EYES, SKIN & CLOTHING.
* Physical/Chemical Properties *
HCC:N1
Solubility in Water:NEGLIGIBLE (<0.1%)
Appearance and Odor:ORANGE TO RED CRYSTALLINE POWDER.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:NONE DOCUMENTED.
Hazardous Decomposition Products:CARBON MONOXIDE & CARBON DIOXIDE.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/ALL APPLICABLE
FEDERAL, STATE & LOCAL ENVIRONMENTAL REGULATIONS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:ALWAYS USE A NIOSH-APPROVED RESPIRATOR WHEN
NECESSARY. FOLLOW OSHA RESPIRATOR REGULATIONS.
Ventilation:GOOD GENERAL VENTILATION SHOULD BE SUFFICIENT TO CONTROL
AIRBORNE LEVELS.
Other Protective Equipment:PROTECTIVE CLOTHING
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE. WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
PH IS FOR 5% SOLUTION.
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:SODIUM CITRATE
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES: MECHANICAL IRRITANT. SKIN: MAY
CAUSE IRRITATION. INGESTION: LARGE AMOUNTS MAY CAUSE
GASTROINTESTINAL IRRITATION. INHALATION: RESPIRATORY TRACT
IRRITANT. LOW HAZARD FOR USUAL INDUSTRIAL HANDLING.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION
* First Aid Measures *
ALERT, GIVE 2-4 CUPFULS OF MILK/WATER. NEVER GIVE ANYTHING BY MOUTH
IF UNCONSCIOU S. INHALATION: REMOVE TO FRESH AIR IMMEDIATELY. GIVE
CPR/OXYGEN IF NECESSARY. OBTAIN MEDICAL ATTENTION IN ALL CASES.
NOTES TO PHYSICIAN: TREAT SYMPTOMATICALLY & SUPPORTIVELY.
* Fire Fighting Measures *
Extinguishing Media:WATER SPRAY, DRY CHEMICAL, CO2/CHEMICAL FOAM
Fire Fighting Procedures:USE APPROPRIATE PROTECTIVE CLOTHING TO PREVENT
CONTACT W/SKIN & EYES. USE SELF CONTAINED BREATHING APPARATUS TO
PREVENT CONTACT W/THERMAL DECOMPOSITION PRODUCTS
Unusual Fire/Explosion Hazard:DUSTS AT SUFFICIENT CONCENTRATIONS CAN
FORM EXPLOSIVE MIXTURES W/AIR.
* Accidental Release Measures *
Spill Release Procedures:VACUUM/SWEEP UP MATERIAL & PLACE INTO A
SUITABLE DISPOSAL CONTAINER.
*Handling and Storage *
Handling and Storage Precautions:KEEP FROM CONTACT W/OXIDIZING
MATERIALS. USE W/ADEQUATE VENTILATION. WEAR APPROPRIATE PROTECTIVE
CLOTHING TO PREVENT SKIN EXPOSURE.
Other Precautions:AVOID CONTACT W/EYES, SKIN & CLOTHING. AVOID
INGESTION & INHALATION.
* Physical/Chemical Properties *
pH:7-9
Solubility in Water:COMPLETE
Appearance and Odor:WHITE CRYSTALLINE SOLID; ODORLESS
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS
Hazardous Decomposition Products:CO, CO2
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/LOCAL, STATE &
FEDERAL REGULATIONS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NIOSH APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN . NOT REQUIRED UNDER NORMAL USE.
Ventilation:NOE REQUIRED UNDER NORMAL USE.
Other Protective Equipment:EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET
ANSI DESIGN CRITERIA .
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
MATLS TO AVOID:COMPONENTS W/ACIDS, ALDEHYDES & CARBAMATE CMPDS. EYE
TO BE CARCIN. ANIMAL:LUNGS, NASAL CAVITIES. NICKEL HYDROXIDE :NTP
* Product Identification *
Product ID:TWICELL
* Composition/Information on Ingredients *
Ingred Name:EFTS OF OVEREXP:INSIDE BATTERY MAY RSLT IN SEV IRRIT & CHEM
Ingred Name:OTHER PREC:ELEVATION TO BATTERY AS WELL AS SHORTEN BATTERY
OR LEAKAGE OF CELL CONTENTS.
OSHA PEL:1 MG/M3
ACGIH TLV:1 MG/M3
OSHA PEL:1 MG/M3 (NI)
ACGIH TLV:0.1 MG/M3 (NI)
OSHA PEL:0.1 MG/M3
OSHA PEL:5 MG/M3 DUST, C
ACGIH TLV:5 MG/M3 DUST
Ingred Name:LANTHANUM
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:CERIUM, CRUDE; (CERIUM)
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:NEODYMIUM
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:POTASSIUM HYDROXIDE (CERCLA)
OSHA PEL:2 MG/M3, C
ACGIH TLV:2 MG/M3, C
Ingred Name:SODIUM HYDROXIDE (CERCLA)
OSHA PEL:2 MG/M3
ACGIH TLV:2 MG/M3, C
Ingred Name:LITHIUM HYDROXIDE
OSHA PEL:N/K
ACGIH TLV:N/K
ANIMAL:PULMONARY FIBROSIS (BLOOD EFFECTS).
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ACUTE:INHAL:DURING NORMAL USE INHAL IS
UNLIKELY RTE OF EXPOS DUE TO CONTAINMENT OF HAZ MATLS W/IN BATTERY
CASE. HOWEVER, SHOULD BATTERIES BE EXPOS TO EXTREME HEAT/PRESS
CAUSING BREACH IN BATTERY CELL CASE, EXPOS TO CONSTITUENTS MAY
OCCUR. INHAL OF COBALT DUSTS MAY RSLT IN PULM CNDTNS. INGEST:IF
BATTERY(EFTS OF OVEREXP)
Explanation of Carcinogenicity:NICKEL:IARC MONOGRAPHS ON EVAL OF CARCIN
RPT (SUPDAT)
Effects of Overexposure:HLTH HAZ:CASE IS BREACHED IN DIGEST TRACT,
ELECTROLYTE MAY CAUSE LOCALIZED BURNS. SKIN ABSORPTION:NO EVID OF
ADVERSE EFTS FROM AVAIL DATA. SKIN CONT:EXPOS TO ELECTROLYTE CNTND
INSIDE BATTERY MAY RSLT IN CHEM BURNS. EXPOS TO NICKEL MAY CAUSE
DERM IN SOME SENSITIVE INDIVIDUALS. EYE CONT:EXPOS TO ELECTROLYTE
Medical Cond Aggravated by Exposure:A KNOWLEDGE OF THE AVAILABLE
TOXICOLOGY INFORMATION & OF PHYSICAL & CHEMICAL PROPERTIES OF
MATERIAL SUGGESTS THAT OVEREXPOSURE IS UNLIKELY TO AGGRAVATE
EXISTING MEDICAL CONDITIONS.
* First Aid Measures *
First Aid:INGEST:DO NOT INDUCE VOMITING. SEEK MEDICAL ATTENTION
MINUTES. INHAL:REMOVE IMMEDIATELY TO FRESH AIR & SEEK MEDICAL
ATTENTION. EYES:IMMEDIAT ELY FLUSH W/WATER CONTINUOUSLY FOR AT
* Fire Fighting Measures *
Extinguishing Media:ANY CLASS OF EXTINGUISHING MEDIUM MAY BE USED ON
BATTERIES OR THEIR PACKING MATERIAL.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
VENTING OF LIQUID ELECTROLYTE. INTERNAL SHORTING COULD ALSO CAUSE
VENTING OF ELECTROLYTE.
* Accidental Release Measures *
Spill Release Procedures:SPILL & LEAKS ARE UNLIKELY BECAUSE CELLS ARE
CONTAINED IN HERMETICALLY-SEALED CASE. IF BATTERY CASE IS BREACHED,
DON PROT CLOTHING THAT IS IMPERVIOUS TO CAUSTIC MATLS & ABSORB/PACK
SPILL RESIDUES IN I NERT MATL. DISP I/A/W APPLIC STATE & FED REGS.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:STORE IN COOL PLACE, BUT PREVENT
CONDENSATION ON CELL OR BATTERY TERMINALS. ELEVATED TEMPERATURES
MAY RESULT IN REDUCED BATTERY LIFE.
CONTAINMENT:IF THERE ARE SPECIAL ENCAPSULATION/SEALING
REQUIREMENTS, CONSULT YOUR MFR'S REPRESENTATIVE ABOUT POSS CELL HAZ
PRECS/LIMITATIONS. ACCIDENTAL SH ORT CIRCUIT WILL BRING HIGH
* Physical/Chemical Properties *
Appearance and Odor:NO ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
BATTERY CELLS ARE ENCASED IN NON-REACTIVE CNTNR; HOWEVER, IF CNTNR IS
BREACHED, AVOID CONT OF INTERNAL BATTERY (SUPDAT)
Stability Condition to Avoid:HEAT, OPEN FLAMES, SPARKS & MOISTURE.
Hazardous Decomposition Products:OXIDES OF NICKEL, COBALT, MANGANESE,
LANTHANUM & CERIUM.
* Disposal Considerations *
Waste Disposal Methods:DISPOSAL MUST BE I/A/W FEDERAL, STATE & LOCAL
REGULATIONS . DISPOSE I/A/W ALL APPLICABLE STATE & FEDERAL
REGULATIONS. DO NOT INCINERATE OR SUBJECT BATTERY CELLS TO
RUPTURE.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:USE NIOSH APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN .
Ventilation:LOCAL EXHAUST: STANDARD EXHAUSTOR.
Other Protective Equipment:EMERGENCY EYEWASH AND DELUGE SHOWER MEETING
ANSI DESIGN CRITERIA .
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
* Product Identification *
CAGE:ALPPR
CAGE:ALPPR
* Composition/Information on Ingredients *
Ingred Name:CARBOXYLIC ACID DERIVATIVE
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:ACETIC ACID, (ETHYLENEDINITRILO)TETRA-; (VERSENE ACIDS)
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:ACETIC ACID, (ETHYLENEDINITRILO)TETRA-, TETRASODIUM SALT;
OSHA PEL:N/K
ACGIH TLV:N/K
OSHA PEL:N/K
ACGIH TLV:N/K
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:AMINE; (TRIAMINE)
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:ETHANOL, 2,2',2''-NITRILOTRI-; (TRIETHANOLAMINE) (CERCLA)
OSHA PEL:N/K
ACGIH TLV:N/K
* Hazards Identification *
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: MILD SKIN AND EYE IRRITATION.
CHRONIC:
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:FUMES FROM OVERHEATING OR FIRE MAY CAUSE EYE
IRRITATION.
Medical Cond Aggravated by Exposure:
* First Aid Measures *
WITH COPIOUS AMOUNTS OF WATER. SEE MD . INHALATION: REMOVE TO FRESH
AIR. SUPPORT BREATHING (GIVE OXYGEN OR ARTIFICIAL RESPIRATION) (FP
N). INGESTION: CALL MD IMMEDIATELY
* Fire Fighting Measures *
Flash Point:NONE
Extinguishing Media:USE MEDIA SUITABLE FOR SURROUNDING FIRE .
Fire Fighting Procedures:WEAR NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:
* Accidental Release Measures *
Spill Release Procedures:FLUSH AND DILUTE TO DRAIN AREA.
Neutralizing Agent:
*Handling and Storage *
CAUSE SLIGHT DECOMPOSITION AND SHORTER CHEMICAL LIFE.
Other Precautions:
* Physical/Chemical Properties *
Spec Gravity:1.1-1.5(H*2O=1)
Solubility in Water:COMPLETELY SOLUBLE
Appearance and Odor:POWDER WHITE OR LIQUID
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:
Hazardous Decomposition Products:
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE AND
FEDERAL REGULATIONS .
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NONE REQUIRED
Other Protective Equipment:NONE
Work Hygienic Practices:OBSERVE NORMAL CARE WHEN WORKING W/CHEMICALS.
Supplemental Safety and Health
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:SODIUM SACCHARINE, SODIUM SACCHARIN (ANIMAL CARCINOGEN BY
Fraction by Wt: 0.1%
Ingred Name:SODIUM FLUORIDE
Fraction by Wt: 2.7-2.8%
OSHA PEL:2.5 MG/CUM
ACGIH TLV:2.5 MG/CUM
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:EYES: MAY CAUSE IRRITATION. SKIN:
CHRONIC EXPOSURE MAY CAUSE DERMATITIS. INGESTION: MAY CAUSE
SALIVATION, NAUSEA, VOMITING. LARGE QUANTITIES MAY CAUSE ABDOMINAL
PAIN, WEAKNESS, TREMOR, SPASM/CONVULSIO NS. INHALATION: DEATH CAN
RESULT FROM RESPIRATORY PARALYSIS.
Explanation of Carcinogenicity:SEE INGREDIENTS.
Effects of Overexposure:IRRITATION, SALIVATION, NAUSEA, VOMITING,
ABDOMINAL PAIN, WEAKNESS, TREMOR, SPASM, CONVULSIONS, PARALYSIS
* First Aid Measures *
MINS. SKIN: WASH THOROUGHLY W/SOAP & WATER. INGESTION: IMMEDIATELY
GIVE COPIOUS QUANTITIES OF MILK/WATER. OBTAIN MEDICAL ATTENTION IN
ALL C ASES.
* Accidental Release Measures *
Spill Release Procedures:SCOOP UP MATERIAL & DISPOSE IN ACCEPTABLE
CONTAINERS.
*Handling and Storage *
Handling and Storage Precautions:KEEP AWAY FROM HEAT. KEEP CONTAINERS
CLOSED WHEN NOT IN USE.
Other Precautions:NONE
* Physical/Chemical Properties *
Appearance and Odor:ABRASIVE DISPERSION OF PUMICE IN AQUEOUS SOLUTION.
VARIOUS FLAVORS & COLORS
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
NONE
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/LOCAL, STATE &
FEDERAL REGULATIONS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:IN OUTDOORS/OPEN AREAS, W/UNRESTRICTED VENT, USE
NIOSH/MSHA APPROVED FILTER RESP TO REMOVE SOLID AIR-BORNE PARTICLES
OF OVERSPRAY DURING SPRAY APPLICATIONS. IN RESPTRICTED VENT AREAS,
USE NIOSH/MSHA A PPROVED RESP I/A/W (SUPDAT)
Ventilation:PROVIDE SUFFICIENT VENT, IN VOLUME & PATTERN, TO KEEP TLV &
LEL OF HAZ INGS BELOW LIMS, & TO REMOVE DECOMP (SUPDAT)
Other Protective Equipment:WEAR APPROPRIATE IMPERVIOUS PROTECTIVE
CLOTHING TO PREVENT SKIN CONTACT.
Work Hygienic Practices:REMOVE & WASH SOILED CLTHG BEFORE REUSE, WASH
HANDS BEFORE EATING/SMOKING.
Supplemental Safety and Health
FIRE FIGHT PROC: AS AN EXTINGUISHING MEDIA. TAKE CARE TO PREVENT SPREAD
OF BURNING LIQUID WITH WATER. CLOSED CONTAINERS MAY EXPLODE WHEN
COMBINATION OF PARTICULATES AND VAPORS. VENT: PRODUCTS DURING
WELDING/FLAME CUTTING ON SURFACES COATED W/PROD.
* Product Identification *
* Composition/Information on Ingredients *
Fraction by Wt: 1-5%
OSHA PEL:N/K
ACGIH TLV:N/K
Fraction by Wt: 1-5%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:COPPER (I) OXIDE PEL/TLV AS COPPER
OSHA PEL:1 MG/M3DUST,0.1 FUME
ACGIH TLV:1 MG/M3DUST,0.2 FUME
Ingred Name:ZINC OXIDE
Fraction by Wt: 1-5%
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES:IRRITATION, REDNESS, TEARING AND
BLURRED VISION. SKIN:IRRITATION. MAY RESULT IN DERMATITIS. HARMFUL
IF ABSORBED THROUGH SKIN. INHAL:SEVERE IRRITATION, DIZZINESS,
POSSIBLE NAUSEA AND VOMITING AND UNCONSCIOUSNESS. INGEST: GI
IRRITATION, NAUSEA, VOMITING, DIARRHEA AND UNCONSCIOUSNESS. CHRONIC
(EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ: OVEREXPOSURE TO, AND MISUSE OF,
SOLVENTS HAS BEEN LINKED TO PERMANANT BRAIN AND NERVOUS SYSTEM
DAMAGE. INHALATION OF ZINC FUME MAY PRODUCE SYMPTOMS KNOWN AS METAL
Medical Cond Aggravated by Exposure:SKIN AND RESPIRATORY CONDITIONS.
* First Aid Measures *
First Aid:EYES:FLUSH IMMEDIATELY W/COPIOUS AMOUNTS OF WATER FOR AT
CONTAMINATED CLOTHING, WASH SKIN W/PLENTY OF SOAP & WATER. LAUNDER
CLOTHING BEFORE REUSE. INHAL:REMOVE TO FRESH AIR. GIVEARTIFICIAL
RESPIRATION IF NEEDED. GET MED ATTENTION. INGEST:GET MED ATTENTION
IMMEDIATELY. DRINK PROMPTLY MILK, EGG WHITES, GELATINE SOLN/WATER.
AVOID ALCOHOL.
* Fire Fighting Measures *
Flash Point Method:SCC
Lower Limits:1%
Extinguishing Media:FOAM, CARBON DIOXIDE, DRY CHEMICAL.
Fire Fighting Procedures:USE NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP
.SMOTHER FLAME W/ONE OF EXTING MEDIA. WATER MAY BE USED TO COOL
UNOPENED CONTRS, BUT MUST NOT BE USED(SUPDAT)
Unusual Fire/Explosion Hazard:CONTAINS FLAMMABLE SOLVENT. DO NOT USE IN
AREAS WHERE SPARKS OR OPEN FLAME ARE PRESENT.
* Accidental Release Measures *
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION. AVOID
INHALATION OF VAPORS. VENTILATE AREA. CLEAN UP WITH ABSORBENT
MATERIALS.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:STORE IN BLDG DESIGNED & PROT FOR
STORAGE OF LIQUID WITH NFPA CLASS IC. AVOID BRTHG DUST/CHIPS FROM
SANDING/BLASTING SURFACES COATED W/PROD.
Other Precautions:THIS MATERIAL IS TOXIC TO FISH IF MISUSED, READ
CONTAINER LABEL BEFORE USE. RECOMMENDED GROUNDING AND BONDING OF
CONTAINERS WHEN TRANSFERRING LIQUIDS AND POWDERS TO AVOID STATIC
CHARGE BUILD UP.
* Physical/Chemical Properties *
Vapor Pres:SEE INGS
Vapor Density:HVR/AIR
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
MOISTURE, OXIDIZING AGENTS.
Stability Condition to Avoid:KEEP DRY. STORE AWAY FROM DIRECT HEAT,
FLAME OR SPARKS.
Hazardous Decomposition Products:CO, CO*2, VARIOUS HYDROCARBON
FRAGMENTS, COPPER FUMES, ZINC FUMES.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE IN ACCORDANCE WITH LOCAL, STATE AND
FEDERAL REGULATIONS. DO NOT INCINERATE UNOPENED CONTAINERS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:WEAR A PROPERLY FITTED NIOSH/MSHA APPROVED SCBA
OR INDUSTRIAL TYPE CANISTER MASK IN ENCLOSED AREAS WITH POOR OR NO
VENTILATION SYSTEM.
Ventilation:LOCAL EXHAUST: PREFERRED. MECHANICAL: ACCEPTABLE
Other Protective Equipment:HYDROCARBON INSOLUBLE APRONS, EYE WASH &
SAFETY SHOWER.
Work Hygienic Practices:REMOVE FROM DUST AREA, TREAT FOR DUST
INHALATION AND WA<SH ALL DUST FROM BODY.
Supplemental Safety and Health
* Product Identification *
Preparer's Name:PHIL PERKINS
* Composition/Information on Ingredients *
Ingred Name:SILVER (SARA III)
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:SILVER POWDER
ACGIH TLV:0.1 MG/CUM
Ingred Name:EPOXY NOVOLAC RESIN
* Hazards Identification *
Routes of Entry: Inhalation:NOSkin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYE: MINOR TRANSIENT IRRITATION. NO
CORNEAL INJURY LIKELY. SKIN; ONLY MINOR IRRITATION; MAY BE A SKIN
SENSITIZER. INHALATION: NO GUIDE FOR CONTROL KNOWN. NOT CONSIDERED
A PROBLEM UNLESS HEATED TO HIGH TEMPERATURES.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:PROLONGED ABSORPTION CAN LEAD TO DISCOLORATION
KNOWN AS ARGYRIE. SNEEZING, COUGHING - REACTION TO DUSTS & POWDERS.
* First Aid Measures *
First Aid:EYES: IRRIGATE W/WATER FOR 5 MINS. SKIN: CONTACT WILL
PROBABLY CAUSE NO MORE THAN IRRITATION. WASH OFF IN FLOWING WATER
OR SHOWER. WASH CLOTHING BEFORE REUSE. DESTROY CONTAMINATED SHOES.
INGESTION: LO W IN TOXICITY. INDUCE VOMITING IF LARGEAMTS ARE
INGESTED. INHALATION: REMOVE TO FRESH AIR IF EFFECTS OCCUR. CONSULT
MEDICAL PERSONNEL.
* Fire Fighting Measures *
Flash Point Method:TOC
Extinguishing Media:CO2, FOAM, DRY CHEMICAL, WATER SPRAY
Fire Fighting Procedures:PERSONNEL ENGAGED IN FIGHTING FIRS SHOULD WEAR
SCBA.
* Accidental Release Measures *
Spill Release Procedures:REMOVE IGNITION SOURCES. PROVIDE ADEQUATE
VENTILATION. COVER SPILL WITH ABSORBENT MATERIAL & REMOVE TO WASTE
CONTAINER.
*Handling and Storage *
Handling and Storage Precautions:STORE IN CLOSED CONTAINERS IN A COOL,
DRY AREA AWAY FROM HEAT. USE ONLY WITH ADEQUATE VENTILATION.
Other Precautions:AVOID PROLONGED OR REPEATED BREATHING OF VAPORS OR
CONTACT WITH SKIN.
* Physical/Chemical Properties *
Vapor Pres:-2
Vapor Density:3.8
Spec Gravity:3.0
Evaporation Rate & Reference:(WATER = 1): 1
Solubility in Water:1%
Appearance and Odor:SILVERY COLOR, SWEET, PLEASANT ODOR.
Percent Volatiles by Volume:3%
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS, AMINES, MERCAPTANS & BASES
Stability Condition to Avoid:EXOTHERMS WHEN CURRED.
Hazardous Decomposition Products:CO, ALDEHYDES & OTHER ORGANICS
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE, AND
FEDERAL REGULATIONS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR WHEN SPRAYING
PAINT
Ventilation:ADEQUATE VENTILATION
Other Protective Equipment:EYE WASH EQUIPMENT
Supplemental Safety and Health
ADDITIONAL INGREDIENTS:WATER, 4.5%; COLORANTS, 1.0%; SURFACTANTS, 2.0%
* Product Identification *
Product ID:ZOOM
* Composition/Information on Ingredients *
Ingred Name:VINYL ACETATE (SARA III)
Ingred Name:ETHYLENE GLYCOL (SARA III)
Fraction by Wt: 2.4%
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:TITANIUM DIOXIDE
Ingred Name:ALUMINUM SILICATE (AS NUISANCE DUST OR PARTICULATES NOT
OTHERWISE REGULATED)
Ingred Name:PHENYLMERCURIC ACETATE (SARA III)
Fraction by Wt: 0.1%
OSHA PEL:0.1 MG HG/M3;CEIL;S
* Hazards Identification *
Effects of Overexposure:VAPOR MAY BE IRRIT TO EYES, SKIN, MAY CAUSE
SYMPTOMS OF HEADACHE, NAUSEA IN POORLY VENTIL AREAS.
* First Aid Measures *
First Aid:SKIN CONTACT:WASH THOROUGHLY W/SOAP & WATER. EYES:FLUSH
AMOUNTS OF SPRAY MIST REMOVE TO FRESH AIR. INGEST:INDUCE
VOMITING.CALL MD.
* Fire Fighting Measures *
Flash Point:NON FLAMMABLE
Fire Fighting Procedures:N/A ACCD TO MFR
* Accidental Release Measures *
Spill Release Procedures:ABSORB SPILL,FLUSH W/LARGE AMOUNTS OF WATER
IMMED. TRANSFER TO CONTAINERS FOR RECOVERY OR DISPOSAL.DO NOT FLUSH
DOWN SEWER SYSTEM.
*Handling and Storage *
Handling and Storage Precautions:KEEP MATERIAL FROM FREEZING.
* Physical/Chemical Properties *
HCC:N1
Vapor Density:>1.0
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:COMPLETE
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
OIL & OIL BASE MATERIALS,PETROLEUM DISTILLATES,STRONG ACIDS
* Disposal Considerations *
Waste Disposal Methods:MFR RECM DISPOSE IN LANDFILL IAW FED, STATE &
LOCAL CODES.
| 1 | eyes_protection_mandatory |
Control Measures
*
Product ID: METERED PUMP-AIR FRESHENER, PERK
Cage: PREFE
Proprietary Ind: Y
*
Contractor Summary
*
Cage: PREFE
Cage: PREFF
Box: UNKNOW
*
Ingredients
*
-----------------------------
*
Health Hazards Data
*
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: NO
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: EYES:CAN SLIGHT TO MODERATE IRRITATION. SKIN:MAY CAUSE
MINIMAL IRRITATION. INHALATION:MAY CAUSE NASAL IRRITATION AND DROWSINESS.
INGESTION:NOT A SIGNIFICANT ROUTE OF EXPOSURE FOR THIS PRODUCT LINE AND NO
SIGNIFICANT ADVERSE EFFECTS EXPECTED. THIS PRODUCT IS A MIXTURE OF WHICH NO
HEALTH HAZARD DATA (EFTS OF OVEREXP)
Explanation Of Carcinogenicity: NOT RELEVANT.
Signs And Symptions Of Overexposure: HLTH HAZ:EXIST. THE HAZARD COMMUNICATION
STANDARD REQUIRES THAT SUCH MIXTURES BE ASSUMED TO PRESENT THE SAME HEALTH
HAZARD AS DO THE COMPONENTS THAT CONSTITUE AT LEAST 1% OF THE MIXTURE (0.1%
FOR CARC IONOGENS) ALTHOUGH OSHA HAS NOTED THAT THE HAZARDS OF THE INDIVIDUAL
COMPONENTS MAY BE ALTERED BY INCLUDING THEM(SUPDAT)
Medical Cond Aggravated By Exposure: NONE EXPECTED.
First Aid: INHALATION:REMOVE TO FRESH AIR. EYE:FLUSH EYES WITH WATER FOR AT
INGESTION:ADMINISTER LUKEWARM WATER (PINT)-INDUCE VOMITING, CALL A PHYS
ICIAN. SKIN:FLUSH W/COPIOUS AMOUNTS OF WATER. CALL MD (FP N). NO TREATMENT IS
NECESSARY UNDER ORDINARY CIRCUMSTANCES.
*
Handling and Disposal
*
Spill Release Procedures: NO SPECIAL CLEAN-UP PROCEDURE IS NECESSARY. REMOVE
ALL SOURCES OF FLAME, SPARKS AND HEAT. PROVIDE ADEQUATE VENTILATION.
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: DISPOSE IN ACCORDANCE WITH ALL LOCAL, STATE AND FEDERAL
REGULATIONS.
Handling And Storage Precautions: AVOID EXPOSURE TO EXCESSIVE HEAT AND PREVENT
FROM FREEZING.
Other Precautions: NONE REQUIRED.
*
Fire and Explosion Hazard Information
*
Flash Point Method: TCC
Extinguishing Media: WATER, CARBON DIOXIDE, DRY CHEMICAL OR FOAM, CLASS A, BC,
OR ABC FIRE EXTINGUISHERS.
Fire Fighting Procedures: USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT (FP N).
Unusual Fire/Explosion Hazard: NONE KNOWN TO PREFERRED DISTRIBUTORS, INC.
*
*
Respiratory Protection: NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR EXPOSURE
OF CONCERN (FP N). NOT NORMALLY NEEDED UNDER NORMAL CIRCUMSTANCES.
Ventilation: GENERAL ROOM VENTILATION IS NORMALLY SUFFICIENT.
Other Protective Equipment: EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET ANSI
DESIGN CRITERIA (FP N).
Work Hygienic Practices: NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health: USERS OF "L" VERSION OF SHOULD CONSULT "LR"
VERSION FOR ADDITIONAL INFORMATION (FP N). EFTS OF OVEREXP:IN A MIXTURE.
COMPONENTS OF THIS PRODUCT THAT ARE LISTED AS HAZARDOUS MATERIALS AND/OR
*
Physical/Chemical Properties
*
Vapor Density: >1
Evaporation Rate & Reference: >1 (N-BUTYL ACETATE=1)
Solubility in Water: NEGLIGIBLE
Appearance and Odor: COLORLESS LIQUID, PLEASANTLY SCENTED.
*
Reactivity Data
*
Stability Indicator: YES
Stability Condition To Avoid: NONE SPECIFIED BY MANUFACTURER.
Materials To Avoid: STRONG OXIDIZING AGENTS.
Hazardous Decomposition Products: CARBON CONTAINING MATARIALS WHEN BURNED WILL
PRODUCE CARBON DIOXIDE AND CARBON MONOXIDE.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT.
*
Toxicological Information
*
*
Ecological Information
*
*
*
*
Regulatory Information
*
*
Other Information
*
*
HAZCOM Label
*
Product ID: LABEL COVERED UNDER EPA REGS - HAZCOM LABEL NOT AUTHORIZED
*
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:IF ENGINEERING CONTROLS DO NOT MAINTAIN AIRBORNE
CONCENTRATIONS TO AN ACCEPTABLE LEVEL, A NIOSH-APPROVED RESPIRATOR
MUST BE WORN. A PROGRAM SHOULD BE INSTITUTED TO ASSURE COMPLIANCE
Ventilation:GENERAL MECHANICAL VENTILATION IS ADEQUATE FOR NORMAL USE.
LOCAL EXHAUST IS RECOMMENDED FOR CONFINED AREAS.
Other Protective Equipment:EYE WASH STATION, SAFETY SHOWER, PROTECTIVE
CLOTHING
Work Hygienic Practices:OBSERVE GOOD INDUSTRIAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES.
Supplemental Safety and Health
* Product Identification *
Product ID:METHYL PURPLE INDICATOR
* Composition/Information on Ingredients *
Other REC Limits:NONE RECOMMENDED
Ingred Name:METHYL RED SODIUM SALT
Other REC Limits:NONE RECOMMENDED
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:TARGET ORGANS:EYE, SKIN, RESPIRATORY
AND GASTROINTESTINAL TRACTS. ACUTE- EYE OR SKIN CONTACT MAY CAUSE
IRRITATION. MAY BE HARMFUL BY INHALATION, INGESTION, OR SKIN
ABSORPTION. TOXICOLOGICAL PROPERTIES OF THIS PRODUCT HAVE NOT BEEN
THOROUGHLY INVESTIGATED. CHRONIC- UNKNOWN.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, NAUSEA, VOMITING, TEARING
Medical Cond Aggravated by Exposure:PERSONS WITH PRE-EXISTING SKIN
DISORDERS SUCH AS ALLERGIES, ECZEMA MAY BE MORE SUSCEPTIBLE TO THE
EFFECTS OF THIS PRODUCT.
* First Aid Measures *
First Aid:GET MEDICAL HELP IF SYMPTOMS PERSIST. INHALED:REMOVE TO FRESH
AIR. PROVIDE CPR/OXYGEN IF NEEDED. EYES:IMMEDIATELY FLUSH WITH
WATER. OR AL:IF CONSCIOUS, RINSE OUT MOUTH WITH WATER. GET MEDICAL
ATTENTION.
* Fire Fighting Measures *
Flash Point:NONE
Lower Limits:NOT RELEVANT
Upper Limits:NOT RELEVANT
Extinguishing Media:WATER SPRAY, CARBON DIOXIDE, FOAM OR DRY CHEMICAL
FOR SURROUNDING FIRE. USE WATER SPRAY TO COOL FIRE EXPOSED
CONTAINERS.
Fire Fighting Procedures:WEAR PROTECTIVE CLOTHING AND NIOSH-APPROVED
SELF-CONTAINED BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:NONE
* Accidental Release Measures *
Spill Release Procedures:WEAR PROTECTIVE EQUIPMENT. VENTILATE AREA.
ABSORB ON SAND, VERMICULITE OR SIMILAR MATERIAL. SWEEP UP AND PLACE
IN AN APPROPRIATE CONTAINER. HOLD FOR DISPOSAL. WASH CONTAMINATED
SPILL AREA WITH DETERGE NT AND WATER.
Neutralizing Agent:NOT RELEVANT
*Handling and Storage *
Handling and Storage Precautions:STORE IN A COOL, DRY PLACE.
Other Precautions:WASH THOROUGHLY WITH SOAP AND WATER AFTER HANDLING
AND BEFORE EATING, DRINKING, SMOKING. KEEP OUT OF REACH OF
CHILDREN. DO NOT TAKE INTERNALLY. DO NOT GET IN EYES OR ON SKIN.
AVOID BREATHING VAPORS.
* Physical/Chemical Properties *
HCC:N1
NRC/State Lic Num:NOT RELEVANT
Appearance and Odor:GREEN LIQUID
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE,
OXIDES OF SULFUR, OXIDES OF NITROGEN
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH ALL LOCAL, STATE
AND FEDERAL REGULATIONS. EVAPORATE WATER USING HEATING BATH WITH
BURN IN A CHEMICAL INCI NERATOR EQUIPPED WITH AN AFTERBURNER AND
SCRUBBER.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NO EXTRA MEASURES NEEDED IF VENTILATION
ADEQUATE.
Ventilation:PROVIDE LOCAL EXHAUST/VENT AS NEEDED TO KEEP VAPOR
CONCENTRATIONS <PEL & TLV
Supplemental Safety and Health
* Product Identification *
* Composition/Information on Ingredients *
MONOETHYL ETHER, ETHOXYDIGLYCOL)
Fraction by Wt: <5%
Other REC Limits:NONE RECOMMENDED
Ingred Name:DIPROPYLENE GLYCOL METHYL ETHER (DIPROPYLENE GLYCOL
MONOMETHYL ETHER)
Fraction by Wt: <5%
Other REC Limits:NONE RECOMMENDED
Fraction by Wt: <5%
Other REC Limits:NONE RECOMMENDED
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: MAY IRRITATE EYES/SKIN ON
CONTACT. EYE INFLAMMATION CHARACTERIZED BY
REDNESS/WATERING/ITCHING. SKIN INFLAMMATION CHARACTERIZED BY
ITCHING, SCALING, REDDENING, OCCASIONALLY BLISTERING. CHRONIC: NO
KNOWN CHRONIC EXPOSURE EFFECTS
Explanation of Carcinogenicity:NONE OF THE INGREDIENTS ARE LISTED AS
CARCINOGENS BY IARC, NTP, OSHA.
Medical Cond Aggravated by Exposure:NO MEDICAL CONDITIONS ARE KNOWN TO
BE AGRAVATED BY EXPOSURE TO THIS PRODUCT.
* First Aid Measures *
First Aid:SKIN: IMMEDIATELY FLUSH CONTAMINATED SKIN W/PLENTY WATER AT
LIDS. GET M EDICAL AID AT ONCE. INHAL: GET FRESH AIR. IF IRRITATION
PERSISTS GET MEDICAL AID PROMPTLY. INGESTION: DON'T INDUCE
VOMITING. IF VICTIM CONSCIOUS GIVE PLENTY WATER TO DRINK. GET
MEDICAL AID AT ONCE.
* Fire Fighting Measures *
Flash Point Method:TCC
Flash Point:NONE
Lower Limits:NA
Upper Limits:NA
Extinguishing Media:NONCOMBUSTIBLE
Fire Fighting Procedures:POSITIVE PRESSURE SCBA.
Unusual Fire/Explosion Hazard:FIRE-EXPOSED DRUMS SHOULD BE COOLED
W/STREAM OF WATER.
* Accidental Release Measures *
Spill Release Procedures:ABSORB ON INERT ABSORBENT MAT'L (E.G.
ZEP-O-ZORB). PICK UP/PLACE RESIDUE IN SUITABLE WASTE CONTAINER OR
IF PERMITTED, FLUSH TO SEWER. THOROUGHLY RINSE SPILL AREA W/WATER.
OBSERVE HANDLING/STORAGE/PROT ECTIVE MEASURES AS LISTED BELOW.
*Handling and Storage *
Handling and Storage Precautions:KEEP CONTAINER TIGHTLY CLOSED IN DRY
Other Precautions:CLOTHING/SHOES THAT BECOME CONTAMINATED W/SUBSTANCE
SHOULD BE REMOVED PROMPTLY, NOT REWORN UNTIL THOROUGHLY CLEANED.
KEEP AWAY FROM CHILDREN.
SKIN CONTACT EXPECTED. ***TIGHT-FITTING SAFETY GLASSES RECOMMENDED
IF SPLASHING MAY OCCUR.
* Physical/Chemical Properties *
Vapor Density:<1
pH:7.2CON
Solubility in Water:DILUTABLE
Appearance and Odor:TAN, OPAQUE LIQUID
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS, ALKALIES, OXIDIZERS.
Hazardous Decomposition Products:CARBON DIOXIDE, CARBON MONOXIDE, OTHER
UNIDENTIFIED ORGANIC COMPOUNDS.
* Disposal Considerations *
Waste Disposal Methods:LIQUID WASTES NOT PERMITTED IN LANDFILL. PRODUCT
NOT HAZ WASTE (RCRA). ABSORB UNUSABLE LIQ ON INERT ABSORBENT, DRUM,
TAKE TO CHEM/INDUSTRIAL LANDFILL. IN SOME AREAS OK TO FLUSH TO
SANITARY SEWER W/WAT ER. SEE APPLICABLE LAWS FOR PROPER DISPOSAL.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:A NIOSH APPROVED RESPIRATOR FOR TOXIC DUSTS IS
RECOMMENDED IF THE PEL/TLV IS EXCEEDED.
Ventilation:PROVIDE VENTILATION TO MAINTAIN A DUST LEVEL BELOW THE
PEL/TLV.
Other Protective Equipment:EMERGENCY EYEWASH AND DELUGE SHOWER MEETING
ANSI DESIGN CRITERIA .
Work Hygienic Practices:THE SCORE AND SNAP METHOD FOR CUTTING IS
RECOMMENDED. SAWING, DRILLING OR MACHINING WILL PRODUCE DUST.
Supplemental Safety and Health
EXPLAN OF CARCIN: CARCIN. HUMAN: LUNG.
* Product Identification *
Product ID:JUMBO SHEATHING
Preparer's Name:NORBERT W KALETA
* Composition/Information on Ingredients *
Ingred Name:CALCIUM (II) SULFATE, DIHYDRATE (1:1:2); (GYPSUM)
Ingred Name:SILICA, CRYSTALLINE - QUARTZ; (QUARTZ)
OSHA PEL:SEE TABLE Z-3
ACGIH TLV:0.1 MG/M3 RDUST
Ingred Name:CELLULOSE; (CELLULOSE (PAPER FIBER))
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ACUTE: GOLD BOND BOARD PRODUCTS DO NOT
PRESENT AN INHALATION, INGESTION OR CONTACT HEALTH HAZARD UNLESS
SUBJECTED TO OPERATIONS SUCH AS SAWING, SANDING OR MACHINING WHICH
RESULT IN THE GENERATION OF A IRBORNE PARTICULATE. SKIN: CONTINUED
AND PROLONGED CONTACT MAY RESULT IN DRYING. EYES: DIRECT CONTACT
(EFTS OF OVEREXP)
Explanation of Carcinogenicity:SILICA, CRYSTALLINE-QUARTZ: IARC MONO,
TO BE (SUP DAT)
Effects of Overexposure:HLTH HAZ: MAY CAUSE MECHANICAL IRRITATION.
INHALATION: TARGET ORGANS: RESPIRATORY SYSTEM. SIGNS AND SYMPTOMS
OF EXPOSURE TO AIRBORNE DUST: CONTINUED AND PROLONGED EXPOSURE TO
AIRBORNE DUST CONCENTRATI ONS IN EXCESS OF THE PEL/TLV MAY RESULTIN
COUGH, DYSPNEA, WHEEZING AND IMPAIRED PULMONARY FUNCTION.
Medical Cond Aggravated by Exposure:OVEREXPOSURE WOULD GENERALLY
AGGRAVATE RESPIRATORY SYSTEM DYSFUNCTIONS.
* First Aid Measures *
AND GET MEDICAL ATTENTION. SKIN: FLUSH AND WASH WITH SOAP AND
WATER. GET MEDICAL ATTENTION IF IRRITATION PERSISTS. INHALATION:
MOVE THE PERSO N TO FRESH AIR AT ONCE. IF NOT BREATHING INITIATE
PULMONARY RESUSCITATION. GET MEDICAL ATTENTION. INGESTION: CALL MD
IMMEDIATELY .
* Fire Fighting Measures *
Extinguishing Media:DRY CHEMICAL, FOAM, WATER FOG OR SPRAY.
Fire Fighting Procedures:WEAR NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE SPECIFIED BY MANUFACTURER.
* Accidental Release Measures *
Spill Release Procedures:PICKUP TO AVOID TRIPPING HAZARD.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:KEEP DRY TO PRESERVE USEFULNESS.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
* Physical/Chemical Properties *
Appearance and Odor:GYPSUM CORE WRAPPED WITH PAPER; SURFACE FINISH WILL
VARY WITH PRODUCT; NO ODOR
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
NONE SPECIFIED BY MANUFACTURER.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:WHEN HEATED TO DECOMPOSITION OXIDES OF
SULFUR AND CARBON WILL BE RELEASED.
* Disposal Considerations *
Waste Disposal Methods:NOT A HAZARDOUS WASTE. DISPOSE OF IN ACCORDANCE
WITH APPLICABLE LOCAL, STATE AND FEDERAL REGULATIONS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:USE AN APPROPRIATE NIOSH/MSHA APPROVED
RESPIRATOR IF AIRBORNE MIST/FUME CONCENTRATIONS EXCEED THE
Ventilation:PROVIDE SUFFICIENT GEN & LOC EXHST VENT TO MAINTAIN AIR
CONC OF VAPS < PEL & TLV. IF SUCH VENT IS UNAVAILABLE(SUPP DATA)
Other Protective Equipment:EYEWASH FOUNTAINS SHOULD BE READILY
AVAILABLE IN AREAS OF USE AND HANDLING.
Work Hygienic Practices:WASH EXPOSED SKIN AREAS AFTER HANDLING.
Supplemental Safety and Health
HLTH HAZ: DIARRHEA, DYSURIA, SHALLOW RESPIRATION AND CONVULSIONS. OTHER
PREC: KIDNEYS, NERVOUS SYSTEMS, BLOOD, HEART AND RESPIRATORY
SYSTEMS. VENT: USE NIOSH/MSHA APPROVED RESPIRATORS AS SPECIFIED ABO
VE.
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:MOLYBDENUM
Ingred Name:MANGANESE (SARA III)
OSHA PEL:(C) 5 MG/M3 DUST
Ingred Name:SILICA, CRYSTALLINE - QUARTZ; (SILICON DIOXIDE)
OSHA PEL:SEE TABLE Z3
Ingred Name:PINE OIL
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:EXCESS INTAKE OF MOLYBDENUM MAY PRDCE
COPPER DEFICIENCY SYMPS. MANGANESE FUME MAY CAUSE METAL FUME FEVER
& BRONCHITIS. MAY CAUSE CNS DAM AFTER 1-2 YRS EXPOS. SILICA EXPOS
MAY CAUSE RESP DAM - SILICOSI S - SYMPS INCLUDE COUGHING, WHEEZING
& DFCLTY IN BRTHG.ASPIR OF PINE OIL INTO LUNGS CAN PRDCE CHEM (EFTS
OF OVEREXPOS)
Explanation of Carcinogenicity:CRYSTALLINE SILICA-QUARTZ: GROUP 2A
(IARC), ANTICIPATED TO BE A CARCINOGEN.
Effects of Overexposure:HLTH HAZ: PNEUMONITIS/EVEN FATAL EDEMA. SKIN:
DEFAT & IRRITATING. PINE OIL IS REPORTED TO BE WEAKLY ALLERGENIC.
RPTD/PRLNGD SKIN CONT W/PINE OIL CAN CAUSE IRRIT. EYE: HIGHILY
IRRITATING. DAM POSS FROM PINE OIL. INGEST: ACUTE PIOSONING
POSSDUE TO PINE OIL. SYMPS INCLUDE ABDOM BURNING SENSATION, NAUS,
VOMIT, (SUPP DATA)
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
* First Aid Measures *
First Aid:INHAL:MOVE TO FRESH AIR.RESTORE & SUPPORT BRTHG AS REQD.GET
IMMED MD ATTN.SKIN:REMOVE CONTAMD CLTHG.WASH EXPOS SKIN W/SOAP &
WATER.GET MD ATTN IF IRRIT PERSISTS.EYE:IMMED FLUSH, INCLUDING
MD ATTN IMMED.DO NOT INDUCE VOMIT.MED NOTE:REMOVE STOM CONTENTS BY
GASTRIC LAVAGE, TAKING EXTREME CARE TO PVNT ASPIR (DUE TO PINE OIL
CONTENT).
* Fire Fighting Measures *
Flash Point Method:PMCC
Extinguishing Media:DRY CHEMICAL, FOAM.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:KEEP AWAY FROM HEAT, SPARKS & FLAME. PINE
OIL DECOMPOSITION PRODUCTS MAY BE TOXIC.
* Accidental Release Measures *
Spill Release Procedures:NOTIFY SAFETY PERSONNEL. REMOVE ALL SOURCES OF
IGNITION. CONTAIN SPILL WITH ABSORBENT MATERIAL. THOSE INVOLVED IN
CLEAN-UP SHOULD WEAR PROTECTIVE EQUIPMENT.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:MAINTAIN GOOD HOUSEKEEPING AND STORE
AWAY FROM HOT SURFACES, HEAT, FLAME AND OXIDIZING AGENTS.
Other Precautions:AVOID PRLNGD/RPTD CONT W/LIQ & BRTHG MIST/VAPS.DO NOT
EAT/SMOKE IN AREAS WHERE MATL IS USED/STORED.DO NOT
INGEST.PREPLACEMENT & ANNUAL PHYSICAL EXAMS ARE RECD IN AREAS OF
EXCESS EXPOS W/ATTN TO PERIPH ERAL NERVOUS SYS, LIVER, (SUPP DATA)
* Physical/Chemical Properties *
HCC:V4
Solubility in Water:INSOLUBLE
Appearance and Odor:GRAY COLORED PASTES WITH A PINE OIL ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
POTASSIUM T-BUTOXIDE AND OTHER STRONG OXIDIZERS, NITRIC ACID,
NITRIC/SULFURIC ACID AND MOISTURE.
Stability Condition to Avoid:HEAT AND FLAME.
Hazardous Decomposition Products:CARBON MONOXIDE AND CARBON DIOXIDE.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF I/A/W ALL APPLICABLE FEDERAL, STATE
AND LOCAL REGULATIONS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NONE REQD FOR NORMAL CONDTNS. IF OPERATING
CONDTNS CAUSE HIGH VAP CONCS/TLV IS EXCEEDED, USE NIOSH/MSHA
APPROVED SUPPLIED AIR RESPIRATOR.
Ventilation:NORMAL VENT UNLESS VAPS ARE HIGH, THEN MECH VENT SHOULD BE
USED.
Other Protective Equipment:COMPLETE PROT CLTHG IF MATL IS BEING HANDLED
HOT.
Work Hygienic Practices:CLEAN EXPOSED SKIN W/SOAP & WATER OR WATERLESS
HAND CLEANER. LAUNDER OR DISCARD CONTMD CLTHG. DISCARD CONTAMD (ING
2)
Supplemental Safety and Health
SPEC GRAV:SLIGHTLY >1 (WATER =1). HANDLING/STOR:REFER TO FOLLOW
PUBLICATION ENTITLED "SAFE STORAGE & HNDLG OF HOT ASPHALT"; THE
PREC:MAY OCCUR W/ROAD WORK, CAN INCREASE SENSIT TO SUNBURN. EYE
PROT:SFTY GLASSES W/SFTY SHIELD IF MATL IS COLD.
* Product Identification *
Product ID:ASPHALT EMULSION, RS-2
* Composition/Information on Ingredients *
Ingred Name:ASPHALT; (PETROLEUM ASPHALT)
OSHA PEL:N/K
ACGIH TLV:5 MG/M3
Ingred Name:SUPDAT:HYGENE PRACT:LEATHER MATL. OBSERVE GOOD PERSONAL
HYGIENE. WASH THORO AFTER WORKING W/ASPHALT & BEFORE EATING.
OSHA PEL:N/K
ACGIH TLV:N/K
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES:IRRITATION. SKIN:MILD IRRITATION.
REPEATED CONTACT CAN CAUSE DERMATITIS. INHAL:RESPIRATORY
IRRITATION, NAUSEA, DIZZINESS, HEADACHE. INGEST:STOMACH IRRITATION,
NAUSEA, AND VOMITING. BREATHING ASPH ALT AEROSOL OR ASPHALT SMOKE
FOR PROTRACTED PERIODS OF TIME HAS PRODUCED DAM TO THE LUNGS OF
MICE. (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ:AMONG THE CHANGES OBSERVED WERE
BRONCHITIS, PNEUMONITIS, AND ABSCESS FORMATION. ASPHALT FUME
CONDENSATES HAVE BEEN SHOWN TO PRODUCE A TUMOROGENIC RESPONSE WHEN
REPEATEDLY APPLIED TO THE SKIN OF EXPERIMENTAL ANIMALS. THE
RELEVANCE OF THIS DATA TO HUMANS IS NOT KNOWN AT THIS TIME.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
* First Aid Measures *
WHILE HOLDING EYELIDS OPEN. GET MED ATTN IF CONDITION PERSISTS.
SKIN:WASH WITH SOAP AND WATER OR USE WATERLESS HANDCLEANER.
INHAL:REMOVE TO FRESH AIR. IF BREATHING IS DIFFICULT, GIVE OXYGEN;
IF BREATHING HAS STOPPED, GIVE ARTIF RESP. GET MED ATTN. INGEST:IF
VICTIM IS CONSCIOUS, GIVE LIQUIDS. INDUCE VOMITING. CALL A
PHYSICIAN.
* Fire Fighting Measures *
Flash Point:NONE
Extinguishing Media:DRY CHEMICAL, WATER FOG, FOAM CO*2.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
* Accidental Release Measures *
Spill Release Procedures:CONTAIN SPILL IMMED IN SMALLEST AREA POSS.
RECOVER AS MUCH OF THE PROD AS POSS. RESIDUAL FLUID SHOULD BE
SOAKED UP BY USE OF ABSORBANT MATLS. SWEEP UP & DISPOSE OF IN
ACCORDANCE WITH FEDERAL, STATE & LOCAL REGS.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
IS EXTREMELY FLAMM, HIGHLY TOXIC GAS. (SUPDAT)
Other Precautions:WHEN ASPHALT PRODS ARE HEATED, THEY OFTEN GIVE OFF SM
AMTS OF HYDROGEN SULFIDE. MINIMIZE BRTHG VAPS, FUMES, OR MIST; WHEN
POSS, USE VENT/WORK UPWIND OF SOURCE OF VAPS, FUMES OR MIST.
EXPOSING SKIN TO ASPHALT FUMES, MIST OR VAPS, AS (SUPDAT)
* Physical/Chemical Properties *
Spec Gravity:SUPDAT
Evaporation Rate & Reference:NO DATA AVAILABLE
Solubility in Water:DILUTES WITH WATER
Appearance and Odor:BROWN TO BLACK LIQUID OR SEMISOLID
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
NONE SPECIFIED BY MANUFACTURER.
Stability Condition to Avoid:HEAT, FLAME OR SPARK. DO NOT HEAT TO
Hazardous Decomposition Products:HAZARDOUS GASES/VAPORS PRODUCED ARE
CARBON DIOXIDE, CARBON MONOXIDE, OR SULFUR DIOXIDE.
* Disposal Considerations *
Waste Disposal Methods:RECYCLE AS MUCH OF RECOVERABLE PROD AS POSS.
DISPOSE OF NONRECYCLABLE MATL BY SUCH METHS AS CONTROLLED
INCINERATION/BLENDING W/AGGREGATE & USED FOR PATCHING & OTHER
MAINTENANCE USE. DISPOSE OF IN ACCO RDANCE WITH FEDERAL, STATE AND
LOCAL REGS .
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NIOSH APPROVED RESPIRATOR.
Ventilation:MECHANICAL EXHAUST REQUIRED.
Other Protective Equipment:EYE WASH AND DELUGE SHOWER MEETING ANSI
DESIGN CRITERIA .
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
WASTE DISP METH: UNLESS SPECIFIED DIFFERENTLY, NONCONTAMINATED
PACKAGING MAY BE TREATED LIKE HOUSEHOLD WASTE/RECYCLED.
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:GUANIDINE THIOCYANATE
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:HARMFUL IF SWALLOWED, INHALED, OR
ABSORBED THROUGH SKIN. MATERIAL IS DESTRUCTIVE TO TISSUE OF MUCOUS
MEMBRANES AND UPPER RESPIRATORY TRACT. CONTACT WITH ACIDS LIBERATES
VERY TOXIC GAS. ACUTE: INHALATI ON: MAY BE HARMFUL BY INHALATION.
MATERIAL IS DESTRUCTIVE TO MUCOUS MEMBRANES AND UPPER RESPIRATORY
TRACT. EYE CONTACT: CAUSES EYE IRRITATION. SKIN CONTACT: CAUSES
SKIN IRRITATION, HARMFUL BY SKIN ABS ORPTION. INGESTION: HARMFUL IF
SWALLOWED. CHRONIC: NOT APPLICABLE.
Effects of Overexposure:SEE HEALTH HAZARDS.
* First Aid Measures *
First Aid:EYE: IMMEDIATELY FLUSH EYES WITH COPIOUS AMOUNTS OF WATER FOR
SEPARATING THE EYELIDS WITH FINGERS. SKIN: IMMEDIATELY WASH SKIN
WITH SOAP AN D COPIOUS AMOUNTS OF WATER. INHALATION: REMOVE TO
FRESH AIR. IF NOT BREATHING GIVE ARTIFICIAL RESPIRATION. IF
BREATHING IS DIFFICULT, GIVE OXYGEN. INGESTION: WASH OUT MOUTH WITH
WATER PROVIDED PERSON IS CONSCIOUS. CALL A PHYSICIAN. REMOVE AND
WASH CONTAMINATED CLOTHING PROMPTLY.
* Fire Fighting Measures *
Extinguishing Media:NONCOMBUSTIBLE. USE EXTINGUISHING MEDIA APPROPRIATE
TO SURROUNDING FIRE CONDITIONS.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
* Accidental Release Measures *
Spill Release Procedures:PRECAUTIONARY MEASURES: WEAR NIOSH APPROVED
VERMICULITE AND PLACE IN CLOSED C ONTAINERS FOR DISPOSAL. VENTILATE
AREA AND WASH SPILL SITE AFTER MATERIAL PICKUP IS COMPLETE.
*Handling and Storage *
Handling and Storage Precautions:STORAGE: STORE TIGHTLY CLOSED AT
Other Precautions:KEEP TIGHTLY CLOSED. DO NOT GET IN EYES, ON SKIN, OR
ON CLOTHING. DO NOT BREATHE VAPOR. SEVERE EYE IRRITANT. STORE IN A
COOL DRY PLACE.
* Physical/Chemical Properties *
Solubility in Water:SOLUBLE
Appearance and Odor:COLORLESS LIQUID; NONE ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS, STRONG OXIDIZING AGENTS.
Hazardous Decomposition Products:TOXIC FUMES OF CARBON MONOXIDE, CARBON
DIOXIDE, NITROGEN OXIDES, AND HYDROGEN CYANIDE.
* Toxicological Information*
ONLY SELECTED REGISTRY OF TOXIC EFFECTS OF CHEMICAL SUBSTANCE
(RTECS) DATA IS PRESENTED HERE. SEE ACTUAL ENTRY IN RTECS FOR
COMPLETE INFORMATION. CAUTION - SU BSTANCES NOT YET FULLY TESTED.
ADDITIONAL INFORMATION; CONTACT WITH ACIDS LIBERATES VERY TOXIC
GAS. THE PRODUCT SHOULD BE HANDLED WITH THE NORMAL CAUTION ACCORDED
CHEMICALS. ADDITIONAL HARMFUL PROPER TIES CANNOT BE RULED OUT.
* Ecological Information *
Ecological:NOT APPLICABLE.
* Disposal Considerations *
Waste Disposal Methods:THERE ARE NO UNIFORM REGS FOR DISP OF CHEM/
RESIDUES. CHEM RESIDUES GENERALLY COUNT AS SPECIAL WASTE. WE REC
THAT YOU CONTACT EITHER AUTHORITIES IN CHARGE/APPRVD WASTE DISP
COMPANIES WHICH WILL ADVISE YOU ON HOW TO DISPOSE OF SPECIAL
WASTE. HANDLE CONTAMD PACKAGING IN SAME WAY AS SUBSTANCE ITSELF. (
SUPDAT)
* MSDS Transport Information *
Transport Information:NOT APPLICABLE.
* Regulatory Information *
Federal Regulatory Information:REGULATORY INFORMATION: LABELING: XN,
State Regulatory Information:
* Other Information *
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NIOSH/MSHA APPROVED RESP DEVICE IN ACCORD WITH
EXPOSURE OF CONCERN.
Ventilation:LOCAL/MECHANICAL,EXPLOSION PROOF MOTORS.
Other Protective Equipment:AS REQUIRED TO PREVENT SKIN CONTACT.
Supplemental Safety and Health
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:N-BUTYL ALCOHOL (SARA III)
Ingred Name:METHYL ISOBUTYL KETONE (SARA III)
Ingred Name:ISOBUTYL ALCOHOL (SARA III)
Ingred Name:N-BUTYL ACETATE (SARA III)
Ingred Name:ISOBUTYL ACETATE
* Hazards Identification *
Effects of Overexposure:EYE/SKIN: IRRIT. VAPORS: DIZZY,HEADACHE,SLIGHT
EUPHORIA,LOSS OF COORDINATION,LIGHT-HEADED FEELING.
* First Aid Measures *
INHALATION: REMOVE TO FRESH AIR. INGESTION: DO NOT INDUCE
VOMITING,CALL PHYSICIAN
* Fire Fighting Measures *
Lower Limits:1.5
Extinguishing Media:CO2,DRY CHEMICAL,FOAM
Fire Fighting Procedures:SELF-CONTAINED BREATH APP
Unusual Fire/Explosion Hazard:FLAMES MAY BE DIFFICULT TO SEE (BLUE
FLAME)
* Accidental Release Measures *
Spill Release Procedures:ELIMINATE ALL SOURCES OF IGNITION IN VICINITY
OF SPILL,VENTILATE WELL TO RELEASE VAPORS,CLEAN UP AS SOON AS
POSSIBLE.
*Handling and Storage *
Handling and Storage Precautions:KEEP AWAY FROM OPEN FLAME,USE IN WELL
VENTILATED AREA. AVOID CONTACT WITH SKIN OR EYES
Other Precautions:DANGER - HARMFUL OR FATAL IF SWALLOWED.
* Physical/Chemical Properties *
HCC:F3
Vapor Density:3.3
Solubility in Water:APPRECIABLE
Appearance and Odor:COLORLESS LIQUID,KETONE/ALCOHOL SMELL
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Hazardous Decomposition Products:CO*2,WATER
* Disposal Considerations *
Waste Disposal Methods:FLUSH WELL WITH WATER,FLUSH DRAIN WITH WATER TO
AVOID VAPOR BACK-UP. COMPLY WITH ALL LOCAL,STATE AND FEDERAL
REGULATIONS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Ventilation:GOOD VENTILATION
Supplemental Safety and Health
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:D-LIMONENE, 4-ISOPROPENYL-1-METHYLCYCLOHEXANE
D-1, 8(9)-P-MENTHADIENE
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SKIN/EYES: IRRITATION. INHALATION:
DIZZINESS, NAUSEA, & HEADACHE. INGESTION: NAUSEA, VOMITING, &
HARMFUL.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:SKIN/EYES: IRRITATION. INHALATION: DIZZINESS,
NAUSEA, & HEADACHE. INGESTION: NAUSEA, VOMITING, & HARMFUL.
* First Aid Measures *
First Aid:SKIN: WASH W/SOAP & WATER. EYES: FLUSH W/PLENTY OF WATER FOR
INGESTION: GIVE PLENTY OF WATER. DON'T INDUCE VOMITING. OBTAIN
MEDICAL ATT ENTION IN ALL CASES.
* Fire Fighting Measures *
Flash Point Method:TCC
Extinguishing Media:FOAM, CO2, OR DRY CHEMICAL
* Accidental Release Measures *
Spill Release Procedures:ABSORB ON ABSORBENT SUCH AS SELIG'S ABSORBENT
& PLACE IN A SEALED DRUM FOR DISPOSAL.
*Handling and Storage *
Handling and Storage Precautions:DON'T STORE, POUR OR SPILL NEAR HEAT
SOURCE OR OPEN FLAME. KEEP OUT OF REACH OF CHILDREN.
Other Precautions:AVOID DIRECT EYE/SKIN CONTACT. HARMFUL IF SWALLOWED.
* Physical/Chemical Properties *
Solubility in Water:NEGLIGIBLE
Appearance and Odor:CLEAR, LIGHT YELLOW COLOR W/CITRUS ODOR
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:HEAT SOURCE OR OPEN FLAME
* Disposal Considerations *
Waste Disposal Methods:DUE TO THE COMBUSTIBILITY FACTOR OF UNDILUTED
PRODUCT & ABSORBENT USED IN SPILL PROCEDURE, DISPOSE OF AS
HAZARDOUS WASTE ACCORDING TO FEDERAL, STATE, & LOCAL REGULATIONS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:APPROVED MECHANICAL FILTER RESPIRATOR TO REMOVE
SOLID AIRBORNE PARTICLES OF ANY SPRAY DURING APPLICATION.
Ventilation:GENERAL (MECHANICAL/LOCAL)
Other Protective Equipment:POST NO SMOKING SIGNS.
Supplemental Safety and Health
NK
* Product Identification *
Product ID:FRESH-N-CLEAN
Preparer's Name:DAVID SCHULTZ
* Composition/Information on Ingredients *
Other REC Limits:NONE RECOMMENDED
Ingred Name:QUATERNARY AMOONIUM COMP.
Other REC Limits:NONE RECOMMENDED
Ingred Name:NONYL PHENOL ETHOXYLATE
Other REC Limits:NONE RECOMMENDED
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYE: PAINFUL, IRRIT. SKIN: IRRIT,
DRYING, CRACKING. INHAL: IRRIT TO NOSE/THROAT, HEADACHE, DROWSY,
NAUSEA, DISORIENTATION, DISTRESS. INGEST: SLIGHTLY TOXIC, DROWSY,
UNCONSCIOUS, STOMACH CRAMPS, PAIN,NAUSEA, VOMIT, DIARRHEA.
Medical Cond Aggravated by Exposure:PRE-EXISTING LUNG DISEASE MAY BE
AGGRAVATED.
* First Aid Measures *
SKIN: WASH W/SOAP & WATER. REMOVE CONTAM CLOTHES, WASH BEFORE
REUSE. INHAL: REMOVE TO FRESH AIR. ARTIF RESPIRATION IF NEEDED.
INGEST: DO NOT I NDUCE VOMIT. IN ALL CASES, GET IMMED MED AID.
* Fire Fighting Measures *
Flash Point Method:SCC
Flash Point:NA
Autoignition Temp:Autoignition Temp Text:NE
Extinguishing Media:FOAM, DRY CHEMICAL, CARBON DIOXIDE WATER, ALCOHOL
FOAM, WATER FOG.
Fire Fighting Procedures:USE SCAB, AND FULL PROTECTRIVE GEAR.
* Accidental Release Measures *
Spill Release Procedures:EXTINGUISH IGNITS. USE SUITABLE PROTECTIVE
CLOTHES. COLLECT LARGE SPILLS FOR DISPOSAL.
*Handling and Storage *
Handling and Storage Precautions:STORE IN COOL DRY AREA.
Other Precautions:KEEP AWAY FROM CHILDREN.
* Physical/Chemical Properties *
Vapor Pres:NO DATA
Vapor Density:NO DATA
Evaporation Rate & Reference:NO DATA
Solubility in Water:MISCIBLE
Appearance and Odor:CLEAR, THIN LIQUID, PLEASANT FLORAL TYPE ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:NONE
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE,
NITROUS OXIDE, AND AMMONIA VAPORS. THERMAL DECOMPOSITION MAY YIELD
ACRYLIC MONOMERS.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/FEDERAL, STATE &
LOCAL REGULATIONS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NONE NEEDED IN NORMAL CONDITIONS.
Ventilation:GOOD GENERAL VENTILATION SHOULD BE SUFFICIENT.
Other Protective Equipment:AS NEEDED BY LOCAL AUTHORITIES.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING PRODUCT.
Supplemental Safety and Health
WORKING SOLUTION WHILE NEW NSN IS FOR 1GAL SOLUTION.KEY1:C2
* Product Identification *
Kit Part:Y
* Composition/Information on Ingredients *
Ingred Name:ETHYLENEDIAMINE-TETRAACETIC ACID (EDTA) (SARA III)
Fraction by Wt: 3.0%
* Hazards Identification *
Routes of Entry: Inhalation:NOSkin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:NO SPECIFIC HAZARDS KNOWN TO EASTMAN
KODAK COMPANY.
Effects of Overexposure:MSDS FM MFR STATES THAT EFFECTS OF OVEREXPOSURE
ARE OF LOW HAZARD FOR USUAL INDUSTRIAL HANDLING. HOWEVER, ANY
MATERIAL THAT CONTACTS THE EYES MAY BE IRRITATING.MAY CAUSE SKIN
ALLERGIC REACTION ON REPE ATED AND/OR PROLONGED CONTACT WIT SKIN.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY THE MANUFACTURER.
* First Aid Measures *
MEDICAL HELP IF IRRITATION PERSISTS; SKIN:FLUSH WITH WATER.GET MED
ATTN IF NEEDED OR SYMPTOMS PERSIST. IF SWALLOWED, DRINK 1-2 GLASSES
OF W ATER.SEEK MEDICAL ATTENTION.
* Fire Fighting Measures *
Flash Point:NONE
Extinguishing Media:USE APPROPRIATE AGENT FOR SURROUNDING FIRE.
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS AND
PROTECTIVE CLOTHING TO PREVENT CONTACT WITH SKIN & EYES.
Unusual Fire/Explosion Hazard:NONE NOTED BY MANUFACTURER.
* Accidental Release Measures *
Spill Release Procedures:EVACUATE UNPROTECTED PERSONS.ELIM IGN
SOURCES.USE PROTECTV CLOTHNG/SAFETY GLASSES.STOP LEAK W/O
RISK.PROVIDE VENT.DIKE LG SPILL & PUMP INTO COVRD
DRUMS;ABSORB/CONTAIN SM SPILL IN CONT;MFGR RECOMMENDS, FLUSH TO
SEWER W/LG AMT OF WATER IAW EXISTING LAWS
*Handling and Storage *
Handling and Storage Precautions:STORE IN COOL,DRY,WELL VENTILATED
AREA.KEEP CONTAINERS TIGHTLY CLOSED.PROTECT CONTAINERS FROM
PHYSICAL DAMAGE.
Other Precautions:AVOID PROLONGED AND/OR REPEATED CONTACT WITH
PRODUCT.REMOVE & WASH CONTAMINATED CLOTHING.WASH HANDS AFTER USE.
* Physical/Chemical Properties *
HCC:C2
Vapor Density:0.6
pH:5.0
Solubility in Water:COMPLETE
Appearance and Odor:RED-BROWN SOLUTION-SLIGHT AMMONIACAL,ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
NONE STATED BY KODAK COMPANY ON THE MSDS.
Stability Condition to Avoid:EXPOSURE TO HIGH HEAT/TEMPERATURES.
Hazardous Decomposition Products:THERMAL DECOMPOSITION MAY LIBERATE
NH*3,N*2 OXIDES,CO & CO*2
* Disposal Considerations *
Waste Disposal Methods:KEEP IN COVERED CONTAINERS PENDING DISPOSAL.SHIP
WASTE MATL TO DISPOSL FACILITY IAW DOT/EPA REGS.HANDLE/DISPOSE IN
FULL COMPLIANCE W/ALL INTNL,FED,STATE/LOCAL REGS;MFGR
RECOMMENDS,FLUSH TO SEWER W/LG AMT OF WATER IAW FED,STATE/LOCAL
EFFLUENT LAWS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:WHERE RESPIRATORY PROTECTION IS REQUIRED, USE
Ventilation:PROVIDE DILUTION VENTILATION OR LOCAL EXHAUST TO PREVENT
BUILD-UP OF VAPORS.
Other Protective Equipment:ANSI APPRVD EYE WASH & DELUGE SHOWER .
IMPERVIOUS CLOTHING, APRON.
Work Hygienic Practices:WASH HANDS THOROUGHLY AFTER HANDLING,
ESPECIALLY BEFORE EATING OR SMOKING.
Supplemental Safety and Health
MFR TRADE NAME/PART NO:HOUSE & TRIM PAINT, EXPLO HAZ:CNDTNS EMITTING
IRRITANT AND/OR TOXIC GASES. IN CLSD TANKS, WATER/FOAM MAY CAUSE
FROTHING/ERUPTION. MATLS TO AVOID:POTASSIUM. EFTS OF OVEREXP:UNCOO
RDINATION, NAUS, VOMIT, GI DISTURB, SEVABDOM PAIN, APATHY, CNS
DEPRESS, RESP PROBLEMS, INTOXICATION, (ING 9)
* Product Identification *
* Composition/Information on Ingredients *
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Fraction by Wt: 1-5%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:IRON (III) OXIDE
Fraction by Wt: 1-5%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:PROPIONIC ACID, 2-METHYL-, MONOESTER WITH
2,2,4-TRIMETHYL-1,3-PENTANEDIOL
Fraction by Wt: 1-5%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:SILICA, CRYSTALLINE-CRISTOBALITE. % (WT):0.1-1.0
Fraction by Wt: 1.0%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:ACRYLIC COPOLYMER
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:WATER
OSHA PEL:N/K
ACGIH TLV:N/K
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:SUPDAT:LIVER DMG, KIDNEY DMG, REPROD SYS DMG, PULM EDEMA,
LOSS OF CONSCIOUSNESS, ACUTE POISONING, RESP FAILURE (ING 1O)
Ingred Name:ING 9:CARD FAILURE, BRAIN DMG, DEATH. SUPP HLTH INFO:OTHER
OF EYES, SKIN & RESPIRATORY TRACT.
Ingred Name:FIRST AID PROC:OCCURS, CONSULT PHYS. EYE:FLUSH IMMED W/LG
TREATMENT. INGEST:OBTAIN MED TREATMENT IMMEDIATELY.
Ingred Name:SPILL PROC:LG SPILLS-SHUT OFF LEAK IF SAFE TO DO SO. DIKE &
PROPERLY.
Ingred Name:OTHER PREC:SURFACES. IF SUCH CNDTNS CANNOT BE AVOIDED, USE
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ACUTE:INHAL:IRRIT OF RESP TRACT,
LUNGS, PRLNGD INHAL MAY LEAD TO MUC MEMB IRRIT, DROW, DIZZ AND/OR
LT HEAD, HDCH, NAUS, GI DISTURB, COUGH, CHOKING SNEEZING, APATHY,
CNS DEPRESS, RESP PROBLEMS, ANESTHEFT/NARCOSIS, DFCLTY OF BRTHG,
BLOOD ABNORMAL, KIDNEY DMG, PNEUMOCONIOSIS, LOSS OF CONSCIOUSNESS.
SKIN:(EFTS OF OVEREXP)
Explanation of Carcinogenicity:CRYSTALLINE SILICA CRISTOBALITE:IARC
Effects of Overexposure:HLTH HAZ:IRRIT. PRLNGD/RPTD CONT CAN CAUSE
DERM. CONT MAY RSLT IN DERMAL ABSORP OF COMPONENT(S) OF THIS PROD
WHICH MAY CAUSE APATHY. EYE:IRRIT. PRLNGD/RPTD CONT CAN CAUSE CONJ,
TEARING, REDNESS, SEV I RRIT/BURNS, CORNEAL INJURY, BLNDNESS.
INGEST:MAY CAUSE MOUTH & THROAT IRRIT, DROW, DIZZ AND/OR LT HEAD,
HDCH, (SUPDAT)
Medical Cond Aggravated by Exposure:EYE, SKIN, RESPIRATORY DISORDERS
ASTHMA-LIKE CONDITIONS, KIDNEY DISORDERS.
* First Aid Measures *
First Aid:INHAL:REMOVE TO FRESH AIR. RESTORE & SUPPORT CONTINUED BRTHG.
GET MED ATTN. HAVE TRAINED PERSON GIVE OXYG IF NEC. GET MED HELP
FOR ANY BRTHG DFCLTY. REMOVE TO FRESH AIR IF INHAL CAUSE EYE
WATERING, HD CH, DIZZ/OTHER DISCOMFORT. GET MED ATTNIF
DISCOMFORT/IRRIT PERSISTS. SKIN:FLUSH W/WATER, THEN WASH THORO
W/SOAP & WATER. REMOVE CONTAMD CLTHG. WASH CONTAMD CLTHG BEFORE
* Fire Fighting Measures *
Flash Point:NONE
Extinguishing Media:DRY CHEMICAL OR FOAM WATER FOG, CARBON DIOXIDE.
Fire Fighting Procedures:NIOSH APPRVD SCBA & FULL PROT EQUIP . WATER
MAY BE USED TO COOL & PROTECT EXPOSED CONTAINERS.
Unusual Fire/Explosion Hazard:VAPS ARE HVR/AIR & MAY TRAVEL LONG DIST
TO SOURCE OF IGNIT & FLASH BACK. CLSD CNTNRS MAY BURST IF EXPOSED
TO EXTREME HEAT/FIRE. MAY DECOMPOSE UNDER FIRE(SUPDAT)
* Accidental Release Measures *
Spill Release Procedures:COMPLY W/ALL APPLIC HLTH & ENVIR REGS. ELIM
ALL SOURCES OF IGNIT. VENTILATE AREA. SPILLS MAY BE COLLECTED
W/ABSORB MATLS. EVAC ALL UNNEC PERS. PLACE COLLECTED MATL IN PROPER
CNTNRS. COMPLETE PERSONAL PROT EQUIP MUST BE USED DURING
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
& OPEN FLAME. KEEP FROM FREEZING. DO NOT STORE IN ALUMINUM CNTNRS.
USE W/ADEQ VENT. DO NOT TAKE INTERNALLY.
Other Precautions:KEEP OUT OF REACH OF CHILDREN. AVOID CONT W/SKIN &
EYES, & BRTHG OF VAPS. KEEP CNTNRS TIGHTLY CLSD & UPRIGHT WHEN NOT
IN USE. AVOID CNDTNS WHICH RSLT IN FORMATION OF INHALABLE PARTICLES
* Physical/Chemical Properties *
Evaporation Rate & Reference:NOT KNOWN
Solubility in Water:NOT KNOWN
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
OXIDIZERS, ACIDS, BASES, ALKALIS ALUMINUM, ZINC, HYPOCHLORITES,
HYDROGEN FLUORIDE, MAGNESIUM, CAUSTICS, SODIUM, (SUPDAT)
Stability Condition to Avoid:ELEVATED TEMPS, CONT W/OXIDIZING AGENT,
ALUMINUM OR ZINC, STOR NEAR ACIDS, FREEZING, SPKS, OPEN FLAME,
IGNIT SOURCES.
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE,
OXIDES OF NITROGEN, ACRID FUMES, OXYGEN, TOXIC GASES.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE IN ACCORDANCE WITH ALL APPLICABLE
FEDERAL, STATE AND LOCAL REGULATIONS. AVOID DISCHARGE TO NATURAL
WATERS.
| 1 | eyes_protection_mandatory |
Control Measures
*
*
Contractor Summary
*
*
Ingredients
*
Other REC Limits: N/K (FP N)
OSHA PEL: N/K (FP N)
OSHA STEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
ACGIH STEL: N/K (FP N)
------------------------------
Other REC Limits: N/K (FP N)
OSHA PEL: N/K (FP N)
OSHA STEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
ACGIH STEL: N/K (FP N)
------------------------------
(TETRA-CALCIUM-ALUMINO-FERRITE)
% low Wt: 5.
Other REC Limits: N/K (FP N)
OSHA PEL: N/K (FP N)
OSHA STEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
ACGIH STEL: N/K (FP N)
------------------------------
% low Wt: 2.
Other REC Limits: N/K (FP N)
OSHA STEL: N/K (FP N)
ACGIH STEL: N/K (FP N)
------------------------------
% low Wt: 1.
Other REC Limits: N/K (FP N)
OSHA PEL: N/K (FP N)
OSHA STEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
ACGIH STEL: N/K (FP N)
------------------------------
% low Wt: 0.
% high Wt: 5.
Other REC Limits: N/K (FP N)
OSHA STEL: N/K (FP N)
ACGIH STEL: N/K (FP N)
------------------------------
% low Wt: 0.
% high Wt: 4.
Other REC Limits: N/K (FP N)
OSHA STEL: N/K (FP N)
ACGIH STEL: N/K (FP N)
------------------------------
% low Wt: 0.
% high Wt: .2
Other REC Limits: N/K (FP N)
OSHA PEL: 5 MG/M3
OSHA STEL: N/K (FP N)
ACGIH TLV: 2 MG/M3
ACGIH STEL: N/K (FP N)
------------------------------
% low Wt: 0.
% high Wt: .2
Other REC Limits: N/K (FP N)
OSHA PEL: see Table Z-3
OSHA STEL: N/K (FP N)
ACGIH TLV: 0.1 MG/M3
ACGIH STEL: N/K (FP N)
------------------------------
Other REC Limits: N/K (FP N)
OSHA PEL: 5 MG/M3 (RESP DUST)
OSHA STEL: N/K (FP N)
ACGIH TLV: 5 MG/M3 (RESP DUST)
ACGIH STEL: N/K (FP N)
*
Health Hazards Data
*
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: YES
Carcinogenicity Inds - NTP: YES
IARC: YES
OSHA: NO
Effects of Exposure: INHALATION (ACUTE): BREATHING DUST MAY CAUSE NOSE, THROAT
OR LUNG IRRITATION AND CHOKING. THE DESCRIBED EFFECTS DEPEND ON THE DEGREE OF
EXPOSURE. INHALATION (CHRONIC): PROLONGED OR REPEATED EXPOSURE M AY CAUSE
LUNG INJURY INCLUDING SILICOSIS. THIS PRODUCT MAY CONTAIN CRYSTALLINE SILICA.
CRYSTALLINE SILICA HAS BEEN CLASSIFIED BY IARC AS A KNOWN HUMAN CARCINOGEN.
SOME HUMAN STUDIES INDICATE POTENTIAL FOR LUNG CANCER FROM CRYSTALLINE
SILICA EXPOSURE. RISK OF INJURY DEPENDS ON DURATION AND LEVEL OF EXPOSURE.
LONG TERM EXPOSURES WHICH RESULT IN SILICOSIS MAY RESULT IN ADDITIONAL HEALTH
EFFECTS. (EFF ECTS OF OVEREXPOSURE)
Explanation Of Carcinogenicity: SILICA, CRYSTALLINE-QUARTZ: IARC MONOGRAPHS,
Signs And Symptions Of Overexposure: HEALTH HAZARDS: EYE CONTACT
(ACUTE/CHRONIC): MAY CAUSE IRRITATION, SEVERE BURNS AND DAMAGE TO CORNEA.
SKIN CONTACT (ACUTE/CHRONIC): MAY CAUSE DRY SKIN, REDNESS, DISCOMFORT,
IRRITATION OR SEVERE BURNS. MAY PRODUCE ALLERGIC REACTION POTENTIALLY
ASSOCIATED WITH HEXAVALENT CHROMIUM. THICKENING OF THE SKIN (SCLERODERMA) MAY
BE ASSOCIATED WITH EXPOSURE TO HIGH LEVELS OF CRYSTALLINE SILICA. INGESTION
(AC UTE/CHRONIC): INGESTION OF LARGE AMOUNTS MAY CAUSE INTESTINAL DISTRESS.
First Aid: INHALATION: MOVE PERSON TO FRESH AIR. SEEK MEDICAL ATTENTION FOR
MEDICAL ATTENTION FOR ABRASIONS. SKIN: WASH WITH SOAP AND W ATER. USE
MOISTURIZING CREAMS FOR IRRITATED SKIN. SEEK MEDICAL ATTENTION FOR BURNS.
INGESTION: DO NOT INDUCE VOMITING, BUT DRINK PLENTY OF WATER. SEEK MEDICAL
ATTENTION FOR DISCOMFORT.
*
Handling and Disposal
*
Spill Release Procedures: GENERAL: WIND BLOWN DUST MAY CAUSE THE HAZARDS
IDENTIFIED IN HEALTH HAZARDS SECTION. REMOVE SPILLED MATERIAL TO LIMIT
POTENTIAL HARM. LAND/WATER SPILL: CLEAN UP SPILLED MATERIAL.
Waste Disposal Methods: DISPOSE IN LANDFILL IN ACCORDANCE WITH ALL APPLICABLE
REGULATIONS. ANY DISPOSAL PRACTICE MUST BE IN ACCORDANCE WITH LOCAL,
PROVINCIAL, STATE AND FEDERAL LAWS AND REGULATIONS. CONTACT LOCAL ENVIRONMENT
AL AGENCY FOR SPECIFIC RULES.
Handling And Storage Precautions: GENERAL: AVOID ACCIDENTAL RELEASE. STORE DRY
AND AWAY FROM WATER. STORAGE TEMPERATURE: UNLIMITED. STORAGE PRESSURE:
UNLIMITED. EMPTY CONTAINERS: DISPOSE OF CONTAINERS IN AN APPROVED LANDFILL OR
INCINE RATOR.
*
Fire and Explosion Hazard Information
*
Flash Point Text: NONE
Autoignition Temp Text: NONE
Lower Limits: NOT COMBUST
Upper Limits: NOT COMBUST
Extinguishing Media: USE MEDIA SUITABLE FOR SURROUNDING FIRE (FP N).
Fire Fighting Procedures: WEAR NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT (FP N). AVOID BREATHING DUST. TREAT ADJACENT MATERIAL.
Unusual Fire/Explosion Hazard: THIS PRODUCT IS NOT A FIRE HAZARD. HAZARDOUS
COMBUSTION PRODUCTS: NONE.
*
*
Respiratory Protection: UNDER ORDINARY CONDITIONS NO RESPIRATORY PROTECTION IS
REQUIRED. WEAR A NIOSH APPROVED RESPIRATOR WHEN EXPOSED TO DUST ABOVE
EXPOSURE LIMITS.
Ventilation: USE EXHAUST VENTILATION TO MAINTAIN DUST LEVELS BELOW EXPOSURE
LIMITS IN WORKPLACES WITH POOR VENTILATION AND DUSTY CONDITIONS.
Other Protective Equipment: EYEWASH AND DELUGE SHOWER MEETING ANSI DESIGN
CRITERIA (FP N). USE SHOES AND PROTECTIVE CLOTHING TO PREVENT SKIN CONTACT.
Supplemental Safety and Health: VAPOR DENSITY: NOT MEASURABLE.
*
Physical/Chemical Properties
*
M.P/F.P Text: NONE, SOLID
Vapor Pres: NOT MEASURABLE
Vapor Density: SUP DAT
Spec Gravity: 3.2
Viscosity: NONE, SOLID
Evaporation Rate & Reference: NOT MEASURABLE
Solubility in Water: SLIGHT (0.1-1.0%)
*
Reactivity Data
*
Stability Indicator: YES
Stability Condition To Avoid: PRODUCT IS STABLE BUT MUST BE KEPT DRY. REACTS
WITH WATER FORMING POLYMERIZED SILICATES AND CALCIUM OXIDE.
Materials To Avoid: DISSOLVES IN HYDROFLUORIC ACID PRODUCING CORROSIVE SILICON
TETRAFLUORIDE GAS. SILICATES REACT WITH POWERFUL OXIDIZERS SUCH AS FLUORINE,
CHLORINE TRIFLUORIDE AND OXYGEN DIFLUORIDE.
Hazardous Decomposition Products: NONE, POWDERED SOLID.
Hazardous Polymerization Indicator: NO
*
Toxicological Information
*
Toxicological Information: FOR DETAILED TOXICOLOGICAL INFORMATION CONTACT:
*
Ecological Information
*
Ecological: FOR DETAILED ECOLOGICAL INFORMATION CONTACT: ENVIRONMENT AND
*
*
Transport Information: NOT A HAZARDOUS MATERIAL FOR DOT OR TDG SHIPPING.
*
Regulatory Information
*
BEEN REVIEWED ACCORDING TO THE EPA HAZARD CATEGORIES PROMULGATED UNDER
SHOULD BE INCLUDED IN THE EMPLOYER'S HAZARD COMMUNICATION PROGRAM.
(TSCA): SOME CONSTITUENTS IN THIS PRODUCT ARE LISTED ON THE TSCA INVENTORY. W
INFORMATION: THIS PRODUCT CONTAINS SUBSTANCES CONSIDERED TO BE HAZARDOUS BY
HEALTH CANADA AND IS A CONTROLLED PRODUCT. CONSULT LOCAL AUTHORITIES FOR
D2A, E.
CALIFORNIA.
*
Other Information
*
Other Information: NOTE: THIS MSDS COVERS MANY PRODUCTS. INDIVIDUAL COMPOSITION
OF HAZARDOUS CONSTITUENTS WILL VARY.
*
HAZCOM Label
*
Assigned IND: Y
Company Name: LAFARGE CORPORATION
Label Required IND: Y
Status Code: A
Origination Code: F
Chronic Hazard IND: Y
Skin Protection IND: YES
Signal Word: WARNING
Respiratory Protection IND: YES
Health Hazard: Moderate
Contact Hazard: Moderate
Fire Hazard: None
Reactivity Hazard: None
Hazard And Precautions: ACUTE: INHAL: BREATHING DUST MAY CAUSE NOSE, THROT/LUNG
IRRIT & CHOKING. EYE CONTACT: MAY CAUSE IRRIT, SEV BURNS & DMG TO
CORNEA. SKIN CONT: MAY CAUSE DRY SKIN, REDNESS, DISCOMFORT, IRRIT/SEV BURNS.
I NGEST OF LRG AMTS MAY CAUSE INTESTINAL DISTRESS. CHRONIC: CANCER HAZARD.
CONTAINS SILICA, CRYSTALLINE-QUARTZ WHICH IS LISTED AS A HUMAN LUNG
CARGINOGEN (FP N).INHAL: PRLNGD/RPTD EXPOS MAY CAUSE LUNG INJURY
INCLUDING SILICOSIS. SKIN & EYE CONT : IRRIT& BURNS MAY PRODUCE
ALLERGIC RXN POTENTIALLY ASSOCIATED WITH HEXAVALENT CHROMIUM. THICKENING OF
THE SKIN (SCLERODERMA) MAY BE ASSOCIATED W ITH EXPOSURE TO HIGH LEVELS OF
CRYSTALLINE SILICA.
*
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:IF WELL VENTED RESP NOT REQ. RESTRICTED VENT,
ORGANIC VAPOR RESP REQ. SPRAY, MECH PREFILTER ALSO REQ. CONFINED,
AIR SUPPLY RESP REQ. ABOVE TLV, RESP W/APPROP PROTECT FACTOR. SEE
Ventilation:LOCAL EXHST-SUFFICIENT VOL/PATTRN TO MAINTAIN EXPOS BELOW
NUSIANCE DUST LIMITS AND PEL. REFER TO INDUSTRIAL VENTILATION
Other Protective Equipment:EYEWASH STATION, SAFETY SHOWER
Supplemental Safety and Health
* Product Identification *
Preparer's Name:W. A. ELLISON
CAGE:PRATT
CAGE:PRATT
* Composition/Information on Ingredients *
Other REC Limits:NONE SPECIFIED
Fraction by Wt: 5%
Other REC Limits:NONE SPECIFIED
Ingred Name:NITROCELLULOSE (RESIN)
Other REC Limits:NONE SPECIFIED
OSHA PEL:NONE ESTABLISHED
ACGIH TLV:NONE ESTABLISHED
Other REC Limits:NONE SPECIFIED
Ingred Name:TITANIUM DIOXIDE (PIGMENT)
Other REC Limits:NONE SPECIFIED
Fraction by Wt: 5%
Other REC Limits:NONE SPECIFIED
Fraction by Wt: < 5%
Other REC Limits:NONE SPECIFIED
1.0 / UFL 6.0)
Fraction by Wt: 5%
Other REC Limits:NONE SPECIFIED
1.0 / UFL 7.0)
Other REC Limits:NONE SPECIFIED
/ UFL 8.0)
Fraction by Wt: < 1%
Other REC Limits:NONE SPECIFIED
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Other REC Limits:NONE SPECIFIED
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:INGEST: GASTROINTESTINAL IRRITATION,
NAUSEA AND VOMITING. ASPIRATION OF MATERIAL INTO LUNG: CHEMICAL
PNEUMONITIS. INHAL: NOSE OR THROAT IRRITATION. ACUTE CNS DEPRESSION
W/HEADACHES, DIZZINESS, NAUSEA, CONFUSION. EYE: IRRITATION. SKIN:
IRRITATION AND DEFATTING.
Explanation of Carcinogenicity:THERE IS SUFFICIENT EVIDENCE OF
CARCINOGENICITY OF DI(2-ETHYLHEXYL)PHTHALATE (DEHP).
Effects of Overexposure:LIVER DAMAGE, PERIPHERAL NERVOUS SYSTEM,
PERIPHERAL NEUROPATHY, PERMANENT BRAIN AND NERVOUS SYSTEM DAMAGE.
INTENTIONAL MISUSE BY DELIBERATELY CONCENTRATING AND INHALING THE
CONTENTS MAY BE HARMFUL ORFATAL.
Medical Cond Aggravated by Exposure:NOTE TO PHYSICIAN: ANY TREATMENT
THAT MIGHT BE REQUIRED FOR OVEREXPOSURE SHOULD BE DIRECTED AT THE
CONTROL OF SYMPTOMS AND THE CLINICAL CONDITIONS.
* First Aid Measures *
First Aid:INGEST: DO NOT INDUCE VOMIT. CALL POISON CENTER, HOSPITAL
EMERGENCY ROOM OR DR IMMED. INHAL: REMOVE TO FRESH AIR IMMED. IF
BREATHING STOPPED, GIVE ARTIFICIAL RESP. KEEP WARM/QUIET-GET MED
GET MED AID. SKIN: IMMED FLUSH CONTAMINATED AREA WITH WATER. REMOVE
CONTAMINATED CLOTHING AS WATER IS APPLIED. CONSULT PHYSICIAN.
* Fire Fighting Measures *
Lower Limits:1.0%
Extinguishing Media:NFPA CLASS B FIRE EXTING (CO2-ALL PURPOSE DRY CHEM-
ALCOHOL FOAM) MADE TO EXTING FLAMM LIQ FIRES. POLYMER FOAM-LG FIRES
Fire Fighting Procedures:USE SCBA. WATER MAY BE INEFFECTIVE-USE TO COOL
EXPOSED CNTNR-PREVENT PRESSURE BLDUP/AUTO EXPLOSION WHEN EXPOSED TO
EXTREME HEAT. FOG NOZZLES PREFERRED W/WATER
Unusual Fire/Explosion Hazard:EMERGENCY CONDITIONS-OVEREXPOSURE TO
DECOMPOSITION MAY BE HEALTH HAZARD-SYPMTOMS DELAYED. GET MED ATTN.
DANGER] EXTREMELY FLAMMABLE-VAPORS MAY CAUSE FLASH FIRE.
* Accidental Release Measures *
Spill Release Procedures:WEAR RESP/BODY PROTECT-EVAC AREA-ELIM IGNIT
SRCS. DIKE/CONTAIN W/INERT MATL-TRANS LIQ TO COVERED METAL CNTNR.
USE NON- SPARK TOOL. DISPOSE ABSORB DIKING MATL IN COVERED METAL
CNTNR. PREVENT CONTAM OF SEWER-STREAM-GROUNDWTR W/SPILL MATL OR
USED ABSORB
*Handling and Storage *
Other Precautions:DO NOT INGEST. CLOSE CNTNR AFTER USE. EMPTY CNTNRS
MUST NOT BE WASHED OR RE-USED FOR ANY PURPOSE. CNTNRS SHOULD BE
GROUNDED/BONDED TO RECEIVING CNTNR. DO NOT WELD-BRAZE-CUT ON EMPTY
CNTNR-NEVER USE PR ESS TO EMPTY. DRUM IS NOT A PRESS VESSEL
* Physical/Chemical Properties *
HCC:F2
Vapor Density:> THAN AIR
Spec Gravity:1.0
pH:4-7STD
Evaporation Rate & Reference:SLOWER THAN DIETHYL ETHER
Solubility in Water:SLIGHT IN WATER
Appearance and Odor:LIQUID, SOLVENT ODOR
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS OR ALKALINE MATERIALS. OXIDIZING MATERIALS.
SOURCES OF IGNITION
Hazardous Decomposition Products:BURNING, WHEN HEATED BY
WELDING/CUTTING WILL PRODUCE SMOKE, CO, CO2. IN ADDITION, OXIDES OF
NITROGEN, MAY BE GENERATED.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE IN ACCORD W/FEDERAL-STATE-LOCAL LAWS AND
REGULATIONS. INCINERATE ONLY IN EPA FACILITY. DO NOT INCINERATE
CLOSED CNTNRS. OBSERVE PRECAUTIONS FOR DISPOSAL OF FLAMM MATL. MAY
DISPOSE CONTAMINATED ABSORB IN HAZARDOUS WASTE LANDFILL. RCRA:
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
NECESSARY.
Ventilation:GOOD GENERAL VENTILATION SHOULD BE SUFFICIENT TO CONTROL
AIRBORNE LEVELS.
Other Protective Equipment:EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET
ANSI DESIGN CRITERIA . WEAR APPROP PROT CLTHG TO PREVENT SKIN CONT.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
FIRST AID PROC:& SUPPORTIVELY. ANTIDOTE:NONE REPORTED.
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:SODIUM HYDROXIDE (CERCLA)
Fraction by Wt: 1%
OSHA PEL:2 MG/M3
ACGIH TLV:2 MG/M3, C
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:PHOSPHORIC ACID, MONOPOTASSIUM SALT; (POTASSIUM PHOSPHATE
MONOBASIC)
Fraction by Wt: 1%
OSHA PEL:N/K
ACGIH TLV:N/K
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:EYE:MAY CAUSE IRRITATION.
SKIN:MAY CAUSE IRRITATION. LOW HAZARD FOR USUAL INDUSTRIAL
HANDLING. INGESTION:MAY CAUSE IRRITATION OF THE DIGESTIVE TRACT.
INHALATION:MAY CAUSE RESPIRATORY TRACT IRRIT ATION. LOW HAZARD FOR
USUAL INDUSTRIAL HANDLING. CHRONIC:NOT AVAILABLE.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
* First Aid Measures *
First Aid:EYES:GET MED AID. GENTLY LIFT LIDS & FLUSH CONTINUOUSLY
DEVELS/PERSISTS. FLUSH W/PLENTY OF SOAP & WATER. INGEST:IF VICTIM
IS CONSCIOUS & ALERT, GI VE 2-4 CUPFULS OF MILK/WATER. GET MED AID.
INHAL:REMOVE FROM EXPOS TO FRESH AIR IMMED. IF NOT BRTHG, GIVE ARTF
RESP. GET MED AID IF COUGH/OTHER SYMPS APPEAR. NOTES TO MD:TREAT
SYMPTOMATICALLY (SUPDAT)
* Fire Fighting Measures *
Extinguishing Media:SUBSTANCE IS NONCOMBUSTIBLE; USE AGENT MOST
APPROPRIATE TO EXTINGUISH SURROUNDING FIRE.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE SPECIFIED BY MANUFACTURER.
* Accidental Release Measures *
Spill Release Procedures:USE PROPER PERSONAL PROTECTIVE EQUIPMENT AS
INDICATED IN EXPOSURE CONTROLS, PERSONAL PROTECTION SECTION. ABSORB
SPILL W/INERT MATERIAL (E.G., DRY SAND OR EARTH), THEN PLACE INTO A
CHEMICAL WASTE CONTA INER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:USE W/ADEQUATE VENTILATION. AVOID
CONTACT W/EYES. KEEP CONTAINER TIGHTLY CLOSED. AVOID INGESTION &
INHALATION. STORE IN A COOL, DRY PLACE.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
* Physical/Chemical Properties *
Solubility in Water:SOLUBLE
Appearance and Odor:CLEAR, COLORLESS LIQUID.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
THERE IS NO INFORMATION FOR ANY INCOMPATIBILITIES FOR THIS SUBSTANCE.
Stability Condition to Avoid:NONE REPORTED.
Hazardous Decomposition Products:NONE.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF IN A MANNER CONSISTENT W/FEDERAL,
STATE & LOCAL REGULATIONS. NOT LISTED AS A MATERIAL BANNED FROM
LAND DISPOSAL ACCORDING TO RCRA.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATOR.
Ventilation:USE GOOD LOCAL EXHAUST AND MECHANICAL (GENERAL)
VENTILATION. FOLLOW OSHA STANDARDS.
Other Protective Equipment:USE PROTECTIVE CLOTHING AS NEEDED.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:SILICA, CRYSTALLINE - QUARTZ; (CRYSTALLINE QUARTZ (SIO*2))
OSHA PEL:SEE TABLE Z3
Ingred Name:ALUMINUM OXIDE (2:3); (ALUMINUM OXIDE) (SARA III)
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ACUTE:EYE IRRITATION, POSSIBLE SKIN
IRRITATION. CHRONIC:FREE SILICA DUST MAY CAUSE DELAYED LUNG INJURY.
Explanation of Carcinogenicity:SILICA, CRYSTALLINE - QUARTZ:GROUP 2A
(IARC) .ANTICAPATED TO BE A CARCINOGEN(NTP).
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:
* First Aid Measures *
First Aid:INHAL:MOVE SUBJECT TO FRESH AIR IF NEEDED. EYES:FLUSH WITH
INGEST:CALL PHYSICIAN.
* Fire Fighting Measures *
Extinguishing Media:MEDIA SUITABLE FOR SURROUNDING FIRE .
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE
* Accidental Release Measures *
Spill Release Procedures:SWEEP OR VACUUM USING GOOD VENTILATION SO TLV
IS NOT EXCEEDED.
Neutralizing Agent:
*Handling and Storage *
Handling and Storage Precautions:USE DUSTLESS SYSTEMS FOR HANDLING,
STORING AND CLEAN UP SO TLV OF SIO2 IS NOT EXCEEDED.
Other Precautions:PRACTICE GOOD HOUSEKEEPING AND POST WORK AREAS WHERE
PRODUCT IS USED.
* Physical/Chemical Properties *
HCC:N1
Solubility in Water:NEGLIGIBLE
Appearance and Odor:GRANULAR POWDER WITH NO ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
DISSOLVED BY HYDROFLUORIC ACID WHICH CAN RESULT IN SILICON
TETRAFLUORIDE WHICH IS A CORROSIVE GAS.
Stability Condition to Avoid:
* Disposal Considerations *
Waste Disposal Methods:DISPOSE IN SANITARY LANDFILL IN ACCORDANCE WITH
LOCAL, STATE AND FEDERAL REGULATIONS ON SOLID WASTES.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR APPROPIATE FOR
EXPOSURE OF CONCERN .
Ventilation:LOCAL/MECH EXHAUST RECOMMENDED.
Other Protective Equipment:PROTECTIVE COVERALLS, EYE WASH, SAFETY
SHOWER.
Work Hygienic Practices:WORK SAFELY. RESPECT THE MATERIAL. WASH AFTER
HANDLING.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
* Product Identification *
Preparer's Name:V. MACNAMARA
* Composition/Information on Ingredients *
Ingred Name:NITRIC ACID (SARA III)
OSHA PEL:2 PPM;4 PPM STEL
ACGIH TLV:2 PPM;4 PPM STEL
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EXPOS TO NITRIC ACID REPRESENTS DUAL
HLTH HAZ:SPECIFICALLY, TISSUE CORROSION FROM TOPICAL CONTACT AND
ACUTE PULMONARY EDEMA OR CHRONIC OBSTRUCTIVE PULMONARY DISEASE FROM
INHALATION. IRRIT OF EYES, RES PIRATORY SYSTEM. EYE BURNS. SKIN
BURNS WITH YELLOWING OF SKIN. DELAYED PULMONARY EDEMA. DENTAL
EROSION.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HLTH HAZS.
Medical Cond Aggravated by Exposure:EYE, SKIN, LUNGS, TEETH,
RESPIRATORY SYSTEM.
* First Aid Measures *
SKIN:IMMEDIATELY FLUSH WITH WATER. INHAL:FRESH AIR., ARTIFICAL
RESPIRATION. INGEST:IF CONSCIOUS GIVE WATER. DO NOT INDUCE VOMIT.
CALL PHYSICIAN.
* Fire Fighting Measures *
Flash Point:NOT COMBUSTIBLE
Extinguishing Media:FLOOD FIRE WITH WATER, DRY CHEMICAL, SODA ASH.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT. COOL FLAME EXPOSED CONTAINERS WITH WATER
UNTIL WELL AFTER FIRE IS OUT.
Unusual Fire/Explosion Hazard:VIOLENT REACTION WITH WATER AND FUELS.
MAY IGNITE COMBUSTIBLES. POWERFUL OXIDIZERS. CONTACT WITH METALS
MAY LIBERATE HYDROGEN GAS.
* Accidental Release Measures *
Spill Release Procedures:ELIMINATE IGNITION SOURCES. FOR MAJOR SPILLS
WEAR NIOSH/MSHA APPROVED SCBA AND FULL PROTECTIVE EQUIPMENT. KEEP
COMBUSTIBLE AWAY FROM SPILL. FLUSH AREA WITH FLOODING AMOUNT OF
WATER. NEUTRALIZE WITH SO DA ASH.
Neutralizing Agent:SODA ASH
*Handling and Storage *
Handling and Storage Precautions:AVOID BREATHING VAPOR. DO NOT GET
LIQUID OR VAPOR IN EYES, ON SKIN, ON CLOTHING. KEEP CONTAINER
CLOSED, AWAY FROM HEAT, FLAME AND COMBUST MATLS.
Other Precautions:OBSERVE ALL PRECAUTIONS WHEN HANDLING "EMPTY"
CONTAINERS AND POSSIBLE RESIDUE THEREIN.
* Physical/Chemical Properties *
HCC:C1
Spec Gravity:1.5 (H2O=1)
Solubility in Water:MISCIBLE
Appearance and Odor:COLORLESS OR YELLOWISH, FUMING, LIQUID. CHOKING
ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
COMBUSTIBLE MATTER, STRONG BASES, METAL POWER, OXIDIZABLE MATERIAL.
Stability Condition to Avoid:HEAT, SPARKS, FLAME, STEAM. COMBUSTIBLE
MATERIALS.
Hazardous Decomposition Products:TOXIC AND CORROSIVE FUMES, NOX,
HYDROGEN NITRATE
* Disposal Considerations *
Waste Disposal Methods:TO BE PERFORMED IN COMPLIANCE WITH ALL LOCAL,
STATE, AND FEDERAL REGULATIONS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:IF WORKPLACE EXPOSURE LIMIT(S) OR PROD OR ANY
COMPONENT IS EXCEEDED A NIOSH/MSHA APPRVD AIR SUPPLIED RESP IS
ADVISED IN ABSENCE OF PROPER ENVIRON CONTROL. OSHA REGS ALSO PERMIT
OTHER NIOSH/MSHA APPRVD RESPS (NEGATIVE PRESSURE TYPE) (ING 7)
Ventilation:PROVIDE SUFFICIENT MECH (GEN &/OR LOC EXHST) VENTILATION TO
MAINTAIN EXPOSURE BELOW TLV(S).
Other Protective Equipment:TO PREVENT REPEATED OR PROLONGED SKIN
CONTACT, WEAR IMPERVIOUS CLOTHING AND BOOTS.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
FIRE FIGHT PROC:FIREFIGHTER. ESPECIALLY IF SPRAYED INTO CNTNRS OF HOT,
BURNING LIQ. WATER MAY BE USED TO KEEP FIRE-EXPOSED CNTNRS COOL
UNTIL FIRE IS OUT. SPILL PROC:SPREADING, PUMP LIQ TO SALVAGE TANK .
REMAINING LIQ MAY BE TAKEN UP ON SAND, CLAY, EARTH, FLOOR ABSORB,
OR OTHER ABSORB MATL & SHOVELED INTO CNTNRS.(ING 2)
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:ING 2: AS REQUIRED, THAT A SPILL HAS OCCURED.
Ingred Name:OTHER PREC: "AUTOIGNIT" OR " IGNIT" TEMP VALUES CANNOT BE
TREATED AS SAFE OPERATING TEMPS IN CHEM PROCESS (ING 5)
Ingred Name:ING 4: WITHOUT ANALYSIS OF THE ACTUAL PROCESS CNDTNS. ANY
USE OF THIS PROD IN ELEVATED TEMP PROCESSES SHOULD (ING 6)
Ingred Name:ING 5: BE THOROUGHLY EVALUATED TO ESTABLISH & MAINTAIN SAFE
OPERATING CONDITIONS.
Ingred Name:RESP PROT: UNDER SPECIFIED CONDITIONS. ENGINEERING OR
ADMINISTRATIVE CONTROLS SHOULD BE IMPLEMENTED TO REDUCE EXPOSURE.
Ingred Name:MINERAL OIL, WHITE; (ALIPHATIC PETROLEUM DISTILLATES)
OSHA PEL:5 MG/M3 OIL MIST
ACGIH TLV:5 MG/M3 OIL MIST
Ingred Name:SUPP DATA:PVNT RUN-OFF TO SEWERS, STREAMS OR OTHER BODIES
OF WATER. IF RUN-OFF OCCURS, NOTIFY PROPER AUTHORITIES (ING 3)
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES: MAY CAUSE IRRITATION. SKIN: MAY
CAUSE IRRITATION. INHAL: MIST CAN CAUSE IRRITATION OF NASAL AND
RESPIRATORY PASSAGES. INGEST: CAN CAUSE GASTROINTESTINAL
IRRITATION, NAUSEA, VOMITING, AND DIARRH EA. ASPIRATION OF MATERIAL
INTO THE LUNGS CAN CAUSE CHEMICAL PNEUMONITIS WHICH CAN BE FATAL.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
* First Aid Measures *
First Aid:SKIN:THORO WASH EXPOSED AREA W/SOAP & WATER. REMOVE CONTAM
CLTHG. LAUNDER CONTAM CLTHG BEFORE RE-USE. EYE:FLUSH W/LRG AMTS OF
WATER, LIFTING UPPER & LOWER LIDS OCCASIONALLY, GET MED ATTN.
INGEST:DO NO T INDUCE VOMIT. KEEP PERSON WARM, QUIET, & GET MED
ATTN. ASPIR OF MATL INTO THE LUNGS DUE TO VOMITING CAN CAUSE
CHEMICAL PNEUMONITIS WHICH CAN BE FATAL. INHAL: REMOVE INDIVIDUAL
TO FRESH AIR.
* Fire Fighting Measures *
Extinguishing Media:REGULAR FOAM OR CARBON DIOXIDE OR DRY CHEMICAL.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL PROT
EQUIP . WATER OR FOAM MAY CAUSE FROTHING WHICH CAN BE VIOLENT &
POSSIBLY ENDANGER THE LIFE OF THE (SUPP DATA)
Unusual Fire/Explosion Hazard:NEVER USE WELDING OR CUTTING TORCH ON OR
NEAR DRUM (EVEN EMPTY) BECAUSE PRODUCT (EVEN JUST-RESIDUE) CAN
IGNITE EXPLOSIVELY.
* Accidental Release Measures *
Spill Release Procedures:SML SPILL: ABSORB LIQ ON VERMICULITE, FLOOR
ABSORB/OTHER ABSORB MATL. LRG SPILL: PERSONS NOT WEARING PROT EQUIP
SHOULD BE EXCLUDED FROM AREA OF SPILL UNTIL CLEAN-UP HAS BEEN
COMPLETED. STOP SPILL AT S OURCE, DIKE AREA OF SPILL TO PREVENT
(SUPP DATA)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:CNTNRS OF THIS MATL MAY BE HAZ WHEN
EMPTIED. SINCE EMPTIED CNTNRS RETAIN PROD RESIDUES (VAP/LIQ &/OR
SOLID), ALL HAZ PREC GIVEN MUST BE OBSERVED.
Other Precautions:WARNING!! SUDDEN REL OF HOT ORGANIC CHEM VAPS/MISTS
FROM PROCESS EQUIP OPERATING AT ELEVATED TEMP & PRESS, OR SUDDEN
INGRESS OF AIR INTO VACUUM EQUIP, MAY RESULT IN IGNIT WITHOUT THE
PRESENCE OF OBVIO US IGNIT SOURCES. PUBLISHED (ING 4)
* Physical/Chemical Properties *
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
Percent Volatiles by Volume:< 1
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
AVOID CONTACT WITH STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:MAY FORM TOXIC MATERIALS; CARBON
DIOXIDE AND CARBON MONOXIDE.
* Disposal Considerations *
Waste Disposal Methods:SMALL AND LARGE SPILL: DISPOSE OF IN ACCORDANCE
WITH ALL LOCAL, STATE AND FEDERAL REGULATIONS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:IF EXPOSURES EXCEED ESTABLISHED LIMITS, A
NIOSH/MSHA APPROVED RESPIRATOR FOR ASBESTOS SHOULD BE USED.
CONSULT YOUR SAFETY OFFICE/IH PERSONNEL FOR GUIDANCE FOR THE TASK
AT HAND.
Ventilation:LOCAL EXHAUST IS RECOMMENDED IN SITUATIONS WHERE DUST IS
GENERATED BY ABRASIVE ACTIONS, ABRASION OR OTHER MEANS.
Other Protective Equipment:AS REQUIRED FOR TASK AT HAND, AND THE
GUIDANCE SET FORTH BY YOUR SAFETY OFFICE OR IH PERSONNEL
Work Hygienic Practices:DONOT INHALE DUST CREATED BY ABRADING ACTIONS.
USE FULL PROTECTION AGAINST AIRBORNE FIBERS. AVOID AIRBORNE DUST
CREATION
Supplemental Safety and Health
GENERIC "MSDS" CREATED FOR "NSN" IDENTIFIED BY "DISC" AS CONTAINING
ASBESTOS.WHEN A MANUFACTURER'S SPECIFIC "MSDS" IS PROVIDED FOR
MATERIAL PROCURED UNDER THIS NSN, THIS GENERIC "MSDS" WILL BE
REMOVED.
* Product Identification *
Preparer's Name:DOD HMIS/DGSC-SSH
* Composition/Information on Ingredients *
Ingred Name:ASBESTOS, CHRYSOTILE
OSHA PEL:0.2 FIBERS/CC
Ingred Name:ASBESTOS OVERALL COMPOSITION
Ingred Name:GENERIC "MSDS". SPECIFIC ASBESTOS TYPE NOT KNOWN. ONE
CITED IS ASSUMED. INFORMATION BASED ON SEGMENT "M" OF "DLSC TIR"
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:ACUTE: NO ACUTE EFFECTS ARE KNOWN;
CHRONIC: DUST FROM ABRASIVE ACTIONS(EG. CUTTING, MACHINING,
FILING, ETC.) MAYCONTAIN ASBESTOS FIBERS. CHRONIC OVEREXPOSURE
TO AIRBORNE FIBERS MAY LEAD TO ASBESTOSIS & MESOTHELIOMA.
SMOKINGCOMBINED W/FIBER INHALATION GREATLY INCREASES LUNG
CANCER RISK!
Explanation of Carcinogenicity:OVEREXPOSURE TO AIRBORNE CONCENTRATIONS
OF ASBESTOS MAY LEAD TO ASBESTOSIS AND MESOTHELIOMA.
Effects of Overexposure:INHAL: INHALATION OF AIRBORNE DUST CONTAINING
ASBESTOS FIBERS ON REPEATED EXPOSURE MAY CAUSE OR CAN LEAD TO
ASBESTOSIS/ MESOTHELIOMA; SKIN: N/K; EYE: POTENTIAL IRRITATION
FROM AIRBORNE DUST; INGEST: N/K.
Medical Cond Aggravated by Exposure:RESPIRATORY DEFICIENCIES DUE TO
REPEATED INHALATION OF AIRBORNE FIBERS.
* First Aid Measures *
First Aid:INHAL: REMOVE TO FRESH AIR. OBTAIN MEDICAL ADVICE; SKIN:
WASH EXPOSED AREA WITH SOAP & WATER; EYE: FLOOD W/ WATER. IF
IRRITATION OCCURS, GET MEDICAL ATTN; INGEST: CONSULT A
PHYSICIAN; OTHER: CHANGE CLOTHING AS REQUIRED TO AVOIDCARRYING
DUST PARTICLES INTO OTHER AREAS
* Fire Fighting Measures *
Flash Point:NONE
Extinguishing Media:MATERIAL IS NOT FLAMMABLE ; USE MEDIA APPROPRIATE
FOR SURROUNDING FIRE.
Fire Fighting Procedures:COMBUSTION PRODUCTS OF THIS MATERIAL MAY BE
TOXIC. USE A SELF-CONTAINED BREATHING APPARATUS WHEN FIGHTING FIRES
INVOLVING CHEMICAL PRODUCTS.
Unusual Fire/Explosion Hazard:NONE KNOWN
* Accidental Release Measures *
Spill Release Procedures:USE PROPER PERSONAL PROTECTION. VACUUM OR WET
CLEAN IF DUST IS INVOLVED. ANY VACUUM SYSTEM SHOULD BE EQUIPPED W/
AN OUTLET "HEPA" FILTER TO PREVENT REINTRODUCING ASBESTOS FIBERS TO
THE ATMOSPHERE.
*Handling and Storage *
Handling and Storage Precautions:HANDLE IN A MATTER TO MINIMIZE
FORMATION OR RETENTION OF AIRBORNE DUST. USE PROPER PERSONAL
PROTECTION FOR TASK AT HAND. CHECK W/YOUR SAFETY OFFICE!!!
Other Precautions:AS MANUFACTURED, LOCKED-IN ASBESTOS DOES NOT PRESENT
A HAZARD. ONLY WHEN THE ITEM IS SUBJECTED TO ABRASIVE ACTIONS &
DUST IS GENERATED, THEN ASBESTOS FIBERS MAY BE RELEASED & BECOME
AIRBORNE.
* Physical/Chemical Properties *
HCC:T6
Evaporation Rate & Reference:NONE
Solubility in Water:NOT SOLUBLE
Appearance and Odor:MANUFACTURED COMMODITY DESCRIBED BY LOGISTICS:
"ITEM-NAME"
Percent Volatiles by Volume:NONE
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
NONE KNOWN
Stability Condition to Avoid:NONE KNOWN
* Disposal Considerations *
Waste Disposal Methods:DUST SHOULD BE HANDLED AS A HAZARDOUS AIR
LANDFILLS APPROVED FOR ASBESTOS DISPOSAL. NOTE IF ITEM UNDER
CONSIDERATION FOR DISPOSAL IS "FRIABLE OR NON-FRIABLE".
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:USE ORGANIC VAPOR RESPIRATOR (AIR
PURIFYING/FRESH AIR). OBSERVE OSHA REGS (RESPIRATOR USE). PROVIDE
VENT (KEEP EXPOSURE LEVELS BELOW OSHA LIMITS). VAPOR PARTICULATE
LIMITS.
Ventilation:EXHAUST VENT SUFFICIENT TO KEEP AIRBORNE CONC (SOLVENT/
POLYISOCYANATES/HDI) BELOW TLV'S. REMOVE ALL IGNITION SOURCES.
Other Protective Equipment:FACE SHIELDS. THE USE OF LONG SLEEVE AND
LONG LEG CLOTHING IS RECOMMENDED.
Work Hygienic Practices:REMOVE AND WASH CONTAMINATED CLOTHING BEFORE
REUSE. WASH HANDS BEFORE EATING, SMOKING OR USING WASHROOM.
Supplemental Safety and Health
DEVELOP ISOCYANATE SENSITIZATION WHICH WILL CAUSE THEM TO REACT TO A
LATER EXPOSURE OF ISOCYANATES LEVELS WELL BELOW THE TLV VALUE OF
ISOCYANATES.
* Product Identification *
Kit Part:Y
* Composition/Information on Ingredients *
Ingred Name:ALIPHATIC ISOCYANATE (VAPOR PRESSURE: 0 MM HG)*
Other REC Limits:NONE SPECIFIED
MONOMER CONTENT LESS THAN 0.7% BASED ON RESIN SOLIDS AT TIME OF**
Other REC Limits:NONE SPECIFIED
Ingred Name:**MANUFACTURE. AFTER 3-6 MO STORAGE, THE FREE MONOMER
Other REC Limits:NONE SPECIFIED
Other REC Limits:NONE SPECIFIED
Ingred Name:N-BUTYL ACETATE (SARA III)
Fraction by Wt: <5%
Other REC Limits:NONE SPECIFIED
Ingred Name:XYLENES (O-,M-,P- ISOMERS)(SARA III)
Fraction by Wt: <5%
Other REC Limits:NONE SPECIFIED
Ingred Name:TOLUENE (SARA III)
Fraction by Wt: <5%
Other REC Limits:NONE SPECIFIED
HG)
Fraction by Wt: 5%
Other REC Limits:NONE SPECIFIED
Ingred Name:METHYL ISOBUTYL KETONE (SARA III)
Other REC Limits:NONE SPECIFIED
Ingred Name:METHYL ETHYL KETONE (2-BUTANONE) (MEK) (SARA III)
Other REC Limits:NONE SPECIFIED
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: VAPORS IRRITATING TO EYES/NOSE/
THROAT. INHALATION: IRRITATION, ACUTE NERVOUS SYSTEM DEPRESSION.
CHRONIC: PROLONGED CONTACT WILL CAUSE DEFATTING ACTION. INGESTION:
IRRITATION. ASPIRATION CAN CA USE CHEMICAL PNEUMONITIS. AS A RESULT
OF PREVIOUS REPEATED OVEREXPOSURE OR SINGLE LARGE DOSE, CERTAIN
INDIVIDUALS WILL
Effects of Overexposure:INHAL: DIFFICULT BREATHING, HEADACHE,
DIZZINESS, STAGGERING GAIT, CONFUSION, UNCONSCIOUSNESS, COMA. SKIN:
IRRIT (SWELLING/REDNESS/RASH). EYES: REDNESS, TEARING, SWELLING
W/STINGING. SKIN: SWELL/REDNES S/RASH. PROLONG/REPEAT--MOD IRRIT,
DRYING, SKIN CRACKING. INGEST: VOMIT. IRRIT. CORROSIVE TO
MOUTH/STOMACH/DIGEST TRACT.
Medical Cond Aggravated by Exposure:ASTHMA AND ANY OTHER RESPIRATORY
DISORDERS. SKIN ALLERGIES, ECZEMA, AND DERMATITIS.
* First Aid Measures *
First Aid:INHALATION: MOVE TO FRESH AIR. RESTORE BREATHING. ASTHMATIC
TYPE SYMPTOMS MAY DEVELOP (IMMED/DELAYED BY SEVERAL HRS). GET MED
AID. SKIN: REMOVE CONTAM CLOTHING. WASH AREA W/SOAP & WATER. WASH
CONTAM C LOTHING BEFORE REUSE. EYES: FLUSH WITH LUKEWARM WATER (LOW
INGESTION: DON'T INDUCE VOMIT. NOTHING BY MOUTH TO UNCONSCIOUS
PERSON. GET MED AID.
* Fire Fighting Measures *
Flash Point Method:TCC
Lower Limits:1%
Extinguishing Media:FOAM, ALCOHOL FOAM, CO2, DRY CHEMICAL, WATER FOG.
Fire Fighting Procedures:FULL FIRE FIGHT EQUIP W/SCBA & FULL PROTECT
CLOTH. USE WATER TO COOL CLOSED CNTNRS/PREVENT PRESSURE
BUILD-UP/AUTO IGNITE/EXPLOSION. HDI/IRRIT VAPORS GENERATED.
Unusual Fire/Explosion Hazard:KEEP FROM IGNITE SOURCES. CLOSED CNTNR
MAY EXPLODE W/HEAT. USE SPECIAL PRECAUTION W/APPLIC TO HOT SRFCS.
DURING EMERG COND, OVEREXPOS TO DECOMP PROD/HEALTH HZD.
* Accidental Release Measures *
Spill Release Procedures:EVACUATE ALL NON-ESSENTIAL PERSONNEL. REMOVE
ALL SOURCES OF IGNITION (FLAME, SPARK SOURCES, HOT SURFACES).
VENTILATE AREA. CONTAIN AND REMOVE WITH INERT ABSORBENT AND
NON-SPARKING TOOLS.
*Handling and Storage *
Handling and Storage Precautions:STORE IN BLDG IN COMPLIANCE W/OSHA
CLOSED CONTAINERS. STORE IN WELL VENT AREAS.
Other Precautions:KEEP CNTNRS TIGHT/UPRIGHT (PREVENT LEAKAGE). NO
PROLONGED BREATHING OF VAPORS/SPRAY MISTS. AVOID CONTACT
W/SKIN/EYES. DO NOT TAKE INTERNALLY. DO NOT HANDLE UNTIL THE SAFETY
PRECAUTIONS HAVE BEEN READ/ UNDERSTOOD. SMOKE ONLY IN SMOKING
AREAS.
* Physical/Chemical Properties *
HCC:F2
Vapor Density:> AIR
Viscosity:*
Solubility in Water:INSOLUBLE
Appearance and Odor:AMBER LIQUID WITH SOLVENT ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
WATER, AMINES, STRONG BASES, ALCOHOLS, METAL COMPOUNDS AND SURFACE
ACTIVE MATERIALS.
Stability Condition to Avoid:CONTACT WITH MOISTURE, MATERIALS WHICH
REACT WITH ISOCYANATES AND HIGH TEMPERATURES.
Hazardous Decomposition Products:BY HIGH HEAT/TEMPERATURE: CARBON
MONOXIDE, CARBON DIOXIDE, AND OXIDES OF NITROGEN, TRACES OF HCN AND
HDI.
* Disposal Considerations *
Waste Disposal Methods:WASTE MUST BE DISPOSED IN ACCORD W/FEDERAL,
STATE & LOCAL ENVIRONMENTAL CONTROL REGULATIONS. EMPTY CONTAINERS
MUST BE HANDLED W/CARE (PRODUCT RESIDUE/FLAMMABLE VAPOR). DON'T
| 1 | eyes_protection_mandatory |